CD-804MPBT. Service Manual - CD-804MPBT

R CD-80MPBT Service Manual - CD-80MPBT

CONTENTS Page Disassembly Instructions... Disassembly Diagram... Operation Check... 5 Block Diagram... 6 Alignment Locations... 7 Alignment Procedures... 8 Printed Circuit Boards... 9 Exploded Views (Panel)... 8 Exploded View Parts Lists (Panel)... 9 Exploded Views (Cabinet)... 0 Exploded View Parts Lists (Cabinet)... Exploded Views (Deck)... Exploded View Parts Lists (Deck)... 5 Schematic Diagram... 7 Electrical Parts List... Specifications... 0

DISASSEMBLY INSTRUCTIONS. Using the unlock key that came with the unit or a similar tool, unlock the Mounting Box and remove toward the rear of the unit.. Remove two screws (A) located on the rear of the top cabinet then remove the Top Cabinet.. Remove two screw (B) located on the rear of the bottom cabinet then remove the Bottom Cabinet.. Remove the screw (C) from on the front side of the base. 5. Remove two screws (D) from on the right side of the rear bracket. Remove the screw (E) and the screw (F) from on the left side of the side bracket. 6. Remove two screws (G) from under the front deck bracket then remove the Front Deck Bracket. Remove two screws (H) from under the rear deck bracket then remove the Rear Deck Bracket. 7. Take out the Panel and remove the Ring. Remove two screws (I) from each side of the base then remove the Base. 8. Remove two screws (J) from on the Heat Sink then remove the Spring Sheet. 9. Remove five screws (K) from on the Heat Sink then remove the Heat Sink. 0. Remove the screw (L) from on the back of the side bracket then remove the Antenna Clip.. Remove the screw (M) from on the back of the side bracket. Remove two screws (N) from on the main board then remove the Heat Sink (7809/DB5).. Remove two screws (O) from on the back of the side bracket then remove the Wire Clip.. Remove the screw (P) from on the right side of the side bracket then remove the IC Mounting Bracket.. Remove three screws (Q) from under the main board then remove the Main Board.

DISASSEMBLY DIAGRAM

GENERAL SPECIFICATIONS OF SIGNAL OPERATION CHECK Standard frequency Signal output Modulation FM AM FM AM AM FM Stereo 98. MHz (87.5, 07.9 MHz) 000 khz (50, 70 khz) mv 5 mv 00 Hz 0% MOD. khz 75kHz DEV. 6% for L only or R only pilot level 8% AF output level FM/AM Power source voltage DC.0V (Backup voltage is the same as this) AF load impedance ohm pure resistance Balance Center position of level Tone Center position The signal strength read in this section is voltage on the antenna. Test Diagram FRONT SPK. -SPEAKER RL. SPR. FL. SPK. -SPEAKER -SPEAKER RR. SPK. FR. SPE. -SPEAKER FRONT SPK. ACC (DV.V) BACK UP (.V) GROUND POWER ANTANNA MAIN UNIT ANT DISTORTION METER VTVM VTVM DUMMY ANTANNA MPX STEREOS MODULATOR AM SG FM SG 5

BLOCK DIAGRAM 6

ALIGNMENT LOCATIONS FM/MW/LW TUNER 7

FM ADJUSTMENT ALIGNMENT PROCEDURES Equipment Required AM IF/RF signal generator Solid-state voltmeter (SSVM) Regulated DC power supply -CH voltmeter Distortion meter FM Alignment Using FM Signal Generator Note: Press the radio power switch to on the radio. Signal generator output must be kept as low as possible to avoid overload and clipping. Step IF 76 khz Pilot Modulation - db Limiting Sens. FM SNC Adjustment FM Stereo S/N Auto Stop Sens. Generator Coupling FM RF Signal Generator to Antenna input. Signal Generator to antenna receptacle Signal Generator to antenna receptacle 98. MHz Dev. 5 khz L+R=90 % Int. khz 60dBµV output Signal Generator Connected to Antenna Signal Generator Connected to Antenna. Generator Display Setting Adjustment Remarks 0.7 MHz Adjust so that Sweep 98. MHz T0 maximum AF output output power and 60 dbµv minimum distortion 75 khz Dev 5% for L only 98. MHz VR05 Adjust to or R only pilot 76 khz level 0% 60 dbµv Adjust VR0 Output. 98. MHz VR0 Making db (±db) Limiting Sensitivity. VOR - VOL = 0 db 98. MHz 98. MHz VR06 (± db) @ 0 dbµ 98.MHz Adjust VR0 FM Int. khz 98.MHz VR0 Stereo S/N is the Dev. 75kHz. optimum. 98. MHz Adjustment Int. khz 98. MHz VR07 AF to stop station. Dev. 75kHz 8 dbµv Note: The tuner module is well-adjust and adjustment is not recommended. 8

MAIN BOARD PRINTED CIRCUIT BOARDS TOP VIEW 9

MAIN BOARD BOTTOM VIEW 0

FM TUNER BOARD

KEY BOARD TOP VIEW

KEY BOARD BOTTOM VIEW

CD SERVO BOARD TOP VIEW

CD SERVO BOARD BOTTOM VIEW 5

BLUETOOTH PCB BOARD TOP VIEW 6

BLUETOOTH PCB BOARD BOTTOM VIEW 7

PANEL EXPLODED VIEW 8

EXPLODED VIEW PARTS LIST PANEL Ref. No. Description RS Part No. Mfr s Part No. 5 6 7 8 9 0 5 6 7 8 9 0 5 6 7 8 9 0 5 Lens-B (S. OPC0000) MP VFD Lens-S (S. OPC0000) MAT Panel Top (Silver) X0. BT Panel Top (S. OP0) Panel Bottom (F) /777 Open Key/F (E-Silver) RE Knob Spring DECARING (S. OP0) VOL Back Light VOL Knob (E-Silver) Power Key (Crystal) SEL Key (Crystal) EQ Key (Crystal) Knob- Left AS/PS~6 Key (L-Up) (S. OP0) Button Back Light TA Key (Crystal) PTY Key (Crystal) AF Key (Crystal) Knob- Right BND/DSP (F) Knob (E-Silver) 7/MOD Key (L-Up) (S. OP0) MANU-SKIP 8-/9+ Key (L-Up) (S. OP0) SKIP Back Light Key Board ENCODER SRGP0000 (ALPS) LCD racket Real (E) CD00 LCD TN COLOR NEG X8 PIN CD007 B.LIGHT /WHITE Axis Post Right Side Block Contact Spring Left Side Block E-Ring Ø.5XX0.MM Screw ØX8 BA/ST Black 5-G0-Y 5-G9-0 6-G0-86B 5-G-80 5-F-00 5-G7-90E 6-85-00 5-G-80 5-G0-00 5-G5-90E 5-G-0B 5-G-0B 5-G-0B 5-G5-00 5-G-8 5-G-00 5-G-0B 5-G-05B 5-G-06B 5-G9-00 5-G8-90E 5-G7-8 5-G6-0 5-G-00-70-9 8-006-00 9-E00-00 7-0000-0Y 0-0007-09-60-00 5-E8-00 6-78008-00 5-E9-00 5-0000-00 0-008- 9

CABINET EXPLODED VIEW 0

EXPLODED VIEW PARTS LIST CABINET Ref. No. Description RS Part No. Mfr s Part No. Panel Ring (S. OPC0) 5-G-80 Base 5-E-00 Side Bracket 6-E005-0 5 CD MECH. CDM-68EUK W/O Bracket (A) 9-068- 6 Heat Sink (For Wire) 6-E006-00 7 Top Cabinet 6-B005-0 8 Bottom Cabinet (For Wire) 6-B0-0 9 Main Fiber 5-B00-00 0 Main Board -0000-088 Mounting Box (07) 6-07-0 Shade 8-69005-0 CD Windows Sheet -E00-00 Hook Shaft -D0-00 5 Hook Spring 6-E0-00 6 Hook 5-E7-00 7 Push Out Spring 6-E0-00 8 Panel Pole 5-E6-00 9 Base Back Light (F) (White) 5-E8-0 0 Front Board -70-8 0PIN Socket 5-F07-0 Eject Key/F (L-Up) (S. OPC0000) 5-G50-0 Eject Board -70-8 Right Bracket 9-E0-0 5 Damper Gear Ass y /9- T/Q 9-6-0 6 Middle Gear (F) 5-E0-00 7 Left Bracket 9-E0-0 8 Deck Front Bracket 9-E05-00 9 Deck Rear Bracket 9-B00-00 0 FM Tuner CET-0-SH 9-00-00 FM Cover 9-D0507-00 IC Mounting Bracket 9-60-00 BLUETOOTH PCB Board -000-0 Spring Sheet 9-B00-00 5 Heat Sink (7809/DB5) W/O Shaft 9-B0-0 6 Wire Clip.0MM 9-B5-00 7 Screw Ø5X8 HH 0-0508-0 8 Spring Washer M5 5-5000-00 9 Hexagon Nut M5 5-0005-00 0 Antenna Clip.0MM 9-B0-00

Ref. No. Description RS Part No. Mfr s Part No. 5 6 7 8 9 50 Screw ØX BH/ST Black Screw ØX6 PA/ST Black Screw Ø.6X BH/MS Screw Ø.6X5 BH/TAPTITE Screw Ø.6X6 BH/MS Screw Ø.6X6 PH/MS Black Screw Ø.6X8 BH/MS Screw Ø.6X0 BH/MS Screw M.6X0 PH/MS Screw ØX5 BH/MS 0-00- 0-006-0 0-060-0 0-0605-0 0-0606-0 0-0606-0 0-0608-0 0-060-0 0-060-00 0-0005-0

EXPLODED VIEW PARTS LIST CMD-09 Ref. No. Description RS Part No. Mfr s Part No. 5 6 Top W/O Brand Bottom CMD-09 PCB Board P-Button (S. OPC0000) TALK-Button (S. OPC0000) TALK Back Light 5-C090-0W 5-C09-0 -0000-088 5-C09-0 5-C095-0 5-C09-00

EXPLODED VIEW (DECK)

EXPLODED VIEW PARTS LIST (DECK) Ref. No. Description Parts No. Q ty 5 6 7 8 9 0 5 6 7 8 9 0 5 6 7 8 9 0 5 6 7 8 9 SENSOR SENSOR PCB SCREW COVER-UPPER LEVER DISC GUIDE UP BUSHING ROLLER ROLLER DISC SHAFT ROLLER PIN ROLLER PVC CAP B/K ROLLER PIN PULLEY PIN IDLE GEAR IDLE GEAR PULLEY BELT PULLEY GEAR ROLLEY LOCKER (L) CAM (L) S/P CAM (L) S/P RACK CAM (R) LOCKER GEAR RACK GEAR LOAD GEAR LOAD (D) GEAR LOAD (B) GEAR LOAD (A) PIN LOAD B/K GEAR MOTOR GEAR WORM GERVO PCB ASSY SPECIAL SCREW S/P RO (L) SUPPORT DAMPER S/P RO CHASSIS MAIN ST-G FR CA/H 0 TT * SECC T.0 POM (F0-0) POM (F0-0) POM (F0-0) SLICON SUS 0 SUML-NI (PLATE) PVC SECC T.0 SUML-NI (PLATE) SUML-NI (PLATE) POM (F0-0) POM (F0-0) CR-WRT POM (F0-0) POM (F0-0) POM (F0-0) SUS0WPB SUS0WPB POM (F0-0) POM (F0-0) POM (F0-0) POM (F0-0) POM (F0-0) POM (F0-0) POM (F0-0) SUML-NI (PLATE) SECC T.0 FF-050SH-90 POM (F0-0) GLASS EPOXY.T P/H TTS * SUS0WPB POM (F0-0) SUS0WPB SEEC T.0 5

EXPLODED VIEW PARTS LIST - CONTINUED (DECK) Ref. No. Description Parts No. Q ty 0 5 6 7 8 9 50 5 5 5 5 55 56 57 58 59 60 6 6 6 6 65 66 67 68 69 70 7 7 7 CLAMP DISC HOLD CLAMPER S/P CLAMPER TURN TABLE BASE PU PIN SIDE (A) SCREW PIN SIDE (B) DAMPER S/P BASE MOTOR GEAR PU (B) GEAR PU (A) SCREW MOTOR HOUSING GEAR SHAFT PU SCREW P CONT WIRE SPRING TENSION GEAR PU LEAD SCREW SWITCH SCREW PICK UP FPC WIRE SPRING PU FIBER PAPER S/P CAM TRANSIT SCREW INSULATOR COVER SWITCH WASHER PE S/P BASE POM (F0-0) SECC T.0 SUS0WPB ABS G/F 0% POM (F0-0) SUML-NI (PLATE) CA/H 0 M/S.7*.5 SUML-NI (PLATE) BUTHYL SUS0WPB RF-00CA-65 HYTRELL 556 POM (F0-0) CA/H 0 M/S * FF-050SH-90 POM (F0-0) KNN (PCD8) R/H (W/W) TTB*5 007 #8 SUS0WPB POM (F0-0) BSBM SW-0 B/H TTB.7*8 SF-C99 POLY AMIDE SUS T0. 0.55.5*8 PE SW- PE SUS0WPB 6 6

SCHEMATIC DIAGRAM (MAIN BOARD) 7

SCHEMATIC DIAGRAM (KEY BOARD) 8

SCHEMATIC DIAGRAM (CD SERVO BOARD) 9

SCHEMATIC DIAGRAM (BLUETOOTH PCB BOARD) 0

ELECTRICAL PARTS LIST Ref. No. Part No. Description Q ty PC BOARD ASSY, MAIN BOARD Q05,80 Q0,0/,60,67~6,80/9 Q8 Q05~7,0/,60//5/7~9,679/80,80/~ 6/8,8 IC80/ Q807 ZD60/ D80 D0,0/,66,67,650~,80/5/6/8/0 D80 ZD0 ZD605,80 ZD60/6 ZD60 ZD0 ZD80 IC60 IC70/ IC60 IC60 IC80 IC805 IC80 IC0 XT60 TUNER TO GND C7,8 C87 C5,0,60/,805~8 C07 C08,0/,607,60,8/8/9/,8/8 C8 C/ C9, C0/5/9,605 C60~ C60 C65/6 C60 0-005-00S 0-008-00 0-00-00 0-0875-07 0-07805-00 0-08550-0 0-0006-07 0-000-00 0-08-0 0-050-00 0-500-00 0-5006-00A 0-5005-00 0-50056-00 0-5009-00A 0-5000-00A 0-0-00 0-0558-06 0-06-00 0-0705-00 0-078-00 0-078- 0-0788-00 0-0957-00 0-0007-0 05-050-00A 05-600-00 05-60-00 05-60-0 05-60-0 05-60-0 05-605-00 05-65-0 05-60-00 05-6-0 05-6-0 05-670-00 05-67-0 05-600-00 TR. BD5 NPN TO-6 SAMSUNG TR. SA8 TRANSISTOR B0 TRANSISTOR SC875G IC-REGULATOR 78L05 TR. 8550C TO-9-B E.S.D. DIDOE NNCD6.G (5PIN) DIODE IN00 DIODE CHIP RLS8 06 ROHM DIODE IN50 ZENER DIODE.V 0.5W ZENER DIODE.6V 0.5W AT. ±% ZENER DIODE 5.V ±5% 0.5W ZENER DIODE 5.6V 0.5W ZENER DIODE 9.V ±5% 0.5W AT. ZENER DIODE 5.V 0.5W AT. TAPE ±% I. C. PTL IC KIA-558F IC OP6-00 RDS (MP+ESP) IC KIA705P IC TDA78A (X0W) Y REGULATOR L7805CV (GROUND TAP) REGULATOR LC-78L8 IC TC957F CRYSTAL HC-9/µS 7.MHZ AXIAL CER CAP 000PF ±0% TP. CHIP CAP PF ±5% NPO 060 SMT CHIP 00PF ±5% NPO 060 SMT CHIP 000PF ±0% X7R 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP 05PF/5V Y5V ±0% 060 SMT CHIP 0.05µF ±0% X7R 060 SMT CHIP CAP PF ±5% NPO 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP CAP 7PF ±5% NPO 060 SMT CHIP 700PF ±0% X7R 060 SMT CHIP CAP 0PF ±5% NPO 060 SMT 8

ELECTRICAL PARTS LIST - CONTINUED Ref. No. Part No. Description Q ty C8 C,606,67,69,87 C8 C70 C06,60~,809,8 C07,70 C68,86 C80 C0,5,0,608,6/8,8,80/,85 C650 C65 C6/7,,60,80~ C6/ C6//9,6/ C85 C609 C6~7,70~6 R85 R9 R0,/5,0,60,70,857 R8,60 R0,0,09,605/5/76,76~9,87/5 R0/9,9,06,/,60///5,6/,6 /7/8,65/5/6,80~,80,87/9,85/8,85 //9,86 R89,8,80,860 R6//6/9 R65 R88 R69,650 R80 R65/6 R,850 R,609,65,6/ 05-67-0 06-007-0 06-07-0 06-07-0 06-606-0E 06-607-0 06-66-0 06-68-00S 06-676-0 06-500-0L 06-5005-0 06-5005-0 06-50-0 06-505-0 06-505-0 06-507-0E 06-5075-0 07-0500-00 07-6000-00 07-600-00 07-60-00 07-60-00 07-60-00 07-60-00 07-605-00 07-6-00 07-65-00 07-655-00 07-68-00 07-60-00 07-6-00 07-6-00 CHIP CAP 0.7µF ±0% X7R 060 SMT E. CAP 00µF 0V (6X5) SPUER MINI E. CAP 0µF 0V (Ø6MM MINI) E. CAP 0µF 0V (Ø8X5MM) E. CAP 0µF/6V (X5MM RC) E. CAP 00µF 6V (Ø6X5MM) E. CAP µf 6V (Ø5X5MM) E. CAP 00µF 6V 05 C E. CAP 7µF 6V (6X5) E. CAP 0.µF 50V ØX5MM LELON E. CAP µf 50V (ØX7MM) E. CAP µf 50V (ØX5MM) E. CAP 0.µF 50V (ØX5MM) E. CAP.µF 50V (X5) E. CAP.µF 50V (ØX7 MM) E. CAP 0.7µF/50V (X5MM RC0) E. CAP.7µF 50V (X7MM) RES. 0Ω /W CHIP RES. 0Ω ±5% 060 SMT CHIP RES. 0Ω ±5% 060 SMT CHIP RES. 00Ω ±5% 060 SMT CHIP RES. kω ±5% 060 SMT CHIP RES. 0kΩ ±5% 060 SMT CHIP RES. 00kΩ ±5% 060 SMT CHIP RES. MΩ ±5% 060 SMT CHIP RES. 0kΩ ±5% 060 SMT CHIP RES..5kΩ ±5% 060 SMT CHIP RES..5MΩ ±5% 060 SMT CHIP RES..8kΩ ±5% 060 SMT CHIP RES. Ω ±5% 060 SMT CHIP RES. 0Ω ±5% 060 SMT CHIP RES..kΩ ±5% 060 SMT 5 7 0 8 5 8 7 5 R66~,675/8/9,70/,805~8,8,89,855 07-6-00 /8 CHIP RES. kω ±5% 060 SMT R6,66,66,680 R70/9,70/5 R08,67 R/,69/0,657/8 R86 07-6-00 07-67-00 07-6-00 07-6-00 07-6-00 CHIP RES. 0kΩ ±5% 060 SMT CHIP RES. 7kΩ ±5% 060 SMT CHIP RES. 0Ω ±5% 060 SMT CHIP RES..kΩ ±5% 060 SMT CHIP RES. kω ±5% 060 SMT 6

ELECTRICAL PARTS LIST - CONTINUED Ref. No. Part No. Description Q ty R08,607 R6 R R67/8 R6 R/9/0,60//6,6 R~6,05/7,0,608,659,667/8,67/7,7 06/7,7/,8,87/6/9,856 R8~7 R6 R809~ R6 R705/8,7/ R6 L80 MB L80 07-6-00 07-69-00 07-69-00 07-69-00 07-67-00 07-67-00 07-67-00 07-67-00 07-65-00 07-656-00 07-675-00 07-68-00 07-68-00 09-7000-0-0000-088 5-70-J CHIP RES. kω CHIP RES. 90Ω ±5% 060 SMT CHIP RES..9kΩ ±5% 060 SMT CHIP RES. 90kΩ ±5% 060 SMT CHIP RES. 70Ω ±5% 060 SMT CHIP RES..7kΩ ±5% 060 SMT CHIP RES. 7kΩ ±5% 060 SMT CHIP RES. 70kΩ ±5% 060 SMT CHIP RES. 5.kΩ CHIP RES. 560Ω ±5% 060 SMT CHIP RES. 7.5kΩ ±5% 060 SMT CHIP RES. 8.kΩ ±5% 060 SMT CHIP RES. 8kΩ ±5% 060 SMT MICRO INDUCTOR 0UH AXIAL TYPE BT-CDD00X. (/5,7~) YMB D/S.6X5X8 RING COIL Ø7XMM V-TYPE 7 5 PC BOARD ASSY, FM TUNER BOARD Q0/6 Q0~,0 D07 D0 D06 IC0 IC0 C6 C5/6 C C7 C6 C C C5,00/ C09,9, C08/9,//8 C0 C C C0 0-0785-00C 0-0875-07 0-08-00 0-08-00A 0-08-0 0-00-00 0-075-00 05-00-0 05-0-0 05-050-0H 05-050-00H 05-05-00 05-090- 05-60-0 05-60-0 05-60-0 05-6-0 05-6-0 06-007-0 06-07-0 06-606-0 TRANSISTOR SC785 NEC TRANSISTOR SC875G DIODE IN-8 DIODE IM-8 AT. (TAPPING) DIODE CHIP PLS8 06 ROHM I.C. LA-0 I.C. LA-75 CHIP CER CAP 000P 50V K Y5P TA CHIP CAP CMX7RK5AT AXIAL CER UP050B0K-B-B7 ±0% AXIAL UP050SL 0J-B-B (±5%) AXIAL CER CAP 0.µF +80/-0% POLY CAP 000PF ±5% CHIP 000PF ±0% X7R 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP 00PF ±0% X7R 060 SMT E. CAP 00µF 0V (Ø5X7MM MINI) E. CAP 0µF 0V (Ø6MM MINI) E. CAP 0µF 6V (ØX7MM) 5

ELECTRICAL PARTS LIST - CONTINUED Ref. No. Part No. Description Q ty C,8, C0,5/7, C J0~5 R V0 VR06 R9 R6/8 R6 J5~5,R5 R8,J6 R09,,08,9,00 R00,0,/7,9 R0 R, R00 R50 R5 R07,0, R06,5 R R7 T0 CF0/ VR0 VR07 VR05 VR0 06-675-0 06-5005-0 06-505-0C 07-05000-5 07-05-6 07-050-6 07-059-6 07-057-6 07-057-6 07-058-5 07-6000-00 07-600-00 07-60-00 07-60-00 07-60-00 07-65-00 07-68-00 07-6-00 07-6-00 07-6-00 07-69-00 07-67-00 07-668-00 07-675-00 08-707-0 09-070-0-00-5 7-00-06S 7-00-06S 7-050-06S 7-050-06S E. CAP.7µF 6V (ØX7MM) E. CAP µf 50V (ØX7MM) E. CAP.µF 50V (ØX5MM) CHIP RES. 0Ω /0W RES. kω /6W RES. 0kΩ /6W ±5% RES..9kΩ /6W RES..7kΩ /6W RES. 7kΩ /6W CHIP RES. 80kΩ /0W CHIP RES. 0Ω 060 SMT CHIP RES. 0Ω ±5% 060 SMT CHIP RES. kω ±5% 060 SMT CHIP RES. 0kΩ ±5% 060 SMT CHIP RES. 00kΩ ±5% 060 SMT CHIP RES. 5kΩ ±5% 060 SMT CHIP RES..8kΩ ±5% 060 SMT CHIP RES..kΩ ±5% 060 SMT CHIP RES. kω ±5% 060 SMT CHIP RES. 0Ω ±5% 060 SMT CHIP RES..9kΩ ±5% 060 SMT CHIP RES. 7kΩ ±5% 060 SMT CHIP RES. 68kΩ ±5% 060 SMT CHIP RES. 7.5kΩ ±5% 060 SMT TFT 0.7MHZ H=7.5MM FILTER SEF 0.7MJ MURATA ±0K LA0 TUNER BOARD 7X0X. SEMI-FIXED EVNDAA0B (0KB) SEMI-FIXED EVNDAA0B5 V SEMI-FIXED EVNDAA0B5 SEMI-FIXED EVNDAA0B5 (50KΩ) 5 5 5 PC BOARD ASSY, KEY BOARD LED~ IC60 C60/~9,6~8 C60 C R6~50 R6 R6 0-0-06M 0-6-0 05-60-00 05-60-0 05-6-00 07-60-00 07-60-00 07-60-00 SMD LED S7DNB-5 0805 BLUE IC PT6 VFD CONTROLLER CHIP 00PF ±5% NPO 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP 0PF ±5% NPO 060 SMT CHIP RES 00Ω ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES 0kΩ ±5% 060 SMT 0 8

ELECTRICAL PARTS LIST - CONTINUED Ref. No. Part No. Description Q ty R608 (PTY) R6 R609 R60,66 R6 R605,65/7 R6 R6 R606,68 R65 R69,607 (TA) R6 R60 R60 R60 R6 KB BAND,DSP,RES VOL 07-6-00 07-65-00 07-65-00 07-68-00 07-68-00 07-6-00 07-6-00 07-67-00 07-6-00 07-69-00 07-67-00 07-67-00 07-656-00 07-656-00 07-668-00 07-68-00-70-9 6-007-00K 6-00-0 8-006-00 5-M07-0 7-B088-00 CHIP RES.kΩ ±5% 060 SMT CHIP RES.5kΩ ±5% 060 SMT CHIP RES 5kΩ ±5% 060 SMT CHIP RES 80Ω ±5% 060 SMT CHIP RES.8kΩ ±5% 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES.kΩ ±5% 060 SMT CHIP RES.7kΩ ±5% 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES 9kΩ ±5% 060 SMT CHIP RES 70Ω ±5% 060 SMT CHIP RES 7kΩ ±5% 060 SMT CHIP RES 5.6kΩ ±5% 060 SMT CHIP RES 56kΩ ±5% 060 SMT CHIP RES 680Ω ±5% 060 SMT CHIP RES 8kΩ ±5% 060 SMT CD-F7 VFD KB D/S.XX8.6MM TACT SW. DCT/0.MM PIN TACT SW. KPS-07SW H=.5 KIE SMD ENCODER SRGP0000 (ALPS) 0PIN PLUG VFD BJ88GNK (FUTABA) CDX. 6 PC BOARD ASSY, SDK/CD SERVO BOARD Q~6,8 Q,0/ Q7 Q0/ D, D5,6 D6,65 ZD0 D D D7 U U5 U U U 0-000-00 0-008-00 0-05- 0-0875-07 0-00-00 0-08-0 0-08-00A 0-500-00A 0-5006-00 0-5005-00 0-505-00 0-096-00 0-0959-00 0-0976-00 0-099-00 0-M00-0 TR. KRC0S TR. SA8 TRANSISTOR SD5M TRANSISTOR SC875G IR LED MIE AMC DIODE CHIP RLS8 06 ROHM DIODE IN-8 AT. (TAPPING) ZENER DIODE.V 0.5W AT. ZENER DIODE.6V 0.5W ZENER DIODE 5.V 0.5W 5.V ZENER DIODE (SMD06) IC SIL 96 IC KA959D IC S5L 976X0-EORN IC S5L99X0-EORO IC X DRAM SI700B (FUJITSU DICE) 6 5

ELECTRICAL PARTS LIST - CONTINUED Ref. No. Part No. Description Q ty X0 C0,6,/,5/7/9 C9 C7, C0,/6/7,0,0/,9,9 C00//6/8,9,//5,///6~8,~ /5/7,/7/8,//6/8,0~9,5,00/ ~6/8 C5/6 C9 C0 C07, C07 C0/ C C05, C8 C0,/ C5 C6 C0,8 C0,0/9,8,0/9~ C5, C0/ R0 R05 0-0069-00 05-606-0 05-600-00 05-60-0 05-60-0 05-60-0 05-65-0 05-65-0 05-60-00 05-6-0 05-6-0 05-60-00 05-6-0 05-69-00 05-67-0 05-67-00 05-668-0 05-68-00 06-007-0 06-607-5 06-676-5 06-505-0 07-0507-00 07-050-6A CRYSTAL HC-9/US 6.9MHZ TAN CAP 0UF 6V ±0% (.5X7) CHIP CAP PF ±5% NPO 060 SMT CHIP 000PF ±0% X7R 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP 500PF ±0% X7R 060 SMT CHIP 0.05µF ±0% X7R 060 SMT CHIP CAP PF ±5% NPO 060 SMT CHIP 00PF ±0% X7R 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP CAP PF ±5% NPO 060 SMT CHIP 0.0µF ±0% 060 SMT CHIP 90PF ±5% NPO 060 SMT CHIP 700PF ±0% X7R 060 SMT CHIP CAP 0.7µF ±5% (+80/-0%) CHIP 0.068µF ±0% 060 SMT CHIP 80PF ±5% 060 SMT E. CAP 00µF 0V (6X5) SUPER MINI E. CAP CHIP 00µF 6V Ø6.X5.5 E. CAP CHIP 7µF 6V Ø5X5.5 E. CAP.µF 50V (X5) RES..7Ω /W RES. 0kΩ /6W (TAPPING) 7 9 8 R0,0,0~7,/6,,5//6/8,0 07-6000-00 CHIP RES 0Ω 060 SMT R6,55,6,0 R05 R0,/ R9/0,6/7,7/8,06,/ R/,/5 R0,5 R5/6,,0,, R R R0,, R0//9 R00/,,5 07-605-00 07-600-00 07-60-00 07-60-00 07-60-00 07-605-00 07-65-00 07-68-00 07-60-00 07-6-00 07-6-00 07-6-00 CHIP RES.5Ω 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES 0kΩ ±5% 060 SMT CHIP RES 00kΩ ±5% 060 SMT CHIP RES MΩ ±5% 060 SMT CHIP RES 5kΩ ±5% 060 SMT CHIP RES 80Ω ±5% 060 SMT CHIP RES 0kΩ ±5% 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES.kΩ ±5% 060 SMT CHIP RES. 0kΩ ±5% 060 SMT 9 6 6

ELECTRICAL PARTS LIST - CONTINUED Ref. No. Part No. Description Q ty R6 R8 R0 R60,08 R0/, R/ R6,00 R,6~0,5~50///9,6,0~/5~ 9 R0//8,7,07,0 R07 R,09,7~ R/9 R09 SW0 07-67-00 07-67-00 07-6-00 07-6-00 07-69-00 07-69-00 07-67-00 07-67-00 07-67-00 07-668-00 07-68-00 07-68-00 07-69-00 --0 6-000-0 CHIP RES..7kΩ ±5% 060 SMT CHIP RES. 70kΩ ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES. 0kΩ CHIP RES.9kΩ ±5% 060 SMT CHIP RES 9kΩ ±5% 060 SMT CHIP RES 70Ω ±5% 060 SMT CHIP RES.7kΩ ±5% 060 SMT CHIP RES. 7kΩ ±5% 060 SMT CHIP RES. 68kΩ ±5% 060 SMT CHIP RES. 8.kΩ ±5% 060 SMT CHIP RES 8kΩ ±5% 060 SMT CHIP RES. 9kΩ ±5% 060 SMT PCB CDX.0.. SERVO D/S MICRO SWITCH MPU07MLBO (MIC) 6 8 PC BOARD ASSY, LINE OUT BOARD C707/8 R7/ RCA 06-5005-0 07-60-00 0-060-08 E. CAP µf 50V (ØX5MM) CHIP RES kω ±5% 060 SMT RCA CABLE WIRE 60MM GREY PC BOARD ASSY, FRONT BOARD Q R R R7 R R R6 R,5 EJ 0-08050-0 0-0-06M 0-0000- 0-070-0J 07-05-00 07-6000-00 07-60-00 07-60-00 07-69-00 07-67-00 07-68-00-70-8 6-00-0A 6-577-00A 5-0000-06 5-0000-07 5-0000-08 5-5-0 5-F07-0 TR. 8050C TO-9-B SMD LED S7DNB-5 0805 BLUE LED ØMM RED (WIDE ANGLE) PLAMP V 0MM X7 K.T. RES 0Ω /W CHIP RES 0Ω ±5% 060 SMT CHIP RES 0kΩ ±5% 060 SMT CHIP RES 00kΩ ±5% 060 SMT CHIP RES 9kΩ ±5% 060 SMT CHIP RES.7kΩ ±5% 060 SMT CHIP RES 80Ω ±5% 060 SMT CD-F7 F/EJB PCB.X8.X.5 TACT SW KPS-07SW TAPPING PUSH SW SPPB5 ALPS RAINBOW WIRE #0 6PIN 00MM RAINBOW WIRE #0 7PIN 00MM RAINBOW WIRE #0 8PIN 00MM RAINBOW WIRE # 5PIN PIN 0PIN SOCKET 7

ELECTRICAL PARTS LIST - CONTINUED Ref. No. Part No. Description Q ty PC BOARD ASSY, BLUETOOTH PCB BOARD Q678 Q77 Q LED, LED Q U5 U U U U X C,,0/ C5,7,/,/,/ C8 C,,6,0/6/8,/5/6/8,, C6/9 C, C8, C65 C9,,0 C5/7 R8,0/7 R, R,6,7,/6 R8,9,0/5/6/9, R R9 R0 R,,67 R67 R8 R R/5 R R, R5,/ 0-008-00 0-0875-07 0-0875-07K 0-0-00F 0-0-0F 0-0080-0 0-07-00 0-08-0 0-7-00 0-655-00 0-58-00 0-0096-00 05-605-00 05-606-0 05-60-0 05-60-0 05-605-00 05-60-00 05-6-00 05-6-0 05-60-00 05-67-00 07-6000-00 07-600-00 07-60-00 07-60-00 07-60-00 07-6-00 07-6-00 07-6-00 07-6-00 07-67-00 07-67-00 07-6-00 07-6-00 07-67-00 07-65-00-000-0 TR. SA8 TRANSISTOR SC875G TR. SC875G NPN SOT- KEC SMD LED PGH GREEN STANLEY SMD LED PGH RED STANLEY BHF RESET IC ASM80SUR-T -SOT VOLTAQE REGULATOR LD7S BTR0A-BHF (MODULE) VOLTAGE GEGULATOR AT7EA D655 PQFP (HANDSFREE DSP) MC58SD SSOP (CODEC) CRYSTAL.096MHZ HC-9/US TAN. CAP µf 6V ±0% TAN. CAP 0µF 6V ±0% 06 SMD CHIP 0.0µF ±0% X7R 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP 05PF/5V Y5V ±0% 060 SMT CHIP CAP PF ±5% NPO 060 SMT CHIP 0PF ±5% NPO 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP CAP PF ±5% NPO 060 SMT CHIP 70PF ±5% NPO 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES 0kΩ ±5% 060 SMT CHIP RES 00kΩ ±5% 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES 0kΩ ±5% 060 SMT CHIP RES 70Ω ±5% 060 SMT CHIP RES 70kΩ ±5% 060 SMT CHIP RES.kΩ ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES 7kΩ ±5% 060 SMT CHIP RES 5.kΩ BLUETOOTH PCB D/S 55XX0.8MM 8 5 7 8

ELECTRICAL PARTS LIST - CONTINUED MTC CON, IC Q D/,6 D ZD, ZD C C C5 C C6 C R5 R6/7 R R6 R0 R R R8 R L Ref. No. Part No. Description Q ty -08-00 BLUETOOTH MIC -66±DB (CM605/T) 6-0005-0 Ø.5MM JACK (PIN) W/SW 6-0007-00K TACT SW. DCT/0.MM PIN 5-90-06 6P SOCKET DIP.0MM (CWB) PC BOARD ASSY, JB. EL DRIVER SECTION 0-005-00S TR. BD5 NPN TO-6 SAMSUNG 0-0875-07 TRANSISTOR SC875G 0-08-00A DIODE IN-8 AT. (TAPPING) 0-08-0 DIO CHIP RLS8 06 ROHM 0-50068-00A ZENER DIODE 6.8V 0.5W AT. 0-5000-00A ZENER DIODE 0V 0.5W AT. TAPE 05-057-00H AXIAL UP050F7Z-B-BZ +80/-0% 05-60-0 CHIP 0.µF ±0% X7R 060 SMT 05-68-00 CHIP CAP 800PF (±0%) NPO 060 SMT 06-67-0 E. CAP 0µF 6V (Ø6.XMM) 06-676-0 E. CAP 7µF 6V (6X5) 06-506-00 E. CAP µf 50V 07-050-0 RES.Ω /W 07-6000-00 CHIP RES 0Ω 060 SMT 07-65-00 CHIP RES.5kΩ ±5% 060 SMT 07-6-00 CHIP RES kω ±5% 060 SMT 07-6-00 CHIP RES.kΩ ±5% 060 SMT 07-6-00 CHIP RES kω ±5% 060 SMT 07-67-00 CHIP RES 70Ω ±5% 060 SMT 07-656-00 CHIP RES 560Ω ±5% 060 SMT 07-668-00 CHIP RES 6.8kΩ ±5% 060 SMT 5-000-00 VFD TRANS EE- SAGAMI 9

SPECIFICATIONS T. H. D... Less than 0.5% Signal to Noise Radio... More than 55 db Channel Separation... More than 5 db Frequency Response... 0Hz - 8kHz Stereo Separating (FM)... 0 db (at khz) Signal to Noise Ratio (FM)... Better than 60 db Output Power... X 0W Speaker Output Impedance... To 8 ohm Power Source...DC V, Negative ground. Frequency Range... FM 87.5 07.9 MHz... AM 50-70 khz Sensitivity... FM µv (S/N=0dB)... AM 6 dbµ (S/N=0 db) Specifications are subject to change without notice. 0