Full Panel Detachable High Power FM/MW/LW Stereo Receiver Compact Disc Player

FILE NO. Service Manual Full Panel Detachable High Power FM/MW/LW Stereo Receiver Compact Disc Player FXD-RS60RM/XE 7870 SEL/SET OPEN VOLUME/ A~Z/0~9 50W x LOU/ENT BAND IR MANU/SKIP EQ DIR POWER DISP MP AS/PS PAU SCN RPT SHF 5 DISC 6 DISC PTY AF TA MODE SW FXD-RS60RM Contents Specifications... Disassembly Instructions... Disassembly Diagram... Operation Check...5 Block Diagram...6 Alignment Locations...7 Alignment Procedures...8 Printed Circuit Boards...9 Service Part List... 0 Exploded View (Panel)... Exploded View Parts List (Panel)... Exploded View (Cabinet)... Exploded View Parts List (Cabinet)... Exploded View (Deck)... 6 Exploded View Parts List (Deck)... 7 Schematic Diagrams... 9 Electrical Parts List... REFERENCE NO: SM-0600009

SPECIFICATIONS FM TUNER Frequency Range... FM 87.5-08.0 MHz (50 KHz Step) Sensitivity... FM µv (S/N=0 db) Stereo Separating (FM)...0 db (at khz) Signal to noise ratio (FM)...Better than 50 db AM TUNER Frequency Range... MW 5-60 khz (9 KHz Step) Sensitivity...MW dbµ (S/N=0 db) Signal to Noise Radio... More than 5 db LW TUNER Frequency Range...LW - 88 khz Sensitivity...LW 5 dbµ (S/N=0 db) CD PLAYER Frequency Response...0Hz - 0,000Hz Signal to Noise Radio... More than 65 db Channel Separation... More than 60 db T. H. D...Less than 0.0% AUDIO AMPLIFIER & GENERAL Output Power... X 50 W Speaker Output Impedance... ohm Power Source...DC V, Negative ground. Specifications are subject to change without notice.

DISASSEMBLY INSTRUCTIONS. Using the unlock key that came with the unit or a similar tool, unlock the Mounting Box and remove toward the rear of the unit.. Remove two screws (A) located on the rear of the side bracket then remove the Bottom Cover.. Remove two screws (B) located on the rear of the side bracket then remove the Bottom Cabinet.. Take out the Panel and the Ring. Remove the screw (C) from on the front of the base. 5. Remove two screws (D) from on the left side of the side bracket. Remove two screws (E) from on the right side of the side bracket then remove the Deck. 6. Remove two screws (F) from each side of the base then remove the Base. 7. Remove two screws (G) from on the left side of the side bracket then remove Spring Sheet. Remove five screws (H) from on the left side of the side bracket then remove the Heat Sink. 8. Remove the screw (I) from on the back of the side bracket then remove the ISO Antenna Socket /Short W /Holder. 9. Remove the screw (J) from on the back of the side bracket and remove two screws (K) from on the main board then remove the Heat Sink (7809/DB5). 0. Remove the screw (L) from on the back of the side bracket the remove the 6PIN ISO Socket.. Remove three screws (M) from under the main board then remove the Main Board.

DISASSEMBLY DIAGRAM

GENERAL SPECIFICATIONS OF SIGNAL OPERATION CHECK Standard frequency Signal output Modulation FM MW LW FM MW LW MW FM Stereo 98. MHz (87.5, 08 MHz) 000 khz (5, 60 khz) 00 khz (, 88kHz) mv 5 mv 5 mv 00 Hz 0% MOD. khz 75kHz DEV. 6% for L only or R only pilot level 8% AF output level FM/MW/LW Power source voltage DC.0V (Backup voltage is the same as this) AF load impedance ohm pure resistance Balance Center position of level Tone Center position The signal strength read in this section is voltage on the antenna. Test Diagram FRONT SPK. -SPEAKER RL. SPR. FL. SPK. -SPEAKER -SPEAKER RR. SPK. FR. SPE. -SPEAKER FRONT SPK. ACC (DV.V) BACK UP (.V) GROUND POWER ANTANNA MAIN UNIT ANT DISTORTION METER VTVM VTVM DUMMY ANTANNA MPX STEREOS MODULATOR AM SG FM SG 5

BLOCK DIAGRAM 6

ALIGNMENT LOCATIONS FM/MW/LW TUNER 7

ALIGNMENT PROCEDURES FM ADJUSTMENT Equipment Required AM/FM IF/RF signal generator Solid-state voltmeter (SSVM) Regulated DC power supply -CH voltmeter Distortion meter FM Alignment Using FM Signal Generator Note: Press the radio power switch to on the radio. Signal generator output must be kept as low as possible to avoid overload and clipping. Step Generator Generator Display Adjustment Remarks Coupling Setting Stereo Signal 98. MHz Adjust AF Separation Generator Int. khz 98. MHz VR output power to antenna Dev. 75 khz at maximum receptacle L+R = 90 % separating pilot = 0 % more than 0 db FM SNC 98. MHz Stereo Separation Adjustment Dev. 75 khz 98. MHz 98. MHz VR 5 db (±5 db) L+R=90 % @ 0 dbµ Int. khz 60dBµV output Stop Signal Generator 98. MHz Adjust AF to SENS. to antenna Mod. khz 98. MHz VR stop station. receptacle Dev 75kHz Note: The tuner module is well-adjust and adjustment is not recommended. 8

MAIN BOARD PRINTED CIRCUIT BOARDS TOP VIEW 9

MAIN BOARD BOTTOM VIEW 0

ISO PCB BOARD

KEY BOARD TOP VIEW

KEY BOARD BOTTOM VIEW

CD SERVO BOARD TOP VIEW

CD SERVO BOARD BOTTOM VIEW 5

REMOTE BOARD TOP VIEW 6

REMOTE BOARD BOTTOM VIEW 7

FRONT & DETACHABLE BOARD TOP VIEW 8

FRONT & DETACHABLE BOARD BOTTOM VIEW 9

SERVICE PARTS LIST Ref. No. Description Parts No. 5 PANEL ASSEMBLY CD MECHANISM ASSEMBLY MAINBOARD ASSEMBLY RC ASSEMBLY TRIM RING RP60RM/XE-PA RP60RM -CDMECH RP60RM-MB RP60RM/XE-RC RP5-67-80D 0

PANEL EXPLODED VIEW

EXPLODED VIEW PARTS LIST (PANEL) *Following part list is only for reference, not supplied as service parts Ref. No. Description RS Part No. Mfr s Part No. 5 6 7 8 9 0 5 6 7 8 9 0 5 6 7 Lens; (Mirror Effect) RDS FXD-RS60RM T. Panel (S. OPC0) FXD W/SW Panel Bottom Sensor Lens (PMS C) Left Panel (S. OP0) Right Panel (S. OP0) Encoder (E-Silver) Decorative Ring Ring Inside Encoder Open Key (S. OP0) TUN BND Knob Spring SEL/SET Knob (L-Up) (S. OPC0) EQ Key (L-Up) (S. OPC0) Power/DISP/6Discs Key (L-Up) (S. OPC0) PTY-MODE Key (L-Up) (S. OP0) BAND/NANU/-SKIP Key (L-Up) (S. OP0) Key Board Encoder SRGP0000 (ALPS) LCD Cover CD58 LCD TN NEG Blue MASK PIN Type LED B.L. QB000-09.5X99 WHT Axis Post Right Side Block Contact Spring Left Side Block E-Ring Ø.5XX0.MM Screw ØX8 BH/ST Black RP5-95-0 RP5-9-80 RP5-9-00 RP5-96-W RP5-9-80 RP5-9-8B RP5-96-90E RP5-9-00 RP5-97-00 RP5-95-80 RP6-60-00 RP5-9-8 RP5-90-8 RP5-99-8 RP5-98-8 RP5-9-8 RP-090-08 RP8-006-00 RP9-E0-0 RP7-0580-Y RP0-A560-09 RP-60-00 RP5-E8-00 RP6-78008-00 RP5-E9-00 RP5-0000-00 RP0-008-0

CABINET EXPLODED VIEW

EXPLODED VIEW PARTS LIST (CABINET) *Following part list is only for reference, not supplied as service parts Ref. No. Description RS Part No. Mfr s Part No. 5 6 7 8 9 0 5 6 7 8 9 0 5 6 7 8 9 0 5 6 7 8 9 0 Panel Ring (S. OPC0) Base (Reset + FLASHING LED) Side Bracket (ISO) CD MECH. CDM-68EUK W/O Bracket (A) Heat Sink (ISO) Top Cabinet Bottom Cabinet (ISO) Main Fiber Main Board Mounting Box (07) Shade CD Windows Sheet Hook Shaft Hook Spring Hook Push Out Spring Panel Pole Base B.L. Front Board 0PIN Socket EJ Knob (L-Up) (S. OPC0000) Eject Board Right Bracket Damper Gear ASS Y /9- T/Q Middle Gear (F) Left Bracket Deck Front Bracket Deck Rear Bracket FM Cover MITSVMI Tuner FAE-7-A9 6PIN ISO Socket W/RCA/CDC/AUXIN (SANYO) Spring Sheet Heat Sink (7809/DB5) W/O Shaft Screw Ø5X8 HH Spring Washer M5 Hexagon Nut M5 ISO Antenna Socket/Short W/Holder Antenna Bracket Screw ØX CH/MA Black RP5-67-80D RP5-E5-0 RP6-E00-0 RP9-068- RP6-E00-00 RP6-B005-0 RP6-B006-0 RP5-B00-00 RP-09-05 RP6-07-0 RP8-69005-0 RP-E00-00 RP-D0-00 RP6-E0-00 RP5-E7-00 RP6-E0-00 RP5-E6-00 RP5-98-00 RP-090-5 RP5-F07-0 RP5-99-0 RP-090-5 RP9-E0-0 RP9-6-0 RP5-E0-00 RP9-E0-0 RP9-E05-00 RP9-B00-00 RP9-D0507-00 RP9-007-0 RP5-6-6 RP9-B00-00 RP9-B0-0 RP0-0508-0 RP5-5000-00 RP5-0005-00 RP9-6-00 RP5-65-00 RP0-00-09H

Ref. No. Description RS Part No. Mfr s Part No. 5 6 7 8 9 Screw ØX BH/MS Black Screw ØX6 PA/ST Black Screw Ø.6 X BH/MS Screw Ø.6 X 5 BH/TAPTITE Screw Ø.6 X 6 BH/MS Screw Ø.6 X 6 PH/MS Black Screw Ø.6 X 8 BH/MS Screw Ø.6 X 0 BH/MS Screw M.6 X 0 PH/MS RP0-00- RP0-006-0 RP0-060-0 RP0-0605-0 RP0-0606-0 RP0-0606-0 RP0-0608-0 RP0-060-0 RP0-060-00 5

EXPLODED VIEW (DECK) 6

EXPLODED VIEW PARTS LIST (DECK) *Following part list is only for reference, not supplied as service parts Ref. No. Description Parts No. Q ty 5 6 7 8 9 0 5 6 7 8 9 0 5 6 7 8 9 0 5 6 7 8 9 SENSOR SENSOR PCB SCREW COVER-UPPER LEVER DISC GUIDE UP BUSHING ROLLER ROLLER DISC SHAFT ROLLER PIN ROLLER PVC CAP B/K ROLLER PIN PULLEY PIN IDLE GEAR IDLE GEAR PULLEY BELT PULLEY GEAR ROLLEY LOCKER (L) CAM (L) S/P CAM (L) S/P RACK CAM (R) LOCKER GEAR RACK GEAR LOAD GEAR LOAD (D) GEAR LOAD (B) GEAR LOAD (A) PIN LOAD B/K GEAR MOTOR GEAR WORM SERVO PCB ASSY SPECIAL SCREW S/P RO (L) SUPPORT DAMPER S/P RO CHASSIS MAIN RPST-G RPFR RPCA/H 0 TT * RPSECC T.0 RPPOM (F0-0) RPPOM (F0-0) RPPOM (F0-0) RPSLICON RPSUS 0 RPSUML-NI RPPVC RPSECC T.0 RPSUML-NI RPSUML-NI RPPOM (F0-0) RPPOM (F0-0) 5 RPCR-WRT RPPOM (F0-0) 6 RPPOM (F0-0) 7 RPPOM (F0-0) 8 RPSUS0WPB RPSUS0WPB RPPOM (F0-0) 9 RPPOM (F0-0) 0 RPPOM (F0-0) RPPOM (F0-0) RPPOM (F0-0) RPPOM (F0-0) RPPOM (F0-0) 5 RPSUML-NI RPSECC T.0 RPFF-050SH-90 RPPOM(F0-0) 6 RPGLASS EPOXY RPP/H TTS * RPSUS0WPB RPPOM (F0-0) 7 RPSUS0WPB RPSEEC T.0 7

EXPLODED VIEW PARTS LIST - CONTINUED (DECK) *Following part list is only for reference, not supplied as service parts Ref. No. Description Parts No. Q ty 0 5 6 7 8 9 50 5 5 5 5 55 56 57 58 59 60 6 6 6 6 65 66 67 68 69 70 7 7 7 CLAMP DISC HOLD CLAMPER S/P CLAMPER TURN TABLE BASE PU PIN SIDE (A) SCREW PIN SIDE (B) DAMPER S/P BASE MOTOR GEAR PU (B) GEAR PU (A) SCREW MOTOR HOUSING GEAR SHAFT PU SCREW P CONT WIRE SPRING TENSION GEAR PU LEAD SCREW SWITCH SCREW PICK UP FPC WIRE SPRING PU FIBER PAPER S/P CAM TRANSIT SCREW INSULATOR COVER SWITCH WASHER PE S/P BASE RPPOM (F0-0) 8 RPSECC T.0 5 RPSUS0WPB 5 RPABS G/F 0% RPPOM (F0-0) RPSUML-NI 5 RPCA/H 0 M/S RPSUML-NI 6 RPBUTHYL RPSUS0WPB 6 RPRF00CA65 RPHYTRELL 556 RPPOM(F0-0) 9 RPCA/H0 M/S * RPFF-050SH RPPOM(F0-0) 0 RPKNN (PCD8) RPR/H(W/W)TTB*5 RP007 #8 RPSUS0WPB 7 RPPOM (F0-0) RPBSBM RPSW-0 RPB/H TTB.7*8 RPSF-C99 RPPOLY AMIDE RPSUS T0. RP--------- RP0.55 RP.5*8 RPPE RPSW- RPPE RPSUS0WPB 8 6 8

SCHEMATIC DIAGRAM (MAIN BOARD) 9

SCHEMATIC DIAGRAM (KEY BOARD) 0

SCHEMATIC DIAGRAM (CD SERVO BOARD)

SCHEMATIC DIAGRAM (REMOTE BOARD)

ELECTRICAL PARTS LIST *Following part list is only for reference, not supplied as service parts Ref. No. Part No. Description Q ty PC BOARD ASSY, MAIN BOARD Q80 Q,0,60,80,TEL-Q Q8 RP0-005-00S RP0-008-00 RP0-00-00 TR. BD5 TO-6 SAMSUNG TR. SA8 TRANSISTOR B0 5 Q,05~7,60,60,80/~6/8,8//,80 RP0-0875-07 TRANSISTOR SC875G 6 IC80 ZD60/ D80//7 D,60,6/6,6/6,67,80/5/6/8/9~,T EL-D D80 ZD80 IC60 IC70/ IC60 IC80 IC80 IC80 IC0 XT60 C0,60/,805~8 C07 C08,0/,607,8/8,8,80/ C9, C0/5/9,/,605,87,C C,60~ C60 C65/6 C60 C8. C C C86 C07,,606,67,88 C8/5 C70 C0,5,08,8,87/9 C06,809,8 C70,87 C,68 RP0-07805-00 RP0-0006-07 RP0-000-00 RP0-08-00A RP0-50-0R RP0-5000-00A RP0-0-00 RP0-0558-6 RP0-06-00 RP0-070-00 RP0-07560-00 RP0-0788-00 RP0-0956-0 RP0-0007-0 RP05-60-0 RP05-60-0 RP05-60-0 RP05-60-00 RP05-6-0 RP05-6-0 RP05-670-00 RP07-67-0 RP05-600-00 RP05-67-0 RP06-007- RP06-006-0 RP06-007-0 RP06-007-0 RP06-07-0 RP06-07-0 RP06-076-0 RP06-606-0E RP06-607-0 RP06-66-0 IC-REGULATOR 78L05 E.S.D. DIODE NNCD6.G (5PIN) DIODE IN00 DIODE N-8 AT. (TAPPING) DIODE.5KE 0A ZENER DIODE 0V 0.5W AT. TAPE ±% I.C. PT I.C. BA-558F IC OP6-00 RDS (MP+ESP) IC NJU70 U50 (SOT-89) 5V IC TDA7560 (X50W) Y REGULATOR LC-78L8 I.C. TC-956F CRYSTAL HC-9U/S 7.MHZ CHIP 000PF ±0% X7R 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP CAP PF ±5% NPO 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP CAP 7PF ±5% NPO 060 SMT CHIP 700PF ±0% X7R 060 SMT CHIP CAP 0PF ±5% NPO 060 SMT CHIP CAP 0.7µF ±0% X7R 060 SMT PANASONIC GOLD CAP EECSOHD7H E. CAP 0µF 0V (ØX5MM) SUP MINI E. CAP 00µF 0V (Ø5X7MM MINI) E. CAP 00µF 0V (6X5) SUPER MINI E. CAP 0µF 0V (Ø6MM MINI) E. CAP 0µF 0V (Ø8X5MM) E. CAP 7µF 0V (6X5) E. CAP 0µF/6V (ØX5MM RC) E. CAP 00µF/6V (Ø6X5MM) E. CAP µf 6V (Ø5X5MM) 9 7 9 8 5 5 6

ELECTRICAL PARTS LIST - CONTINUED *Following part list is only for reference, not supplied as service parts Ref. No. Part No. Description Q ty C66 C80 C89,8 C6/7,60,80~5 C6//9,609,6~7,70~6 C6/ R60 R85 R,600,60,857 R65 R8 R65 R87 R65/6 R R70,88/9,RA0~7, R0,0 RA0 R0,0,60/,6,76~9,8,85 R,7,0/9,0/9,6/5,6//6,80~,8 8,8~,85/,TEL-R/, R,89,8 R6//6/7/9 R88 R87 R,8~7 R,6/,87 R70/,805~8,8,86/ R6,66,860 R70/9,70/5 R08,86 R/,605,69/0,87 R89 R607 R67/8 R R850,TEL-R R/9,0,60//6,6,80 R,~6,608,6,706/7,7/,80///5, 80/5,85,86//6 R6 RP06-66-0 RP06-68-00S RP06-675-0 RP06-5005-0 RP06-505-0 RP06-50-0 RP07-050-0 RP07-0500-00 RP07-0500-6A RP07-050-00 RP07-050-6A RP07-050-6A RP07-050-6A RP07-050-6A RP07-057-6A RP07-6000-00 RP07-600-00 RP07-60-00 RP07-60-00 RP07-60-00 RP07-60-00 RP07-605-00 RP07-65-00 RP07-65-00 RP07-68-00 RP07-6-00 RP07-6-00 RP07-6-00 RP07-67-00 RP07-6-00 RP07-6-00 RP07-6-00 RP07-6-00 RP07-69-00 RP07-670-00 RP07-67-00 RP07-67-00 RP07-67-00 RP07-65-00 E. CAP µf 6V (Ø6.X5MM) E. CAP 00µF/6V 05 C E. CAP.7µF 6V (Ø.5X5MM) E. CAP µf 50V (ØX5 MM) E. CAP.µF 50V (X5) E. CAP 0.µF 50V (ØX5MM) RES..Ω /W RES. 0Ω /W RES. 0Ω /6W (TAPPING) RES. 00Ω /W RES. 00Ω /6W (TAPPING) RES. kω /6W(TAPPING) RES. 0kΩ /6W(TAPPING) RES. Ω /6W (TAPPING) RES..7kΩ /6W (TAPPING) CHIP RES. 0Ω ±5% 060 SMT CHIP RES. 0Ω ±5% 060 SMT CHIP RES. 00Ω ±5% 060 SMT CHIP RES. kω ±5% 060 SMT CHIP RES. 0kΩ ±5% 060 SMT CHIP RES. 00kΩ ±5% 060 SMT CHIP RES. MΩ ±5% 060 SMT CHIP RES..5kΩ ±5% 060 SMT CHIP RES. 50kΩ ±5% 060 SMT CHIP RES. 80kΩ ±5% 060 SMT CHIP RES..kΩ ±5% 060 SMT CHIP RES. kω ±5% 060 SMT CHIP RES. 0kΩ ±5% 060 SMT CHIP RES. 7kΩ ±5% 060 SMT CHIP RES. 0Ω ±5% 060 SMT CHIP RES..kΩ ±5% 060 SMT CHIP RES. kω ±5% 060 SMT CHIP RES. 0kΩ ±5% 060 SMT CHIP RES. 90kΩ ±5% 060 SMT CHIP RES. 7Ω ±5% 060 SMT CHIP RES. 70Ω ±5% 060 SMT CHIP RES..7kΩ ±5% 060 SMT CHIP RES. 7kΩ ±5% 060 SMT CHIP RES. 5.k 8 9 5 5 9 6 8 0

R809~ R86/8 R6 R705/8,7/ R6 L80 CF0 ISO PCB MB L80 CON Q90/ Q90 D6,90 IC90 C90/7 C90/5 C906 C90 C90 R90 R9 R9 R906/8,95 R90 R90// R90 R905/7/9 R9/6,9 R9 Q0~,0 D0,6 IC0 XT0 C0/, C8, C6 C7 ELECTRICAL PARTS LIST CONTINUED *Following part list is only for reference, not supplied as service parts Ref. No. Part No. Description Q ty RP07-656-00 CHIP RES. 560Ω ±5% 060 SMT RP07-668-00 CHIP RES. 68kΩ ±5% 060 SMT RP07-675-00 CHIP RES. 7.5kΩ ±5% 060 SMT RP07-68-00 CHIP RES. 8.kΩ ±5% 060 SMT RP07-68-00 CHIP RES. 8kΩ ±5% 060 SMT RP09-7000-0 MICRO INDUCTOR 0UH AXIAL TYPE RP09-80006-00 BAND PASS FILTER GFMB6-T RP-0000-5 ISO PCB D/S.X0X (SANYO) RP-09-05 PCB SIR-9 YMB 8X5X.6MM RP5-0000-05 TDROIO COIL L=05µH Ø.0MM RP5-6-6 6PIN ISO SOCKET W/RCA/CDC/AUXIN RP5-68-08 ISO LINE IN/SW SOCKET 00MM PC BOARD ASSY, MAIN BOARD SUB-W SECTION RP0-0875-07 TRANSISTOR SC875G RP0-08050-0 TR. 8050C TO-9-B RP0-08-00A DIODE N-8 AT. (TAPPING) RP0-0558-6 I.C. BA558F RP05-668-0 CHIP 0.068µF ±0% X7R 060 SMT RP06-007-0 E. CAP 00µF 0V (6X5) SUPER MINI RP06-606-0E E. CAP 0µF/6V (ØX5MM RC) RP06-607-0 E. CAP 00µF 6V (Ø6X5MM) RP06-5005-0 E. CAP µf 50V (ØX5MM) RP07-05-6A RES. 0kΩ /6W (TAPPING) RP07-600-00 CHIP RES 0Ω ±5% 060 SMT RP07-60-00 CHIP RES kω ±5% 060 SMT RP07-60-00 CHIP RES 0kΩ ±5% 060 SMT RP07-6-00 CHIP RES.kΩ ±5% 060 SMT RP07-6-00 CHIP RES 0kΩ ±5% 060 SMT RP07-6-00 CHIP RES 0Ω ±5% 060 SMT RP07-69-00 CHIP RES 9kΩ ±5% 060 SMT RP07-67-00 CHIP RES 7kΩ ±5% 060 SMT RP07-668-00 CHIP RES 80Ω ±5% 060 SMT PC BOARD ASSY, MAIN BOARD FM TUNER SECTION RP0-0875-07 TRANSISTOR SC875G RP0-08-00A DIODE IN-8 AT. (TAPPING) RP0-06579-00 IC SAA-6579T RP0-00-00M C..MHZ HC-9U 0PPM PF RP05-60-0 CHIP 0.0µF ±0% X7R 060 SMT RP05-6-0 CHIP 0.0µF ±0% X7R 060 SMT RP05-60-00 CHIP CAP PF ±5% NPO 060 SMT RP05-670-00 CHIP CAP 7PF ±5% NPO 060 SMT 5

C0 C/5 C8 C R0 R R/ R R05,7 R06 R07 R0 R/ TUNER Q0 Q0/ D6/6 C08 C06 C0~ C0 R09 R05/7/8 R0/ R0 R06 L0 Z LED7 LED~6,8~ IC C, C R,9 R8,5~8 R//6/8 R9 ELECTRICAL PARTS LIST - CONTINUED *Following part list is only for reference, not supplied as service parts Ref. No. Part No. Description Q ty RP05-668-00 CHIP CAP 680PF ±5% NPO 060 SMT RP05-668-0 CHIP 6800PF ±0% X7R 060 SMT RP06-076-0 E. CAP 7µF 0V (6X5) RP06-50-0 E. CAP 0.µF 50V (ØX5MM) RP06-505-0 E. CAP.µF 50V (X5) RP07-050-6A RES. 00Ω /6W (TAPPING) RP07-05-6A RES..kΩ /6W (TAPPING) RP07-600-00 CHIP RES 0Ω ±5% 060 SMT RP07-60-00 CHIP RES 00Ω ±5% 060 SMT RP07-60-00 CHIP RES kω ±5% 060 SMT RP07-65-00 CHIP RES 50Ω ±5% 060 SMT RP07-67-00 CHIP RES 70Ω ±5% 060 SMT RP07-67-00 CHIP RES 7kΩ ±5% 060 SMT RP07-656-00 CHIP RES 5.6kΩ ±5% 060 SMT RP9-007-0 MITSUMT TUNER FAE-7-A9 PC BOARD ASSY, MAIN BOARD AM TUNER SECTION RP0-008-00 TR. SA8 RP0-0875-07 TRANSISTOR SC875G RP0-08-00A DIODE IN-8 AT. (TAPPING) RP05-65-00 TAN CAP..µF 6V RP05-60-0 CHIP 0.0µF ±0% X7R 060 SMT RP05-6-0 CHIP 0.0µF ±0% X7R 060 SMT RP06-606-0E E. CAP. 0µF/6V (X5MM RC) RP07-0500-6A RES 0Ω /6W (TAPPING) RP07-60-00 CHIP RES kω ±5% 060 SMT RP07-60-00 CHIP RES 0kΩ ±5% 060 SMT RP07-6-00 CHIP RES 0Ω ±5% 060 SMT RP07-68-00 CHIP RES 8.kΩ ±5% 060 SMT RP09-7070-0 M. INDUCTOR AL0TOR7 (AXIAL) PC BOARD ASSY, KEY BOARD RP0-0006-07 E.S.D. DIODE NNCD6.G (5PIN) RP0-0-0F SMD LED BRH RED STANLEY RP0-0-05M SMD LED BL-HW5A 0805 PURE GREN RP0-90-09 LED B.L.5X99 WHT (FOR RS60) RP0-758-00 IC LC758ED RP05-60-0 CHIP 0.µF ±0% X7R 060 SMT RP05-668-0 CHIP 680P ±5% NPO 060 SMT RP07-05-00 RES 0Ω /W RP07-60-00 CHIP RES kω ±5% 060 SMT 5 RP07-6-00 CHIP RES 0Ω ±5% 060 SMT RP07-65-00 CHIP RES.5kΩ ±5% 060 SMT 6

ELECTRICAL PARTS LIST - CONTINUED *Following part list is only for reference, not supplied as service parts Ref. No. Part No. Description Q ty R R, R R,, R8,0 R7 R5,/5 R5 R R R6 R R R9 R6 R5,7 R R0 KB RP07-65-00 RP07-68-00 RP07-68-00 RP07-6-00 RP07-6-00 RP07-6-00 RP07-67-00 RP07-6-00 RP07-6-00 RP07-670-00 RP07-67-00 RP07-67-00 RP07-67-00 RP07-65-00 RP07-656-00 RP07-668-00 RP07-68-00 RP07-68-00 RP-090-08 CHIP RES 5kΩ ±5% 060 SMT CHIP RES 80Ω ±5% 060 SMT CHIP RES 8kΩ ±5% 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES.kΩ ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES 7kΩ ±5% 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES.kΩ ±5% 060 SMT CHIP RES 7Ω ±5% 060 SMT CHIP RES 70Ω ±5% 060 SMT CHIP RES.7kΩ ±5% 060 SMT CHIP RES 7kΩ ±5% 060 SMT CHIP RES 5kΩ ±5% 060 SMT CHIP RES 5.6kΩ ±5% 060 SMT CHIP RES 680Ω ±5% 060 SMT CHIP RES 8.kΩ ±5% 060 SMT CHIP RES 8kΩ ±5% 060 SMT CD9 LCD KB D/S.X.5X8.8MM AM(MUTE),AMS,BAND/LOUD,DSP,EQ,M RP6-007-00K /PAU,M/SCN,M/RPT,M/SHF,M5/DN,M6/UP,MODE,POWER TACT SW. DCT/0.MM PIN 8 VR CON LCD REM RP8-006-00 RP5-M07-0 RP7-0580-Y RP9-00-00 ENCODER SRGP0000 (ALPS) 0PIN PLUG CD58 LCD TN NEG BLUE MASK PIN TYPE IR RECEIVER GPUM6XK (SHARP) PC BOARD ASSY, SDK/CD SERVO BOARD Q~6,8 Q05 Q,0/ Q7 Q0/ D, D0 D5,6 D0/,65,6 (MP+ESP) ZD0 D D ZD0 D7 RP0-000-000 RP0-005-00S RP0-008-00 RP0-05- RP0-0875-07 RP0-00-00 RP0-000-00 RP0-08-0 RP0-08-00A RP0-500-00A RP0-5006-00 RP0-5005-00 RP0-5009-00 RP0-505-00 TR. KRC0S TR BD5S NPN TO-6 FAIRCHLD TR. SA8 TRANSISTOR SD5M TRANSISTOR SC875G IR LED MIE AMC DIODE IN00 DIODE CHIP RLS8 06 ROHM DIODE IN-8 AT. (TAPPING) ZENER DIODE.V 0.5W AT. ZENER DIODE.6V ±5% 0.5W ZENER DIODE 5.V ±5% 0.5W ZENER DIODE 9.V ±5% 0.5W AT. 5.V ZENER DIODE (SMD06) 6 7

ELECTRICAL PARTS LIST - CONTINUED *Following part list is only for reference, not supplied as service parts Ref. No. Part No. Description Q ty U U5 U U U X0 C0,6,/,5/7/9 C9 C7, C0,/6/7,0,0/,9,9 C00//6/8,9,//5,///6~8,~ /5/7,/7/8,//6/8,0~9,5,00/ ~6/8 C5/6 C9 C0 C07, C07 C0/ C C05, C8 C0,/ C5 C6 C0,8 C0,0/9,8,0/9,0/ C5, C0/ R0 R05 RP0-096-00 RP0-0959-00 RP0-0976-00 RP0-099-00 RP0-M00-0 RP0-0069-00 RP05-606-0 RP05-600-00 RP05-60-0 RP05-60-0 RP05-60-0 RP05-65-0 RP05-65-0 RP05-60-00 RP05-6-0 RP05-6-0 RP05-60-00 RP05-6-0 RP05-69-00 RP05-67-0 RP05-67-00 RP05-668-0 RP05-68-00 RP06-007-0 RP06-607-5 RP06-676-5 RP06-505-0 RP07-0507-00 RP07-050-6A IC SIL 96 IC KA959D IC S5L 976X0-EORN IC S5L99X0-EORO (CDRW+MP+ESP) IC X DRAM SI700B (FUJITSU DICE) CRYSTAL HC-9/US 6.9MHZ TAN CAP 0UF 6V ±0% (.5X7) CHIP CAP PF ±5% NPO 060 SMT CHIP 000PF ±0% X7R 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP 0.µF ±0% X7R 060 SMT CHIP 500PF ±0% X7R 060 SMT CHIP 0.05µF ±0% X7R 060 SMT CHIP CAP PF ±5% NPO 060 SMT CHIP 00PF ±0% X7R 060 SMT CHIP 0.0µF ±0% X7R 060 SMT CHIP CAP PF ±5% NPO 060 SMT CHIP 0.0µF ±0% 060 SMT CHIP 90PF ±5% NPO 060 SMT CHIP 700PF ±0% X7R 060 SMT CHIP CAP 0.7µF ±5% (+80/-0%) CHIP 0.068µF ±0% 060 SMT CHIP 80PF ±5% 060 SMT E. CAP 00µF 0V (6X5) SUPER MINI E. CAP CHIP 00µF 6V Ø6.X5.5 E. CAP CHIP 7µF 6V Ø5X5.5 E. CAP.µF 50V (X5) RES..7Ω /W RES. 0kΩ /6W (TAPPING) 7 9 8 R0,0,0~7,/6,,5//6/8,0 RP07-6000-00 CHIP RES 0Ω 060 SMT R6,55,6,0 R05 R0,/ R9/0,6/7,7/8,06,/ R/,/5 R0,5 R5/6,,0,, R R RP07-605-00 RP07-600-00 RP07-60-00 RP07-60-00 RP07-60-00 RP07-605-00 RP07-65-00 RP07-68-00 RP07-60-00 CHIP RES.5Ω 060 SMT CHIP RES 0Ω ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES 0kΩ ±5% 060 SMT CHIP RES 00kΩ ±5% 060 SMT CHIP RES MΩ ±5% 060 SMT CHIP RES 5kΩ ±5% 060 SMT CHIP RES 80Ω ±5% 060 SMT CHIP RES 0kΩ ±5% 060 SMT 9 6 8

ELECTRICAL PARTS LIST - CONTINUED *Following part list is only for reference, not supplied as service parts Ref. No. Part No. Description Q ty R0,, R0//9 R00/,,5 R6 R8 R0 R60,08 R0/, R/ R6,00 R,6~0,5~50///9,6,0~/5~ 9 R0//8,7,07,0 R07 R,09,7~ R/9 R09 SW0 RP07-6-00 RP07-6-00 RP07-6-00 RP07-67-00 RP07-67-00 RP07-6-00 RP07-6-00 RP07-69-00 RP07-69-00 RP07-67-00 RP07-67-00 RP07-67-00 RP07-668-00 RP07-68-00 RP07-68-00 RP07-69-00 RP--0 RP6-000-0 CHIP RES 0Ω ±5% 060 SMT CHIP RES.kΩ ±5% 060 SMT CHIP RES. 0kΩ ±5% 060 SMT CHIP RES..7kΩ ±5% 060 SMT CHIP RES. 70kΩ ±5% 060 SMT CHIP RES kω ±5% 060 SMT CHIP RES. 0kΩ CHIP RES.9kΩ ±5% 060 SMT CHIP RES 9kΩ ±5% 060 SMT CHIP RES 70Ω ±5% 060 SMT CHIP RES.7kΩ ±5% 060 SMT CHIP RES. 7kΩ ±5% 060 SMT CHIP RES. 68kΩ ±5% 060 SMT CHIP RES. 8.kΩ ±5% 060 SMT CHIP RES 8kΩ ±5% 060 SMT CHIP RES. 9kΩ ±5% 060 SMT PCB CDX.0.. SERVO D/S MICRO SWITCH MPU07MLBO (MIC) 6 8 PC BOARD ASSY, REMOTE BOARD Q500 LD D500/ IC500 RP0-078-8 RP0-00-00 RP0-08-00 RP0-000-00 TR. SD78K-R ROHM INFRARED LED ØMM MIE-A DIODE IN-8 IC S00 (SGNEC) C50 RP05-005-0M CHIP CAP KC0EC05M-TS C50/ R50 R50 CF50 PCB RP05-0-06 RP07-050-5 RP07-050-5 RP09-5055-05J RP-700-505 CHIP CAP. 0PF (NPO) CHIP RES..Ω /0W CHIP RES kω /0W CER RESONATOR ZTB55E CD70 RC06 D/S.X80.X5.5 SANYO PC BOARD ASSY, MAIN BOARD LINE OUT SECTION C707~0 R7~ RP06-5005-0 RP07-6000-00 E.CAP µf 50V (ØX5MM) CHIP RES. 0Ω ±5% 060 SMT PC BOARD ASSY, MAIN BOARD TONE SECTION D6 C0/ C0/ R0/ R0/ RP0-08-00A RP05-65-0 RP06-505-0E RP07-68-00 RP07-6-00 DIODE IN-8 AT. (TAPPING) CHIP 500PF ±0% X7R 060 SMT E.CAP.µF/50V (X5MM RC0) CHIP RES..8kΩ ±5% 060 SMT CHIP RES..kΩ ±5% 060 SMT 9

ZD50 ZD50 IC50 C505 C50 C50 C50//6/7 R507 R50 R68 R505/6 R50/ R50 R508/9 Q LED R5 R6,0 R, R7 R8,9 EJ RESET DTH ELECTRICAL PARTS LIST - CONTINUED *Following part list is only for reference, not supplied as service parts Ref. No. Part No. Description Q ty PC BOARD ASSY, MAIN BOARD JB/GIB SECTION RP0-50056-00A ZENER DIODE 5.6V 0.5W AT. ±% RP0-50068-00A ZENER DIODE 6.8V 0.5W AT. ±% RP0-0-06 IC BAF SOP8 ROHM RP06-06-0 E. CAP µf 0V (Ø5X5MM) RP06-606-0E E. CAP 0µF/6V (X5MM RC) RP06-607-0 E. CAP 00µF 0V (Ø6X5MM) RP06-5005-0 E. CAP µf 50V (ØX5MM) RP07-050-6A RES 00Ω /6W (TAPPING) RP07-60-00 CHIP RES kω ±5% 060 SMT RP07-605-00 CHIP RES MΩ ±5% 060 SMT RP07-6-00 CHIP RES.kΩ ±5% 060 SMT RP07-6-00 CHIP RES.kΩ ±5% 060 SMT RP07-67-00 CHIP RES 70Ω ±5% 060 SMT RP07-668-00 CHIP RES.8kΩ ±5% 060 SMT RP5-00080-08 RAINBOW WIRE #0 8PIN 80MM RP5-68-0 ISO CDC SOCKET 8PIN 00MM PC BOARD ASSY, FRONT & DETACHABLE BOARD RP0-08050-0 TR. 8050C TO-9-B RP0-0-05M SMD LED BL-HW5A 0805 PURE GREN RP0-070-0J PLAMP V 0MM X7KT RP07-050-00 RES 00Ω /W RP07-6000-00 CHIP RES 0Ω ±5% 060 SMT RP07-60-00 CHIP RES 0kΩ ±5% 060 SMT RP07-69-00 CHIP RES 9kΩ ±5% 060 SMT RP07-68-00 CHIP RES 80Ω ±5% 060 SMT RP-090-5 PCB SIR-9 FB 9X.8X.MM RP6-00-0A TACT SW KPS-07SW TAPPING RP6-0500-00 TACT SW TS-06500-50 H=5MM RP6-577-00K PUSH SW. SPPB577A (DS-0) KONEX RP5-0000-08 RAINBOW WIRE #0 8PIN 00MM RP5-5-0 RAINBOW WIRE # 5MM PIN RP5-F07-0 0PIN SOCKET 0