DVM. Technical Data Book

Transcript

1 DVM Technical Data Book

2

3

4 Products Outdoor units Line-up Accessories 2

5 Outdoor units Specifications Operation limit Electrical wiring diagram Sound level Cycle diagrams Dimensional drawing Products Outdoor units Capacity Capacity 1 2 Capacity tables Capacity correction 3

6 4

7 Products Products 1 Nomenclature Line-up Accessories...8 5

8 1 Nomenclature 1-1. Outdoor units Model name AM RVX HF TX TW FA EN ER / EU 100 (Buyer) Classification Feature1 AM DVM W DVM WATER Capacity Feature2 x 1/10 HP (3 digits) A Standard + General Temp.+ Module Version F 2013 H 2014 J 2015 Rating Voltage N G 3Ø, 380~415V, 50/60Hz 3Ø, 380~415V, 50Hz Product Type Mode X Outdoor Unit R Heat Recovery N Indoor Unit H Heat Pump

9 2 Line-up 2-1. Outdoor units Capacity (HP) Type Heat Recovery / Heat Pump Products 2-1. Indoor units Type Capacity (kw) Slim 1 way cassette 2 way cassette 4 way cassette (S) 4 way cassette (600 x 600) Slim duct MSP duct HSP duct Console Ceiling Neo Forte Neo Forte (E) Floor Standing Type Air Flow Rate (CMH) ,000 ERV PLUS Type Capacity (kw) Hydro Unit HE Hydro Unit HT

10 3 Accessory Classification Product Model Image Application model Integrated management system Controller Interface Module DMS 2 MIM-D00AN DVM S, DVM S WATER S-NET 3 MST-P3P DVM S, DVM S WATER PIM MIM-B16N DVM S, DVM S WATER (latter half of '13) Centralized controller MCM-A202DN DVM S, DVM S WATER Centralized control system Controller Operation mode selection switch MCM-C200 DVM S, DVM S WATER New touch controller MCM-A300N DVM S, DVM S WATER Wireless remote controller MR-DH00 Cassette, Duct(Receiver needed) Individual control System controller Controller Wired remote controller (Multi function) MWR-WE10N Cassette, Wall-mounted, Ceiling, Duct, Console, ERV Wireless signal receiver MRK-A10N Duct (For wireless remote controller) Remote sensor MRW-TA Cassette, Wall-mounted, Ceiling, Duct, Console ERV CO2 Sensor MOS-C1 ERV, ERV PLUS Building management system Lonworks interface module MIM-B18N DVM S, DVM S WATER DMS-Bnet (BACnet) MIM-B17N DVM S, DVM S WATER Guest room management system External contact interface module MIM-B14 DVM S, DVM S WATER Converter S-Net Pro MIM-C02N DVM S, DVM S WATER Communication MIM-N00 DVM S, DVM S WATER Multi Tenant Function Controller MCM-C210 DVM S, DVM S WATER

11 Classification Feature Model Description Relevant unit Remark Y-JOINT Y-joint (High Pressure Gas, HR only) Outdoor joint (Outdoor Connection) Outdoor joint (High Pressure Gas, HR only) MXJ-YA1509M MXJ-YA2512M MXJ-YA2812M MXJ-YA2815M MXJ-YA3419M MXJ-YA4119M MXJ-YA4422M MXJ-YA1500M MXJ-YA2500M MXJ-YA3100M MXJ-YA3800M MXJ-TA3819M MXJ-TA4422M MXJ-TA3100M MXJ-TA3800M 15.0 kw and below Over 15.0 ~ 40 kw and below Over 40 ~ 45 kw and below Over 45 ~ 70.3 kw and below Over 70.3 ~ 98.4 kw and below Over 98.4 ~ kw and below Over kw 22.4 kw and below Over 22.4 ~ 70.3 kw and below Over 70.3 ~ kw and below Over kw kw and below Over kw kw and below Over kw DVM S HP/HR DVM S WATER HP/HR DVM S HR DVM S WATER HR DVM S HP/HR DVM S WATER HP/HR DVM S HR DVM S WATER HR Requisite Requisite Requisite Requisite Products Header joint MXJ-HA2512M MXJ-HA3115M MXJ-HA3819M 45.0 kw and below (for 4 rooms) 70.3 kw and below (for 8 rooms) Over 70.3 kw (for 8 rooms) DVM S HP/HR DVM S WATER HP/HR Requisite MXD-E24K132A MXD-E24K200A 2 Indoor MXD-E32K200A EEV kits MXD-E24K232A MXD-E24K300A MXD-E32K224A 3 Indoor Apply to products without EEV (Wall mount & Ceiling) Option MXD-E32K300A MEV-E24SA MEV-E32SA 1 Indoor MDP- N047SNC1D HSP Duct (22.0/28.0)kW - Drain Pump MCU AHU KIT MDP- M075SGU1D MDP- M075SGU2D MDP- M075SGU3D MDP- E075SEE3D MCU-S4NEE1N MCU-S6NEE1N MCU-S4NEE2N MXD-K025AN MXD-K050AN MXD-K075AN MXD-K100AN MSP Duct (9.0/11.2) kw MSP Duct (12.8/14.0) kw MSP Duct (5.6/7.1) kw SlimDuct (2.0~14.0)kW - Below 4 indoor units Below 6 indoor units Below 2 large capacity ducts 7.0kW~8.75kW 14.0kW~17.5kW 21.0kW~26.25kW 28.0kW~35.0kW - DVM S HR DVM S WATER HR Option Requisite (HR Only) - Option

12 3 Accessory Classification Feature Model Description Relevant unit Remark MXD-A38K2A 8~12HP PDM KIT MXD-A12K2A 14~16HP DVM S Option MXD-A58K2A 18~22HP Humidifier MVO-VA CMH MVO-VA CMH - Option Virus Doctor MSD-CAN1 4way Cassette KIT MSD-EAN1 ERV-Plus - Option Motion detect sensor MCR-SMA 4way Cassette - Option PC1NUSMAN Slim 1way cassette PC1NUPMAN Slim 1way cassette (Z-slide) PC2NUSMEN 2 way cassette PC4SUSMAN Mini 4way cassette (Waffle) Front panel PC4SUSMBN Mini 4way cassette (Classic) - Requisite PC4NUSKAN 4 way cassette (Waffle) PC4NUSKEN 4 way cassette (Classic) PC4NBSKAN 4 way cassette (Waffle, Black)

13 Outdoor units 1 Specifications Operation limit Electrical wiring diagram Sound level Cycle diagrams Dimensional drawing...26 Outdoor units 11

14

15 Model Name AM180FXWANR AM200FXWANR AM220FXWANR AM240FXWANR Power Supply Ø, #, V, Hz 3,4, ,50/60 3,4, ,50/60 3,4, ,50/60 3,4, ,50/60 Mode - HEAT RECOVERY HEAT RECOVERY HEAT RECOVERY HEAT RECOVERY Performance Power COP Compressor Condenser Piping Connections Field Wiring HP HP Ton Ton Capacity (Nominal) Power Input (Nominal) Cooling Heating kw Btu/h 172, , , ,300 kw Btu/h 193, , , ,000 Cooling 1) kw Heating 2) Current Input Cooling 1) (Nominal) Heating 2) A MCA (MCA) (MCA) (MCA) (MCA) MFA Nominal Cooling 1) Nominal Heating 2) Type - SSC Scroll x 2 SSC Scroll x 2 SSC Scroll x 2 SSC Scroll x 2 Model Name - DS-GB052FAVBSG x 2 DS-GB052FAVBSG x 2 DS-GB052FAVBSG x 1 + DS-GB066FAVBSG x 1 DS-GB066FAVBSG x 2 Oil Type - PVE PVE PVE PVE Type - PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) Pipe Size Ø, inch PT 1-1/4 x 2 PT 1-1/4 PT 1-1/4 x 2 PT 1-1/4 x 2 Lost Head kpa x 2 Water Flow Rate LPM x 2 Max. Pressure Mpa Liquid Pipe Discharge Gas Pipe Gas Pipe Installation Limitation Ø, mm Ø, inch 5/8" 5/8" 5/8" 5/8" Ø, mm Ø, inch 7/8" 1 1/8" 1 1/8" 1 1/8" Ø, mm Ø, inch 1 1/8" 1 1/8" 1 1/8" 1 1/8" Max. Length m 170(190) 170(190) 170(190) 170(190) Max. Height m 50.0(40.0) 50.0(40.0) 50.0(40.0) 50.0(40.0) Power Source Wire mm Transmission Cable mm ~ ~ ~ ~ 1.25 Refrigerant Type - R410A R410A R410A R410A Factory Charging kg Sound 3) Sound Pressure db(a) Sound Power db(a) External Dimension Operating Temp. Range Net Weight kg x x x 2 Shipping Weight kg x x x 2 Net Dimensions (WxHxD) mm (770 x 1,000 x 545) x 2 1,100 x 1,000 x 545 (770 x 1,000 x 545) x 2 (770 x 1,000 x 545) x 2 Shipping Dimensions (WxHxD) mm (840 x 1,200 x 620) x 2 1,170 x 1,200 x 620 (840 x 1,200 x 620) x 2 (840 x 1,200 x 620) x 2 Cooling C 10.0 ~ ~ ~ ~ 45.0 Heating C 10.0 ~ ~ ~ ~ 45.0 Outdoor units Specifications may be subject to change without prior notice for product improvement. 1) Nominal cooling capacities are based on; Indoor temerature : 27 C DB, 19 C WB / Inlet water temperature : 30 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 2) Nominal heating capacities are based on; Indoor temerature : 20 C DB, 15 C WB / Inlet water temperature : 20 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 3) Sound level was acquired in an anechoic room. Thus actual noise level may be different depending on the installation conditions.

16 1 Specifications 1-1. DVM S WATER Model Name AM260FXWANR AM280FXWANR AM300FXWANR AM320FXWANR Power Supply Ø, #, V, Hz 3,4, ,50/60 3,4, ,50/60 3,4, ,50/60 3,4, ,50/60 Mode - HEAT RECOVERY HEAT RECOVERY HEAT RECOVERY HEAT RECOVERY Performance Power COP Compressor Condenser Piping Connections Field Wiring HP HP Ton Ton Capacity (Nominal) Power Input (Nominal) Cooling Heating kw Btu/h 248, , , ,700 kw Btu/h 279, , , ,900 Cooling 1) kw Heating 2) Current Input Cooling 1) (Nominal) Heating 2) A MCA (MCA) (MCA) (MCA) (MCA) MFA Nominal Cooling 1) Nominal Heating 2) Type - SSC Scroll x 3 SSC Scroll x 3 SSC Scroll x 3 SSC Scroll x 3 Model Name - DS-GB052FAVBSG x 3 DS-GB052FAVBSG x 3 DS-GB052FAVBSG x 3 DS-GB066FAVBSG x 1 + DS-GB052FAVBSG x 2 Oil Type - PVE PVE PVE PVE Type - PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) Pipe Size Ø, inch PT 1-1/4 x 3 PT 1-1/4 x 2 PT 1-1/4 x 2 PT 1-1/4 x 2 Lost Head kpa 22.0 x Water Flow Rate LPM 80.0 x Max. Pressure Mpa Liquid Pipe Discharge Gas Pipe Gas Pipe Installation Limitation Ø, mm Ø, inch 3/4" 3/4" 3/4" 3/4" Ø, mm Ø, inch 1 1/8" 1 1/8" 1 1/8" 1 1/8" Ø, mm Ø, inch 1 3/8" 1 3/8" 1 3/8" 1 3/8" Max. Length m 170(190) 170(190) 170(190) 170(190) Max. Height m 50.0(40.0) 50.0(40.0) 50.0(40.0) 50.0(40.0) Power Source Wire mm Transmission Cable mm ~ ~ ~ ~ 1.25 Refrigerant Type - R410A R410A R410A R410A Factory Charging kg Sound 3) Sound Pressure db(a) Sound Power db(a) External Dimension Operating Temp. Range Net Weight kg x Shipping Weight kg x Net Dimensions (WxHxD) mm (770 x 1,000 x 545) x 3 Shipping Dimensions (WxHxD) mm (840 x 1,200 x 620) x x 1,000 x ,100 x 1,000 x x 1,200 x ,170 x 1,200 x x 1,000 x ,100 x 1,000 x x 1,200 x ,170 x 1,200 x x 1,000 x ,100 x 1,000 x x 1,200 x ,170 x 1,200 x 620 Cooling C 10.0 ~ ~ ~ ~ 45.0 Heating C 10.0 ~ ~ ~ ~ 45.0 Specifications may be subject to change without prior notice for product improvement. 1) Nominal cooling capacities are based on; Indoor temerature : 27 C DB, 19 C WB / Inlet water temperature : 30 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 2) Nominal heating capacities are based on; Indoor temerature : 20 C DB, 15 C WB / Inlet water temperature : 20 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 3) Sound level was acquired in an anechoic room. Thus actual noise level may be different depending on the installation conditions.

17 Model Name AM340FXWANR AM360FXWANR AM380FXWANR AM400FXWANR Power Supply Ø, #, V, Hz 3,4, ,50/60 3,4, ,50/60 3,4, ,50/60 3,4, ,50/60 Mode - HEAT RECOVERY HEAT RECOVERY HEAT RECOVERY HEAT RECOVERY Performance Power COP Compressor Condenser Piping Connections Field Wiring HP HP Ton Ton Capacity (Nominal) Power Input (Nominal) Cooling Heating kw Btu/h 324, , , ,200 kw Btu/h 365, , , ,900 Cooling 1) kw Heating 2) Current Input Cooling 1) (Nominal) Heating 2) A MCA 61.6 (MCA) 63.6 (MCA) 66.9 (MCA) (MCA) MFA Nominal Cooling 1) Nominal Heating 2) Type - SSC Scroll x 3 SSC Scroll x 4 SSC Scroll x 4 SSC Scroll x 4 Model Name - DS-GB052FAVBSG x 1 + DS-GB066FAVBSG x 2 DS-GB052FAVBSG x 4 DS-GB052FAVBSG x 4 DS-GB052FAVBSG x 4 Oil Type - PVE PVE PVE PVE Type - PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) Pipe Size Ø, inch PT 1-1/4 x 3 PT 1-1/4 x 3 PT 1-1/4 x 3 PT 1-1/4 x 2 Lost Head kpa x x x 2 Water Flow Rate LPM x x x 2 Max. Pressure Mpa Liquid Pipe Discharge Gas Pipe Gas Pipe Installation Limitation Ø, mm Ø, inch 3/4" 3/4" 3/4" 3/4" Ø, mm Ø, inch 1 1/8" 1 3/8" 1 3/8" 1 3/8" Ø, mm Ø, inch 1 3/8" 1 5/8" 1 5/8" 1 5/8" Max. Length m 170(190) 170(190) 170(190) 170(190) Max. Height m 50.0(40.0) 50.0(40.0) 50.0(40.0) 50.0(40.0) Power Source Wire mm Transmission Cable mm ~ ~ ~ ~ 1.25 Refrigerant Type - R410A R410A R410A R410A Factory Charging kg Sound 3) Sound Pressure db(a) Sound Power db(a) External Dimension Operating Temp. Range Net Weight kg x x x x 2 Shipping Weight kg x x x x 2 Net Dimensions (WxHxD) mm (770 x 1,000 x 545) x 3 Shipping Dimensions (WxHxD) mm (840 x 1,200 x 620) x 3 (770 x 1,000 x 545) x 2 + 1,100 x 1,000 x 545 (840 x 1,200 x 620) x 2 + 1,170 x 1,200 x 620 (770 x 1,000 x 545) x 2 + 1,100 x 1,000 x 545 (840 x 1,200 x 620) x 2 + 1,170 x 1,200 x 620 (1,100 x 1,000 x 545) x 2 (1,170 x 1,200 x 620) x 2 Cooling C 10.0 ~ ~ ~ ~ 45.0 Heating C 10.0 ~ ~ ~ ~ 45.0 Outdoor units Specifications may be subject to change without prior notice for product improvement. 1) Nominal cooling capacities are based on; Indoor temerature : 27 C DB, 19 C WB / Inlet water temperature : 30 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 2) Nominal heating capacities are based on; Indoor temerature : 20 C DB, 15 C WB / Inlet water temperature : 20 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 3) Sound level was acquired in an anechoic room. Thus actual noise level may be different depending on the installation conditions.

18 1 Specifications 1-1. DVM S WATER Model Name AM420FXWANR AM440FXWANR AM480FXWANR AM500FXWANR Power Supply Ø, #, V, Hz 3,4, ,50/60 3,4, ,50/60 3,4, ,50/60 3,4, ,50/60 Mode - HEAT RECOVERY HEAT RECOVERY HEAT RECOVERY HEAT RECOVERY Performance Power COP Compressor Condenser Piping Connections Field Wiring HP HP Ton Ton Capacity (Nominal) Power Input (Nominal) Cooling Heating kw Btu/h 401, , , ,700 kw Btu/h 451, , , ,400 Cooling 1) kw Heating 2) Current Input Cooling 1) (Nominal) Heating 2) A MCA (MCA) (MCA) (MCA) (MCA) MFA Nominal Cooling 1) Nominal Heating 2) Type - SSC Scroll x 4 SSC Scroll x 4 SSC Scroll x 5 SSC Scroll x 5 Model Name - DS-GB052FAVBSG x 3 + DS-GB066FAVBSG x 1 DS-GB066FAVBSG x 2 + DS-GB052FAVBSG x 2 DS-GB052FAVBSG x 5 DS-GB052FAVBSG x 5 Oil Type - PVE PVE PVE PVE Type - PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) Pipe Size Ø, inch PT 1-1/4 x 3 PT 1-1/4 x 3 PT 1-1/4 x 3 PT 1-1/4 x 3 Lost Head kpa x x x 2 Water Flow Rate LPM x x x 2 Max. Pressure Mpa Liquid Pipe Discharge Gas Pipe Gas Pipe Installation Limitation Ø, mm Ø, inch 3/4" 3/4" 3/4" 3/4" Ø, mm Ø, inch 1 3/8" 1 3/8" 1 3/8" 1 3/8" Ø, mm Ø, inch 1 5/8" 1 5/8" 1 5/8" 1 5/8" Max. Length m 170(190) 170(190) 170(190) 170(190) Max. Height m 50.0(40.0) 50.0(40.0) 50.0(40.0) 50.0(40.0) Power Source Wire mm Transmission Cable mm ~ ~ ~ ~ 1.25 Refrigerant Type - R410A R410A R410A R410A Factory Charging kg Sound 3) Sound Pressure db(a) Sound Power db(a) External Dimension Operating Temp. Range Net Weight kg x x x x 2 Shipping Weight kg x x x x 2 Net Dimensions (WxHxD) Shipping Dimensions (WxHxD) mm mm (770 x 1,000 x 545) x 2 + 1,100 x 1,000 x 545 (840 x 1,200 x 620) x 2 + 1,170 x 1,200 x 620 (770 x 1,000 x 545) x 2 + 1,100 x 1,000 x 545 (840 x 1,200 x 620) x 2 + 1,170 x 1,200 x x 1,000 x (1,100 x 1,000 x 545) x x 1,200 x (1,170 x 1,200 x 620) x x 1,000 x (1,100 x 1,000 x 545) x x 1,200 x (1,170 x 1,200 x 620) x 2 Cooling C 10.0 ~ ~ ~ ~ 45.0 Heating C 10.0 ~ ~ ~ ~ 45.0 Specifications may be subject to change without prior notice for product improvement. 1) Nominal cooling capacities are based on; Indoor temerature : 27 C DB, 19 C WB / Inlet water temperature : 30 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 2) Nominal heating capacities are based on; Indoor temerature : 20 C DB, 15 C WB / Inlet water temperature : 20 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 3) Sound level was acquired in an anechoic room. Thus actual noise level may be different depending on the installation conditions.

19 Model Name AM520FXWANR AM600FXWANR Power Supply Ø, #, V, Hz 3,4, ,50/60 3,4, ,50/60 Mode - HEAT RECOVERY HEAT RECOVERY Performance Power COP Compressor Condenser Piping Connections Field Wiring HP HP Ton Ton Capacity (Nominal) Power Input (Nominal) Cooling Heating kw Btu/h 496, ,200 kw Btu/h 558, ,900 Cooling 1) kw Heating 2) Current Input Cooling 1) (Nominal) Heating 2) A MCA (MCA) (MCA) MFA Nominal Cooling 1) Nominal Heating 2) Type - SSC Scroll x 5 SSC Scroll x 6 Model Name - DS-GB066FAVBSG x 1 + DS-GB052FAVBSG x 4 DS-GB052FAVBSG x 6 Oil Type - PVE PVE Type - PHE(Stainless Steel Plate) PHE(Stainless Steel Plate) Pipe Size Ø, inch PT 1-1/4 x 3 PT 1-1/4 x 3 Lost Head kpa x x 3 Water Flow Rate LPM x x 3 Max. Pressure Mpa Liquid Pipe Discharge Gas Pipe Gas Pipe Installation Limitation Ø, mm Ø, inch 3/4" 3/4" Ø, mm Ø, inch 1 3/8" 1 3/8" Ø, mm Ø, inch 1 5/8" 1 5/8" Max. Length m 170(190) 170(190) Max. Height m 50.0(40.0) 50.0(40.0) Power Source Wire mm2 - - Transmission Cable mm ~ ~ 1.25 Refrigerant Type - R410A R410A Factory Charging kg Sound 3) Sound Pressure db(a) - - Sound Power db(a) - - External Dimension Operating Temp. Range Net Weight kg x x 3 Shipping Weight kg x x 3 Net Dimensions (WxHxD) mm 770 x 1,000 x (1,100 x 1,000 x 545) x 2 (1,100 x 1,000 x 545) x 3 Shipping Dimensions (WxHxD) mm 840 x 1,200 x (1,170 x 1,200 x 620) x 2 (1,170 x 1,200 x 620) x 3 Cooling C 10.0 ~ ~ 45.0 Heating C 10.0 ~ ~ 45.0 Outdoor units Specifications may be subject to change without prior notice for product improvement. 1) Nominal cooling capacities are based on; Indoor temerature : 27 C DB, 19 C WB / Inlet water temperature : 30 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 2) Nominal heating capacities are based on; Indoor temerature : 20 C DB, 15 C WB / Inlet water temperature : 20 C / Equivalent refrigerant piping : 7.5m, Level differences : 0m 3) Sound level was acquired in an anechoic room. Thus actual noise level may be different depending on the installation conditions.

20 2 Operation limit 2-1. Cooling Inlet water temperature (ºC) Operation Range Continuous Operation Range Operation Range Indoor temperature (ºC, WB) 2-2. Heating Operation Range Outdoor temperature (ºC) Warming up operation range Continuous Operation Range Operation Range Anti-freeze A Antifreeze A : freezing point -8 ºC Antifreeze B : freezing point -15 ºC Anti-freeze B Indoor temperature (ºC, DB)

21 2-3. Heat Recovery Operation Range Inlet water temperature (ºC) Warming up operation range Heating operation range Continuous Operation Range Operation Range Anti-freeze A Cooling operation range Antifreeze A : freezing point -8 ºC Antifreeze B : freezing point -15 ºC Outdoor units Anti-freeze B Indoor temperature (ºC, DB) Design standard Type Circulating water Operation Heat source water Ground heat source 1) Water loop Ground water Ground loop Inlet water temperature ( C) Standard Main usage Operation limit Cooling 30 20~35 Heating 20 20~35 Cooling 15 15~35 Heating 10 5~25 Cooling 25 15~35 Heating 5 5~25 10~45 Cooling : 10~45 Heating : -5~45 (Heating : -10~45) 2) 1) Anti-freeze must be used when temperature of water inlet for heating is below 10 C or ground heat is used. Maintain appropriate concentration level of anti-freeze according to temperature of water inlet. 2) Strict management of anti-freeze concentration level is required. Consult Samsung before application. Anti-freeze standard Type of anti-freeze (Based on 15 C) Concentration [% Wt.] Freezing temperature ( C) Density [kg/m 3 ] Methanol Ethanol Ethylene glycol Propylene glycol

22 2 Operation limit 2.4 Water flow rate When the water flow rate is out of the operation range, stop the outdoor unit and take care of the cause before restart the operation. (Allowable range : 60~120% of the standard water flow rate) Section Water Flow Rate (LPM) 8HP 10HP 12HP 20HP Standard condition Operation range 48~96 58~115 68~ ~228 Pressure loss from plate type heat exchanger (kpa) AM080FXWA AM100FXWA 60 AM120FXWA Pressure loss from plate type heat exchanger (kpa) AM200FXWA Amount of cooling water (L/min) Amount of cooling water (L/min)

23 3 Electrical wiring diagram 3-2. Heat Recovery 1) AM FXWA Outdoor units External contact Input/Output AC/DC Remarks 2Way V/V power Output AC Optional Water pump Contact output - Optional 2Way V/V Contact output - Optional Flow S/W Contact input - Mandatory Flow control Output DC(0~10V) Optional

24 4 Sound level 4-1. Sound pressure level Unit: db(a) Model Cooling AM080FXWANR 48 AM100FXWANR 48 AM120FXWANR 50 AM200FXWANR 51 Note These operation values were obtained in an anechoic room. Sound pressure level will vary depending on a range of factors such as the construction of the particular room where the equipment is installed. Operation sound level may differ depending on operation and ambient conditions NC curves 1) AM080FXWANR 2) AM100FXWANR Sound pressure level (db) Sound pressure level (db) Octave band center frequency(hz) Octave band center frequency(hz) 3) AM120FXWANR 4) AM200FXWANR Sound pressure level (db) Sound pressure level (db) Octave band center frequency(hz) Octave band center frequency(hz)

25 4-3. Sound Power Note Model Power dba = A-weighted sound power level. AM080FXWANR 70 Reference power : 1pW AM100FXWANR 70 Measured according to ISO AM120FXWANR 70 AM200FXWANR 73 Unit: db(a) 1) AM080FXWANR Level [db re 1pW] 2) AM100FXWANR Level [db re 1pW] Outdoor units Band (Hz) Band (Hz) 3) AM120FXWANR 4) AM250FXWANR Level [db re 1pW] Level [db re 1pW] Band (Hz) Band (Hz)

26 5 Cycle diagrams 5-1. Parts of outdoor unit 1) AM080/100/120FXWA Classification A B C D E E1 F G H I J K L M V1 V2-1, V2-2 V3 V4 V5 V6 Name INV COMP ACCUM O/S 4WAY V/V PLATE HEAT EXCHANGER MAIN EEV EVI EEV IPM COOLER SUB COOLER RECEIVER HEAT PUMP V/V HIGH PRE. S/W HIGH PRE. SENSOR LOW PRE. SENSOR ACCUM RETRUN V/V HOT GAS BYPASS VV MAIN COOLING V/V EVI V/V EVI B/P V/V DPR V/V Classification Name V7 LIQUID TUBE V/V V8 HOT GAS CHARGING V/V V9 LOW PRE. GAS SERVICE V/V V10 HIGH PRE. GAS SERVICE V/V V11 LIQUID SERVICE V/V CV1 DISC. CHECK V/V CV2 HRV CHECK V/V CV3 HR CHECK V/V CV4 MAIN COOL CHECK V/V CV5-1, CV5-2 LIQUID TUBE CHECK V/V T1 COMP TOP SENSOR T2 DISC. SENSOR T3 SUC. SENSOR 2 T4 SUC. SENSOR 1 T5 WATER SENSOR T6 COND OUT SENSOR T7 LIQUID TUBE SENSOR T8 SC IN SENSOR T9 SC OUT SENSOR

27 5-1. Parts of outdoor unit 2) AM200FXWA Outdoor units Classification Name A1, A2 INV COMP B ACCUM C1, C2 O/S D 4WAY V/V E PLATE HEAT EXCHANGER E1 MAIN EEV F EVI EEV G1, G2 IPM COOLER H SUB COOLER I RECEIVER J HEAT PUMP V/V K1, K2 HIGH PRE. S/W L HIGH PRE. SENSOR M LOW PRE. SENSOR V1 ACCUM RETRUN V/V V2-1, V2-2 HOT GAS BYPASS VV V3 MAIN COOLING V/V V4-1, V4-2 EVI V/V V5 EVI B/P V/V V6 DPR V/V Classification Name V7 LIQUID TUBE V/V V8 HOT GAS CHARGING V/V V9 LOW PRE. GAS SERVICE V/V V10 HIGH PRE. GAS SERVICE V/V V11 LIQUID SERVICE V/V CV1-1, CV-2 DISC. CHECK V/V CV2 HRV CHECK V/V CV3 HR CHECK V/V CV4 MAIN COOL CHECK V/V CV5-1, CV5-2 LIQUID TUBE CHECK V/V T1-1, T1-2 COMP TOP SENSOR T2-1, T2-2 DISC. SENSOR T3 SUC. SENSOR 2 T4 SUC. SENSOR 1 T5 WATER SENSOR T6 COND OUT SENSOR T7 LIQUID TUBE SENSOR T8 SC IN SENSOR T9 SC OUT SENSOR

28 6 Dimensional drawing 6-1. Heat recovery 1) AM080/100/120FXWA Unit : mm Description Description No. Name No. Name 8HP 10HP 12HP 8HP 10HP 12HP ➀ Liquid ref. pipe 9.52 (3/8") 9.52 (3/8") (1/2") ➄ Water inlet pipe PT 1-1/4 ➁ ➂ High pressure gas ref. pipe Low pressure gas ref. pipe (5/8") (3/4") (3/4") ➅ External contact wiring (3/4") (7/8") (1 1/8") ➆ Communication wiring ➃ Water outlet pipe PT 1-1/4 ➇ Power wiring - - -

29 6-1. Heat recovery 2) AM200FXWA Unit : mm Outdoor units No. Name Description No. Name Description ➀ Liquid ref. pipe (5/8") ➄ Water inlet pipe PT 1-1/4 ➁ High pressure gas ref. pipe (1 1/8") ➅ External contact wiring - ➂ Low pressure gas ref. pipe (1 1/8") ➆ Communication wiring - ➃ Water outlet pipe PT 1-1/4 ➇ Power wiring -

30 28

31 Capacity 1 Capacity table Capacity correction Capacity 29

32 1 Capacity table

33 Capacity

34 1 Capacity table

35 Capacity

36 1 Capacity table

37 Capacity

38 1 Capacity table

39 Capacity

40 1 Capacity table

41 Capacity

42 1 Capacity table

43 Capacity

44 1 Capacity table

45 Capacity

46 1 Capacity table

47 Capacity

48 1 Capacity table

49 Capacity

50 1 Capacity table

51 Capacity

52 1 Capacity table

53 Capacity

54 1 Capacity table

55 Capacity

56 1 Capacity table

57 Capacity

58 1 Capacity table

59 Capacity

60 1 Capacity table

61 Capacity

62 1 Capacity table

63 Capacity

64 1 Capacity table

65 Capacity

66 1 Capacity table

67 Capacity

68 1 Capacity table

69 Capacity

70 1 Capacity table

71 Capacity

72 1 Capacity table

73 Capacity

74 1 Capacity table

75 Capacity

76 1 Capacity table

77 Capacity

78 1 Capacity table

79 Capacity

80 1 Capacity table

81 Capacity

82 1 Capacity table

83 Capacity

84 1 Capacity table

85 Capacity

86 1 Capacity table

87 Capacity

88 1 Capacity table

89 Capacity

90 1 Capacity table

91 Capacity

92 1 Capacity table

93 Capacity

94 1 Capacity table

95 Capacity

96 1 Capacity table

97 Capacity

98 1 Capacity table

99 Capacity

100 1 Capacity table

101 Capacity

102 1 Capacity table

103 Capacity

104 1 Capacity table

105 Capacity

106 1 Capacity table

107 Capacity

108 1 Capacity table

109 Capacity

110 1 Capacity table

111 Capacity

112 1 Capacity table

113 Capacity

114 1 Capacity table

115 Capacity

116 1 Capacity table

117 Capacity

118 1 Capacity table

119 Capacity

120 1 Capacity table

121 Capacity

122 1 Capacity table

123 Capacity

124 1 Capacity table

125 Capacity

126 1 Capacity table

127 Capacity

128 1 Capacity table

129 Capacity

130 1 Capacity table

131 Capacity

132 1 Capacity table

133 Capacity

134 1 Capacity table

135 Capacity

136 1 Capacity table

137 Capacity

138 1 Capacity table

139 Capacity

140 1 Capacity table

141 Capacity

142 1 Capacity table

143 Capacity

144 1 Capacity table

145 Capacity

146 1 Capacity table

147 Capacity

148 1 Capacity table

149 Capacity

150 1 Capacity table

151 Capacity

152 1 Capacity table

153 Capacity

154 1 Capacity table

155 Capacity

156 1 Capacity table

157 Capacity

158 1 Capacity table

159 Capacity

160 1 Capacity table

161 Capacity

162 1 Capacity table

163 Capacity

164 2 Capacity correction 2-1. Capacity correction factor 1. Correction coefficient( ) represents the capacity change rate of the system during the maximum load operation in the standard condition. (The correction coefficient( ) value is not much different from that of the standard condition.) 2. When the equivalent length of main pipe is 90m or more between the outdoor unit and the farthest indoor unit, the diameter of the main gas and liquid pipes must be increased by one grade larger. 3. When the pipe length after the first refrigerant branch kit is 45m or more, the diameter of the gas and liquid pipes between first and final branch kit must be increased by one grade larger. 4. In this cases, correction coefficient( ) is measured as below based on the overall equivalent length. The overall equivalent length = (Equivalent length of main pipe x correction factor) + (Equivalent length of first branch ~ last branch pipe x correction factor) + (Equivalent length of last branch ~ farthest indoor unit) ex) When the condition is System 8HP a. Main pipe : 80 m (Size Up) b. First branch~last branch pipe : 30 m (Size Up) c. Last branch~farthest ondoor unit : 25 m Cooling : The overall equivalent length = 80 x x = 80m Heating : The overall equivalent length = 80 x x = 47m Heating correction coefficient( ) = The correction coefficient( ) can be reduced according to the condition of pipe insulation. 1) AM080FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) *

165 2) AM100FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) * Capacity 3) AM120FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) *

166 2 Capacity correction 2-1. Capacity correction factor 4) AM160FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) * ) AM180FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) *

167 6) AM200FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) * Capacity 7) AM220FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) *

168 2 Capacity correction 2-1. Capacity correction factor 8) AM240FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) * ) AM260FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) *

169 10) AM280FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) * Capacity 11) AM300FXWANR (1) Cooling Level Difference (m) Pipe Length (m) * (2) Heating Level Difference (m) Pipe Length (m) *