CONTENTS PC BOARD TX-RX UNIT (X XX) TX-RX SECTION DISPLAY SECTION SCHEMATIC DIAGRAM... 26

Transcript

1 VHF FM TRANIVR TK-0 RVI MANUAL UPPLMNT 0- PRINT IN JAPAN --00 (Y) PF This service manual (--00) has been revised due to the modification of the Final Transistor and issues it as a supplemental manual. This service manual applies to products with A0000 or subsequent serial numbers. Refer to the TK-0 service manual for any information which has not been covered in this manual. abinet (A0-0-) Microphone (T-0-) Knob (VOL) (K--0) Key top (K--0) Panel assy (A-0-) YTM TUP... IAMLY FOR RPAIR... PART LIT... XPLO VIW... PAKIN... ONTNT P OAR TX-RX UNIT (X-00-XX)... 0 TX-RX TION... 0 IPLAY TION... HMATI IARAM... This product complies with the RoH directive for the uropean market. This product uses Lead Free solder.

2 TK-0 ocument opyrights opyright 0 by Kenwood orporation. All rights reserved. No part of this manual may be reproduced, translated, distributed, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, for any purpose without the prior written permission of Kenwood. isclaimer While every precaution has been taken in the preparation of this manual, Kenwood assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Kenwood reserves the right to make changes to any products herein at any time for improvement purposes. YTM T-UP Merchandise received License and frequency allocated by F hoose the type of transceiver Transceiver programming Frequency range.~mhz ~0MHz RF power 0W 0W Type TK-0 K TK-0 K Note : Internal beat interference exists at both.00mhz and.000mhz. A personal computer programming interface (KP-), and programming software (KP-) are required for programming. (The frequency and signalling data are programmed for the transceiver.) Are you using the external speaker? NO Y K- (XT. P) Are you using the ignition sense cable? NO Y KT- elivery ompatibility information IAMLY FOR RPAIR The Final transistor (Q,:0) has been discontinued by the supplier, so New Final transistor (A) has been applied on to X-00-XX production. TK-0 K,K (TX-RX Unit : X-00-XX) Ref. Part Name OL Part /No. 000 and before NW Part /No. A0000 onwards ompatibility Q,Q Final transistor 0 A No P board (X-00-XX) J-00-x J-0-x No

3 PART LIT TK-0 New Parts. indicates safety critical components. Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Ref. No. Address New Parts No. escription TK-0 * A0-0- MTALLI AINT A * A-0- PANL AY --0 AUTION TIKR * --0 AUTION TIKR --0 TIKR MX MAX -0-0 RIAL NUMR TIKR estination * --0 INTRUTION MANUAL AORY --0 MOL NAM-PLAT K * -- MOL NAM-PLAT K 0-- ANTNNA AL 0-- OR AORY --0 LA WIR WITH ONNTOR AORY A -0-0 FLAT AL (MI&VOL UNIT:P) A * -0- LA WIR WITH ONNTOR (P) 0 * -0- LA WIR WITH ONNTOR (P) A * --0 FLAT AL (IPLAY UNIT:P) A F0-0-0 HILIN PLAT * F-0-0 HILIN HT F FU(X0 0A) AORY A FLAT PRIN 0 A FLAT PRIN A * 0--0 FIROU HT (HAI UPPR) * 0--0 FIROU HT (HAI P) A, * 0--0 FIROU HT (HAI I) * FIROU HT (A) * 0--0 FIROU HT (HAI LOWR) * --0 RUR HT --0 UHION (HAI RAR) --0 UHION (P) 0 * --0 UHION (P WIR) -0-0 PAKIN (P) -0-0 PAKIN (A) * H0-0-0 INNR ARTON A * H-0- PAKIN FIXTUR (FRONT) * H-0- PAKIN FIXTUR (RAR) * H-0-0 PROTTION HT H-0-0 PROTTION A (0/00/0.0) H-0-0 ITM ARTON A 0 J-- HOLR AORY J--0 HARWAR FIXTUR(P ONNTOR) J--0 HARWAR FIXTUR (P) J-0-0 RAKT AORY * J-0-0 UHIN (P ONNTOR) J-0-0 AHIV HT(P) A K--0 KY TOP 0 A K--0 KNO A * N-0- OVAL HA MAHIN RW A N-00- PAN HA M RW L : candinavia K : UA P : anada Y : PX (Far ast, Hawaii) T : ngland : urope : hina X : Australia M : Other Areas TK-0 TX-RX UNIT (X-00-XX) Ref. No. Address New Parts No. escription estination A, N-0- RAZIR HA TAPTIT RW N-0-0 RW T AORY * T0-0- PAKR T-0- MIROPHON AORY TX-RX UNIT (X-00-XX) -0 : K, - : K 0 -- ILLUMINATION UI FILTR L 0 * --0 INTR ONNTOR 0 * J--0 MOUNTIN HARWAR L(R/RN) L(Y/) L KH0K HIP 0.00UF K HH0J HIP PF J K HH0J HIP PF J K KH0K HIP 0.00UF K HHJ HIP 0PF J K KH0K HIP 0.00UF K KH0K HIP 000PF K KH0K HIP 0.00UF K HH0J HIP 00PF J K HH0J HIP PF J K HIP PF J K HIP PF J K HH0J HIP 00PF J K KH0K HIP 0.00UF K K HH00 HIP 0PF K KHK HIP 00PF K KH0K HIP 0.00UF K, KHK HIP 00PF K - KH0K HIP 0.00UF K 0 HH0J HIP PF J K 0 HH0J HIP PF J K, HH0J HIP 00PF J K, HHJ HIP 0PF J K HH0J HIP PF J K HH0J HIP PF J K HH0J HIP PF J K HH0J HIP PF J K KH0K HIP 0.00UF K, KH0K HIP 0.00UF K 0 * --0 HIP 0PF J K 0 * --0 HIP 0PF J K * 0AR0M LTRO UF WV KH0K HIP 0.00UF K KHK HIP 00PF K KH0K HIP 0.00UF K AA0M HIP TNTL UF 0WV KH0K HIP 0.00UF K,0-0-0 HIP 00PF K

4 TK-0 PART LIT TX-RX UNIT (X-00-XX) HH0J HIP PF J K HH0J HIP PF J K * 0--0 ALUMINIUM LTROLYTI (0UF) KF0K HIP 0.0UF K KHK HIP 00PF K HH0J HIP 00PF J KF0K HIP 0.0UF K 0 KH0K HIP 0.00UF K KF0K HIP 0.00UF K KHK HIP 0.0UF K HH00 HIP.0PF HH0J HIP PF J KH0K HIP 0.00UF K KF0K HIP 0.0UF K - KH0K HIP 0.00UF K HH0J HIP PF J KH0K HIP 0.00UF K HH00 HIP.0PF, HH0J HIP PF J K, HH0J HIP PF J K, KK HIP 0.0UF K 0 MFH0J HIP PF J K 0 MFH0J HIP PF J K MFH0J HIP PF J K MFH0J HIP PF J K MFHJ HIP 0PF J KH0K HIP 0.00UF K MFH0J HIP PF J K MFH0J HIP PF J K MFH0J HIP PF J K, MFH0J HIP PF J K, MFH0J HIP PF J K MFH0J HIP PF J K MFH0J HIP PF J K MFH0J HIP PF J K 0 KH0K HIP 0.00UF K HH0J HIP PF J K HH0J HIP PF J K HH0J HIP 00PF J K HHJ HIP 0PF J K HH0J HIP PF J K HH0J HIP PF J K, HH0J HIP PF J K, HH0J HIP PF J K HH0J HIP PF J K HH0J HIP PF J K, HH0J HIP PF J K, HH0J HIP PF J K HH0J HIP PF J K HH0J HIP PF J K 0 HH0J HIP 00PF J K 0 HHJ HIP 0PF J K HH0J HIP PF J K HH0J HIP PF J K - KH0K HIP 0.00UF K * --0 HIP 0PF J K * --0 HIP 0PF J K Ref. No. Address New Parts No. escription 0 * 0--0 LTRO 0UF WV 0 KHK HIP 00PF K LTRO 000UF WV 0 * 0AHRM LTRO.UF 0WV 0,0 KF0K HIP 0.0UF K 0 K0K HIP.0UF K 0 * 0AR0M LTRO UF WV 0,0 KF0K HIP 0.0UF K * 0AR0M LTRO 00UF WV * 0AR0M LTRO UF WV A0J00M HIP TNTL 0UF.WV, KFK HIP 0.UF K, KH0K HIP 000PF K, KF0K HIP 0.0UF K 0 * 0AR0M LTRO UF WV KFF0Z HIP.0UF Z KHK HIP 0PF K - KH0K HIP 0.00UF K KFF0Z HIP.0UF Z KHK HIP 0PF K 0 A0J0M HIP TNTL UF.WV KH0K HIP 000PF K, KH0K HIP 0.00UF K KF0K HIP 0.0UF K, A0J00M HIP TNTL 0UF.WV, KFK HIP 0.UF K K0K HIP 0.0UF K 0 KFK HIP 0.UF K K0K HIP 0.0UF K KHK HIP 0PF K Ref. No. Address New Parts No. escription estination estination KH0K HIP 0.00UF K K, KH0K HIP 000PF K 00 K0K HIP 0.0UF K 0 HH0J HIP PF J K 0 HH0J HIP 00PF J 0 HH00 HIP.0PF K 0 HH0J HIP PF J K 0 HH0J HIP PF J K 0 K0K HIP 0.0UF K 0 KH0K HIP 000PF K 0 AA00M HIP TNTL 0UF 0WV 0, KH0K HIP 0.00UF K K0K HIP 0.0UF K HH00 HIP.0PF K KH0K HIP 0.00UF K HH0J HIP PF J K HH0J HIP PF J K K0K HIP 0.0UF K KH0K HIP 0.00UF K K0K HIP 0.0UF K HH00 HIP.0PF K HH0J HIP 00PF J K0K HIP 0.0UF K HH0J HIP PF J KH0K HIP 000PF K HH00 HIP 0PF HH0J HIP PF J HH00 HIP.0PF 0 HH0J HIP PF J, KH0K HIP 0.00UF K

5 PART LIT TK-0 Ref. No. Address New Parts No. escription KHK HIP 0PF K KHK HIP 0PF K - KH0K HIP 000PF K HH00 HIP.0PF 0 HH0J HIP PF J KH0K HIP 000PF K KK HIP 0.0UF K KH0K HIP 000PF K HHR HIP.PF KH0K HIP 000PF K, KH0K HIP 0.00UF K HH00 HIP.0PF 0 HHR HIP.PF HH0R HIP 0.PF KH0K HIP 000PF K KH0K HIP 0.00UF K KH0K HIP 000PF K K0K HIP 0.0UF K - KH0K HIP 000PF K 0 HH00 HIP.0PF K0K HIP 0.0UF K KH0K HIP 000PF K A00M HIP TNTL.0UF WV HH0J HIP PF J, K0K HIP 0.0UF K,0 KH0K HIP 000PF K KH0K HIP 0.00UF K KH0K HIP 000PF K K0K HIP 0.0UF K KHK HIP 0PF K, KH0K HIP 000PF K KFHK HIP 0.0UF K A0J00M HIP TNTL 0UF.WV KFK HIP 0.UF K 0 KH0K HIP 0.00UF K Ref. No. Address New Parts No. escription TX-RX UNIT (X-00-XX) 00 KH0K HIP 0.00UF K 0 KH0K HIP 0.0UF K 0 AARM HIP TNTL.UF WV 0 HH0J HIP PF J 0,0 KH0K HIP 0.00UF K estination estination 0 HH0J HIP PF J K 0 HH0J HIP PF J K 0 KH0K HIP 0.00UF K 0 HHJ HIP 0PF J 0 KH0K HIP 0.00UF K - KH0K HIP 0.00UF K KH0K HIP 000PF K K0K HIP.0UF K KH0K HIP 0.00UF K KH0K HIP 000PF K * AAARM HIP TNTL.UF 0WV 0 KH0K HIP 000PF K HHJ HIP 0PF J HH0J HIP PF J - KH0K HIP 0.00UF K KHK HIP 00PF K 0 HHJ HIP 0PF J 0 A0J00M HIP TNTL 0UF.WV 0 HH00 HIP 0PF 0 KH0K HIP 0.00UF K 0,0 KH0K HIP 000PF K 0 A0J00M HIP TNTL 0UF.WV 0 A0J0M HIP TNTL UF.WV, KH0K HIP 0.00UF K HH00 HIP 0PF KH0K HIP 000PF K HH00 HIP 0PF, KH0K HIP 000PF K KH0K HIP 0.00UF K KH0K HIP 0.00UF K A0J00M HIP TNTL 0UF.WV KH0K HIP 0.00UF K HH0J HIP PF J K HH0J HIP PF J K, HH0J HIP PF J HH00 HIP.0PF HH0J HIP PF J 0 HH00 HIP.0PF HH0J HIP 00PF J HH00 HIP.0PF HH0J HIP PF J HH00 HIP.0PF HH0J HIP PF J HHR HIP.PF 00 HH0J HIP PF J 0,0 HHR HIP.PF 0 HH0J HIP PF J 0,0 HHR HIP.PF 0 HH0J HIP PF J 0,0 KH0K HIP 000PF K 0 HH00 HIP.0PF 0- KH0K HIP 000PF K A0JRM HIP TNTL.UF.WV, KH0K HIP 000PF K KHK HIP 00PF K HH0J HIP 00PF J A0JRM HIP TNTL.UF.WV HH0J HIP PF J HHJ HIP 0PF J K HH0J HIP PF J K 0 KH0K HIP 000PF K - HH0J HIP 00PF J, KH0K HIP 000PF K HH0J HIP 00PF J KH0K HIP 000PF K HH0J HIP PF J KH0K HIP 0.00UF K 0 KH0K HIP 000PF K HH0J HIP 00PF J AV0RM HIP TNTL 0.UF WV A0J00M HIP TNTL 0UF.WV A00M HIP TNTL.0UF WV, A0J0M HIP TNTL UF.WV KK HIP 0.0UF K KH0K HIP 000PF K K, KH0K HIP 000PF K K HH0J HIP 00PF J K

6 TK-0 PART LIT TX-RX UNIT (X-00-XX) 0 HH00 HIP.0PF K 0 HH00 HIP.0PF K A00M HIP TNTL.0UF WV KH0K HIP 0.00UF K A0J00M HIP TNTL 0UF.WV KH0K HIP 000PF K HH00 HIP.0PF K KH0K HIP 000PF K HH0J HIP PF J 0, KH0K HIP 000PF K HH0J HIP PF J HH0J HIP PF J KH0K HIP 000PF K HH0J HIP PF J 0 HH0J HIP PF J KH0K HIP 000PF K HH00 HIP.0PF HH0J HIP PF J, KH0K HIP 000PF K HH0J HIP PF J HH0J HIP PF J HH00 HIP.0PF 0 HH00 HIP.0PF K HH00 HIP.0PF KH0K HIP 000PF K HH0J HIP PF J K HH0J HIP PF J KH0K HIP 000PF K HH00 HIP 0PF HH00 HIP.0PF - KH0K HIP 000PF K K, KH0K HIP 000PF K K 0 HH0J HIP PF J K - KH0K HIP 000PF K K HH0J HIP PF J KH0K HIP 0.00UF K KH0K HIP 000PF K KH0K HIP 0.00UF K HH0J HIP PF J 0 KH0K HIP 000PF K 0 KFF0Z HIP.0UF Z 0 KHK HIP 0PF K 0 KH0K HIP 0.00UF K 0 KHK HIP 00PF K 0 KFF0Z HIP.0UF Z 0 KHK HIP 00PF K 0 KHK HIP 0PF K 0 A0J0M HIP TNTL UF.WV 0 KH0K HIP 000PF K - HHH0J HIP 00PF J 0 KH0K HIP 000PF K A0J00M HIP TNTL 0UF.WV KH0K HIP 000PF K K0K HIP 0.0UF K 0 K0K HIP 0.0UF K 0 A0J00M HIP TNTL 0UF.WV 0 KHK HIP 00PF K 0 HHJ HIP 0PF J K0K HIP 0.0UF K K0K HIP 0.0UF K Ref. No. Address New Parts No. escription KHK HIP 0PF K 0 KH0K HIP 0.00UF K KH0K HIP 0.00UF K, HH0J HIP 00PF J KHK HIP 0PF K 0, HH0J HIP 00PF J K0K HIP 0.0UF K, HH0J HIP 00PF J K0K HIP 0.0UF K, HH0J HIP 00PF J, HH0J HIP 00PF J, HH0J HIP 00PF J, HH0J HIP 00PF J 0, HH0J HIP 00PF J, HH0J HIP 00PF J HH0J HIP 00PF J KH0K HIP 000PF K HH0J HIP 00PF J 0 A0J00M HIP TNTL 0UF.WV - KH0K HIP 000PF K KK HIP 0.0UF K 0 HHJ HIP 0PF J KH0K HIP 0.00UF K KK HIP 0.0UF K KH0K HIP 0.00UF K KHK HIP 00PF K HHJ HIP 0PF J KH0K HIP 0.00UF K KHK HIP 00PF K KK HIP 0.0UF K KK HIP 0.0UF K 0 KH0K HIP 0.00UF K HH0J HIP 00PF J ARM HIP TNTL 0.UF WV KH0K HIP 0.00UF K KK HIP 0.0UF K K0K HIP 0.0UF K - KH0K HIP 0.00UF K A0JRM HIP TNTL.UF.WV K0K HIP 0.0UF K, KH0K HIP 0.00UF K A0J00M HIP TNTL 0UF.WV K0K HIP 0.0UF K HHJ HIP 0PF J KH0K HIP 0.00UF K KH0K HIP 000PF K 00 KH0K HIP 0.00UF K 0 KHJ HIP 00PF J 0 K0K HIP 0.0UF K 0-0 KH0K HIP 0.00UF K 0,0 K0K HIP 0.0UF K 0 KH0K HIP 0.00UF K 0 K0K HIP 0.0UF K 0- KHJ HIP 00PF J KHJ HIP 00PF J HH0J HIP PF J KK HIP 0.0UF K, KHJ HIP 00PF J HH00 HIP.0PF A0J00M HIP TNTL 0UF.WV Ref. No. Address New Parts No. escription estination estination

7 PART LIT TK-0 Ref. No. Address New Parts No. escription 0 HHJ HIP 0PF J HH00 HIP.0PF KHJ HIP 00PF J KH0K HIP 000PF K A0J00M HIP TNTL 0UF.WV Ref. No. Address New Parts No. escription TX-RX UNIT (X-00-XX) estination estination L L-0- MALL FIX INUTOR(UH) L L-- MALL FIX INUTOR(0.UH) K L * L-- MALL FIX INUTOR(0.UH) K L, L-0-0 HIP FRRIT L L-0- MALL FIX INUTOR(UH) K K0K HIP 0.0UF K HH0J HIP 00PF J -0 K0K HIP 0.0UF K KH0K HIP 0.00UF K A0J00M HIP TNTL 0UF.WV KHK HIP 00PF K KH0K HIP 0.00UF K KHK HIP 00PF K A0JRM HIP TNTL.UF.WV KK HIP 0.0UF K HH0J HIP 00PF J 0 KFHK HIP 0.0UF K A0JRM HIP TNTL.UF.WV KH0K HIP 000PF K KHK HIP 00PF K K0K HIP 0.0UF K -0-0 HIP 0PF K K HIP 0PF K K, -0-0 HIP 0PF K K -0-0 HIP 0PF K K -0-0 HIP 0PF J K -0-0 HIP 0PF J K 0,0 KH0K HIP 000PF K 0 KH0K HIP 000PF K 0 A00M HIP TNTL.0UF WV 0 HH0J HIP 00PF J T RAMI TRIMMR APAITOR(0PF) T RAMI TRIMMR APAITOR(0PF) N FLAT AL ONNTOR N --0 PIN AY N FLAT AL ONNTOR N PIN AY N --0 PIN AY N PIN AY N FLAT AL ONNTOR N FLAT AL ONNTOR J0-0-0 MOULAR JAK W * PRO LA WIR W OR A * F0-- HILIN PLAT A F0-0-0 HILIN PLAT A * F0--0 HILIN PLAT F F-0-0 FU(A/V) F0 F-00-0 FU(.A/0V) A -- UHION A * J-00-0 UHIN A0 J-0-0 OLLAR (LH--.) F0,0 L-0-0 RAMI FILTR L * L-- MALL FIX INUTOR(0.UH) K L- L-- MALL FIX INUTOR(0.UH) L L--0 TOROIAL OIL L0 L-0-0 HOK OIL L * L-- TOROIAL OIL L L-0- TOROIAL OIL L * L-- TOROIAL OIL K L * L-- TOROIAL OIL K L L-0- MALL FIX INUTOR(UH) L L-0- TOROIAL OIL L L-0- MALL FIX INUTOR(UH) L * L--0 AIR-OR OIL K L, * L--0 AIR-OR OIL K L * L--0 AIR-OR OIL K L0 * L--0 AIR-OR OIL K L0 * L--0 AIR-OR OIL K L L-- MALL FIX INUTOR(0.UH) L, L0-- MALL FIX INUTOR(0NH) L, L-- MALL FIX INUTOR(0.UH) L L0-- MALL FIX INUTOR(NH) K L0 L-- MALL FIX INUTOR(0.0UH) K L0,0 * L-0-0 OIL K L0,0 * L--0 OIL K L0 L0-- MALL FIX INUTOR(NH) L0 L-00- MALL FIX INUTOR(0UH) L0,0 * L-0-0 OIL K L0,0 * L--0 OIL K L0 L0-- MALL FIX INUTOR(NH) L0,0 L0-- MALL FIX INUTOR(NH) L L0-- MALL FIX INUTOR(0NH) L L0-- MALL FIX INUTOR(0NH) K L L0-- MALL FIX INUTOR(0NH) K L, L--0 TOROIAL OIL L L-0-0 HIP FRRIT L L--0 TOROIAL OIL L L0-- MALL FIX INUTOR(0NH) L L-- MALL FIX INUTOR(.UH) L L--0 AIR-OR OIL L0 L-- MALL FIX INUTOR(.UH) L L-0- MALL FIX INUTOR(UH) L, * L--0 OIL L * L--0 OIL L * L--0 OIL L, L0-- MALL FIX INUTOR(0NH) L L0-- MALL FIX INUTOR(0NH) L- L-0-0 AIR-OR OIL L L--0 OIL L0 L-0- MALL FIX INUTOR(.0UH) L0 L-0- MALL FIX INUTOR(.0UH) L0,0 L-0-0 HIP FRRIT L0 L-- MALL FIX INUTOR(.UH)

8 TK-0 PART LIT TX-RX UNIT (X-00-XX) L0-0 L-0-0 HIP FRRIT L L0-- MALL FIX INUTOR(0NH) L L-- MALL FIX INUTOR(0NH) L L-0-0 HIP FRRIT L L0-- MALL FIX INUTOR(NH) K L L0-- MALL FIX INUTOR(NH) K L L-0-0 HIP FRRIT L L0-- MALL FIX INUTOR(0NH) K L * L--0 VO L L0-- MALL FIX INUTOR(0NH) K L- L-0-0 HIP FRRIT L L0-- MALL FIX INUTOR(NH) L L0-- MALL FIX INUTOR(NH) L L0-- MALL FIX INUTOR(NH) L L0-- MALL FIX INUTOR(NH) L L0-- MALL FIX INUTOR(0NH) L L0-- MALL FIX INUTOR(NH) L L0-- MALL FIX INUTOR(NH) L0 L0-- MALL FIX INUTOR(NH) L, L0-0- MALL FIX INUTOR(00NH) L L0-- MALL FIX INUTOR(0NH) L L0-- MALL FIX INUTOR(NH) L L0-- MALL FIX INUTOR(NH) L L0-- MALL FIX INUTOR(NH) L L0-0- MALL FIX INUTOR(00NH) L L0-- MALL FIX INUTOR(0NH) L0 L0-- MALL FIX INUTOR(0NH) K L L0-0- MALL FIX INUTOR(0NH) K L0 L-0-0 HIP FRRIT L0 L-00- MALL FIX INUTOR(0UH) L0-0 L-0-0 HIP FRRIT L0-0 L-00-0 HIP FRRIT L0 L-0-0 HIP FRRIT X0 L-0-0 VXO (.MHZ) X0 L-0- RYTAL RONATOR(.MHZ) XF0 L-00-0 MF (.MHZ) P0-0 R0-0-0 MULTIPL RITOR P0- R MULTIPL RITOR P R0-0-0 MULTIPL RITOR P, R0-0-0 MULTIPL RITOR R RKAJ HIP R K J /0W K R RKAJ HIP R K J /0W K R RKAJ HIP R 0 J /0W R RKA00J HIP R 0 J /0W R RKAJ HIP R.K J /0W R RKA0J HIP R J /0W R RKAJ HIP R 0 J /0W R RKAJ HIP R 0 J /0W K R RKA00J HIP R 0 J /0W K R RKA0J HIP R J /0W K R RKAJ HIP R 0 J /0W K R0 RKA0J HIP R J /0W R RKAJ HIP R K J /0W K R RKAJ HIP R K J /0W K R RKAJ HIP R K J /0W R RKAJ HIP R K J /0W R RKAJ HIP R.K J /0W R - RKF0J HIP R 00 J /W R - R--0 HIP R. J W Ref. No. Address New Parts No. escription R, RF0J FL-PROOF R 00 J W R RKA0J HIP R 00K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R.0M J /0W R RKA0J HIP R J /0W R RKA0J HIP R 0K J /0W R0, RKA0J HIP R J /0W R RKA0J HIP R J /0W R RKAJ HIP R K J /0W R RKAJ HIP R K J /0W Ref. No. Address New Parts No. escription estination estination R RKAJ HIP R K J /0W R RKA000J HIP R 0.0 J /0W K R RKAJ HIP R 0 J /0W R RKA0J HIP R.0K J /0W R RKAJ HIP R 0 J /0W K R RKA000J HIP R 0.0 J /0W R, RKA000J HIP R 0.0 J /0W R RKAJ HIP R K J /0W R RKA000J HIP R 0.0 J /0W R RKA0J HIP R 0K J /0W R RKAJ HIP R.K J /0W R0 RKA0J HIP R 00K J /0W R RKA000J HIP R 0.0 J /0W K R RKAJ HIP R 0 J /0W K R RKAJ HIP R 0 J /0W R RKAJ HIP R 0 J /0W R RKA0J HIP R 00K J /0W R - RKAJ HIP R.K J /0W R0 RKAJ HIP R K J /0W R RKA0J HIP R 0K J /0W R RKAJ HIP R K J /0W R RKAJ HIP R.K J /0W R - * RKR0J HIP R.0 J /W R, RKF000J HIP R 0.0 J /W R RKA0J HIP R J /0W K R RKAJ HIP R 0 J /0W R0 RRJ FL-PROOF R. J W R0 RKA0J HIP R.0K J /0W R0 RKA0J HIP R 00K J /0W R0 RKAJ HIP R K J /0W R0 RKA0J HIP R 00K J /0W R0 RKA000J HIP R 0.0 J /0W R0 RKAJ HIP R K J /0W R0 RKAJ HIP R K J /0W R0 RKA0J HIP R 0K J /0W R0 RKF000J HIP R 0.0 J /W R RKA0J HIP R 0K J /0W R RKAJ HIP R 0 J /0W R RKA0J HIP R 00K J /0W R RKAJ HIP R K J /0W R- RKAJ HIP R K J /0W R RKAJ HIP R.K J /0W R- RKAJ HIP R K J /0W R RKAJ HIP R.K J /0W R, RKAJ HIP R.K J /0W R RKAJ HIP R K J /0W R RKAJ HIP R 0K J /0W R- RKA0J HIP R 0K J /0W R RKA00J HIP R 0 J /0W R RKAJ HIP R K J /0W

9 PART LIT TK-0 Ref. No. Address New Parts No. escription R RKA0J HIP R 0K J /0W R RKAJ HIP R 0K J /0W R RKA0J HIP R 00K J /0W R, RKAJ HIP R 0K J /0W R0, RKA0J HIP R 00K J /0W R RKAJ HIP R K J /0W R, RKA0J HIP R 0K J /0W R RKA0J HIP R.0K J /0W R RKAJ HIP R 0 J /0W R0 RKAJ HIP R K J /0W R0,0 RKA0J HIP R 0K J /0W R0 RKAJ HIP R K J /0W R0 RKA0J HIP R.0K J /0W R0-0 RKA0J HIP R 0K J /0W R RKA0J HIP R J /0W R RKA0J HIP R J /0W R RKA000J HIP R 0.0 J /0W R RKA0J HIP R 0K J /0W R RKA000J HIP R 0.0 J /0W R RKA000J HIP R 0.0 J /0W R RKA000J HIP R 0.0 J /0W R RKA000J HIP R 0.0 J /0W R RKAJ HIP R 0 J /0W R RKAJ HIP R.K J /0W R RKA0J HIP R 00 J /0W R RKA000J HIP R 0.0 J /0W R0 RKA0J HIP R J /0W R RKA0J HIP R.0K J /0W R RKA0J HIP R 00K J /0W R RKA000J HIP R 0.0 J /0W R RKA0J HIP R 0K J /0W R RKAJ HIP R.K J /0W R RKA0J HIP R.0K J /0W R, RKAJ HIP R.K J /0W R,0 RKA0J HIP R 0K J /0W R RKAJ HIP R.K J /0W R RKA00J HIP R 0 J /0W R, RKA000J HIP R 0.0 J /0W R RKA00J HIP R 0 J /0W R RKA0J HIP R.0K J /0W R RKA000J HIP R 0.0 J /0W R RKAJ HIP R K J /0W R RKAJ HIP R 0K J /0W R RKAJ HIP R 0K J /0W R RKA000J HIP R 0.0 J /0W R RKAJ HIP R 0 J /0W R, RKAJ HIP R.K J /0W R RKA0J HIP R 00 J /0W R RKA0J HIP R.0K J /0W R RKAJ HIP R 0K J /0W R RKA0J HIP R 00K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R 00K J /0W R RKA000J HIP R 0.0 J /0W R RKA0J HIP R J /0W R RKAJ HIP R 0 J /0W R RKA0J HIP R J /0W R RKA0J HIP R 00K J /0W R0 RKA000J HIP R 0.0 J /0W R00 RKA00J HIP R 0 J /0W Ref. No. Address New Parts No. escription TX-RX UNIT (X-00-XX) estination estination R0 RKA0J HIP R 00K J /0W R0 RKA0J HIP R 0K J /0W R0 RKA000J HIP R 0.0 J /0W R0 RKAJ HIP R 0K J /0W K R0 RKAJ HIP R 0K J /0W K R0 RKA0J HIP R 00K J /0W R0 RKAJ HIP R K J /0W R0 RKA0J HIP R 00 J /0W R0 RKAJ HIP R 0 J /0W R0 RKAJ HIP R 0 J /0W R0 RKA0J HIP R J /0W R RKA0J HIP R 0K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R 0K J /0W R RKAJ HIP R.K J /0W R RKA0J HIP R 00 J /0W R, RKA0J HIP R 0K J /0W R RKA000J HIP R 0.0 J /0W R,0 RKAJ HIP R.K J /0W R RKAJ HIP R K J /0W R RKAJ HIP R 0K J /0W R RKA0J HIP R 00K J /0W R RKA0J HIP R.0K J /0W R RKAJ HIP R K J /0W R RKAJ HIP R.K J /0W R RKA0J HIP R 0K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R J /0W R0 RKAJ HIP R 0K J /0W R RKAJ HIP R K J /0W R RKAJ HIP R 0K J /0W R RKAJ HIP R.K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R 0K J /0W R RKA0J HIP R.0K J /0W R RKA0J HIP R 00 J /0W R RKA0J HIP R 0K J /0W R RKA0J HIP R 00 J /0W R0, RKA0J HIP R.0K J /0W R RKA0J HIP R 00K J /0W R0 RKAJ HIP R K J /0W R0 RKA0J HIP R J /0W R0 RKA000J HIP R 0.0 J /0W R0 RKAJ HIP R.K J /0W R0 RKA000J HIP R 0.0 J /0W R RKA0J HIP R J /0W R RKA0J HIP R 0K J /0W R, RKA00J HIP R 0 J /0W R RKA0J HIP R.0K J /0W R, RKA00J HIP R 0 J /0W R RKA0J HIP R.0K J /0W R RKA0J HIP R 0K J /0W R0 RKAJ HIP R 0 J /0W R RKA000J HIP R 0.0 J /0W K R, RKA000J HIP R 0.0 J /0W K R RKA00J HIP R 0 J /0W K R RKA0J HIP R 00 J /0W K R RKAJ HIP R 0 J /0W K R RKA0J HIP R.0K J /0W R RKAJ HIP R.K J /0W

10 TK-0 PART LIT TX-RX UNIT (X-00-XX) R RKA000J HIP R 0.0 J /0W R RKAJ HIP R 0K J /0W R RKA0J HIP R 00K J /0W K R RKAJ HIP R 0K J /0W K R0, RKA0J HIP R.0K J /0W R RKA0J HIP R 00K J /0W R, RKAJ HIP R K J /0W R RKAJ HIP R.K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R.0K J /0W K R RKAJ HIP R 0 J /0W K R RKAJ HIP R.K J /0W R RKA0J HIP R J /0W R RKAJ HIP R 0 J /0W K R RKAJ HIP R 0 J /0W K R- RKAJ HIP R.K J /0W R RKA000J HIP R 0.0 J /0W R RKA0J HIP R 00 J /0W R RKAJ HIP R 0 J /0W R RKA0J HIP R.0K J /0W R0 RKAJ HIP R 0K J /0W R RKAJ HIP R 0 J /0W R RKAJ HIP R K J /0W R RKA0J HIP R J /0W R, RKA00J HIP R 0 J /0W R RKAJ HIP R K J /0W R RKAJ HIP R 0K J /0W R0 RKA0J HIP R J /0W R RKA000J HIP R 0.0 J /0W R, RKA0J HIP R J /0W R RKA0J HIP R 00 J /0W R, RKA0J HIP R.0K J /0W R RKA000J HIP R 0.0 J /0W R0 RKA000J HIP R 0.0 J /0W K R0 RKA0J HIP R J /0W K R RKA0J HIP R J /0W K R RKA000J HIP R 0.0 J /0W K R00 RKHJJ HIP R K J /W R0 RKA0J HIP R 0K J /0W R0 RKAJ HIP R 0K J /0W R0 RKAJ HIP R K J /0W R0 RKA0J HIP R 0K J /0W R0 RKAJ HIP R K J /0W R0 RKA0J HIP R.0K J /0W R0 RKA00J HIP R 0 J /0W R0 RKAJ HIP R K J /0W R0 RKA0J HIP R 0K J /0W R0 RKA00J HIP R 0 J /0W R- RKAJ HIP R K J /0W R RKAJ HIP R.K J /0W R RKAJ HIP R K J /0W R0 RKA000J HIP R 0.0 J /0W R RKA0J HIP R 00K J /0W R RKAJ HIP R K J /0W R- RKA0J HIP R.0K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R.0K J /0W R0, RKAJ HIP R K J /0W R RKA000J HIP R 0.0 J /0W R, RKA000J HIP R 0.0 J /0W Ref. No. Address New Parts No. escription R, RKA000J HIP R 0.0 J /0W R, RKAJ HIP R 0K J /0W R00 RKAJ HIP R K J /0W R0-0 RKA0J HIP R.0K J /0W R0 RKA000J HIP R 0.0 J /0W R0 RKA0J HIP R 00K J /0W R0 RKF000J HIP R 0.0 J /W R0 RKA000J HIP R 0.0 J /0W R RKAJ HIP R K J /0W R RKA0J HIP R 00K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R 00K J /0W R-0 RKAJ HIP R K J /0W R RKF000J HIP R 0.0 J /W R RKAJ HIP R K J /0W R RKF000J HIP R 0.0 J /W R- RKAJ HIP R K J /0W R RKAJ HIP R 0K J /0W R0, RKAJ HIP R 0K J /0W R, RKA000J HIP R 0.0 J /0W R, RKA0J HIP R 0K J /0W R RKA000J HIP R 0.0 J /0W R RKAJ HIP R K J /0W R RKA0J HIP R 0K J /0W R0 RKAJ HIP R K J /0W R RKAJ HIP R K J /0W R, RKAJ HIP R 0K J /0W R RKAJ HIP R K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R 0K J /0W R RKAJ HIP R 0K J /0W R RKA0J HIP R 00 J /0W R RKA0J HIP R 00K J /0W R RKAJ HIP R K J /0W R RKA000J HIP R 0.0 J /0W R RKAJ HIP R K J /0W R RKAJ HIP R 0K J /0W R RKA000J HIP R 0.0 J /0W R RKAJ HIP R.K J /0W R RKAJ HIP R 0K J /0W R RKAJ HIP R.K J /0W R0 RKAJ HIP R.K J /0W R RKAJ HIP R K J /0W R RKA000J HIP R 0.0 J /0W R RKAJ HIP R.K J /0W R RKAJ HIP R K J /0W R RKAJ HIP R 0K J /0W R RKA0J HIP R 00K J /0W R RKAJ HIP R 0K J /0W R RKAJ HIP R K J /0W R RKA000J HIP R 0.0 J /0W R0 RNHJ HIP R K /W R RNHJ HIP R K /W R RKA0J HIP R 0K J /0W R RNHJ HIP R K /W R RNHJ HIP R K /W R RNHJ HIP R 0K /W R RKAJ HIP R 0K J /0W R RNHJ HIP R K /W R RKF000J HIP R 0.0 J /W Ref. No. Address New Parts No. escription estination estination 0

11 PART LIT TK-0 Ref. No. Address New Parts No. escription R RKA000J HIP R 0.0 J /0W R0 RKA0J HIP R 00K J /0W R RNHJ HIP R.K /W R RKAJ HIP R.K J /0W R RKAJ HIP R.M J /0W R, RKAJ HIP R.K J /0W R RNHJ HIP R K /W R RKAJ HIP R 0K J /0W R RKAJ HIP R.K J /0W R RNHJ HIP R.K /W R0 RKA0J HIP R 00 J /0W R, RKA0J HIP R 00K J /0W R RKAJ HIP R 0K J /0W R RKA0J HIP R 0K J /0W R RKAJ HIP R K J /0W R RKA0J HIP R 00K J /0W R RKAJ HIP R 0K J /0W R RKAJ HIP R K J /0W R00 RKAJ HIP R K J /0W R0 RKAJ HIP R K J /0W R0 RKAJ HIP R 0K J /0W R0,0 RKAJ HIP R 0 J /0W R0 RKA0J HIP R J /0W R0 RKA0J HIP R J /0W R0 RKAJ HIP R K J /0W R0 RKA000J HIP R 0.0 J /0W R0 RKAJ HIP R K J /0W R0 RKAJ HIP R 0K J /0W R RKAJ HIP R 0K J /0W R RKA0J HIP R 00K J /0W R RKA0J HIP R 0K J /0W R RKA000J HIP R 0.0 J /0W R- * RKR0J HIP R.0 J /W K R0,0 RKAJ HIP R K J /0W R0,0 * RKRHJ HIP R 0 J /W R0-0 RKA000J HIP R 0.0 J /0W R0 * RKRHJ HIP R 0 J /W R0,0 * RKRHJ HIP R 0 J /W R * RKRHJ HIP R 0 J /W R RKA00J HIP R 0 J /0W R RKAJ HIP R K J /0W R, * RKRHJ HIP R 0 J /W R- RKA0J HIP R.0K J /0W R RKA0J HIP R 00K J /0W R RKAJ HIP R 0K J /0W R- RKA0J HIP R 0K J /0W R RKA00J HIP R 0 J /0W VR0 * R-0-0 MI FIX VARIAL RITOR VR0 R-00-0 VARIAL RITOR K -0-0 RLAY HMA- IO HMA- IO, IO 0Z.F-Y ZNR IO 0 AA-FK IO Ref. No. Address New Parts No. escription 0 ZAA ZNR IO 0 0ZF-X,Y ZNR IO 0 IO 0 UZW.() ZNR IO 0 IO TX-RX UNIT (X-00-XX) 0 A0U IO 0 IO 0 0ZF-X,Y ZNR IO 0 HMA- IO K 0-0 KV0- VARIAL APAITAN IO 0 MAJ IO 0 MA-F IO 0 0Z.F-Y ZNR IO 00 H IO 0-0 MA0 IO 0-0 A0U IO MAJ IO - AP0U IO -F IO MINIM00F VARITOR AVRM00MAA VARITOR I TA0F-F MO-I I0 T0F(N)-F MO-I I0 * TA ANALOU I I0 KIA0API MO-I I0 TK0ML- I-POLAR I I0 U0FV MO-I I0 N0(Q) MO-I I0 TAFN MO-I I0 * KIFU-P MO-I I00 TA0F-F MO-I I0 * LMH0MM ANALOU I I0 LMXLTMX ANALOU I I0 PTNR MO-I I0 TK0ML- I-POLAR I I0 TWU0FU-F MO-I I0 * AA MU I0 AT0N-H ROM I I0 * T0FU-F MO-I I0 AT000TU ROM I I0-0 U0FV MO-I I0 TAW0FUF MO-I I0,0 TWFUF MO-I I0 LM MO-I I0 TWFUF MO-I I0 MFP-F MO-I I TWFUF MO-I I U0FV MO-I I TF MO-I I TAW0FUF MO-I I MPF0J MO-I I0 U0F MO-I I0 LW MO-I Q (N,P) TRANITOR Q TRANITOR Q K- FT Q, RFM0UX FT estination estination Q, A A TRANITOR

12 TK-0 PART LIT Ref. No. Address New Parts No. escription TX-RX UNIT (X-00-XX) Ref. No. Address New Parts No. escription estination estination Q K FT Q KTA-P(Y) TRANITOR Q0 K FT Q * RTN0U-T TRANITOR Q (Q,R) TRANITOR Q K FT Q K TRANITOR Q0 RTPU-T TRANITOR Q0 RTPU-T TRANITOR Q0 RTPU-T TRANITOR Q0 RTNU-T TRANITOR Q0 * RTP0U-T TRANITOR Q0 RTNU-T TRANITOR Q0 K FT Q0 RTNU-T TRANITOR Q0 K FT Q0 * J0-() FT Q RTPU-T TRANITOR Q- K FT Q (Q,R) TRANITOR Q, KTA-P(Y) TRANITOR Q, K FT Q0 K- FT Q0-0 K0NV(K) FT Q0 -F(Y) TRANITOR Q0 () TRANITOR Q00 K-FP FT Q0 A(R)F TRANITOR Q0-0 (R)F TRANITOR Q0 A(R)F TRANITOR Q0 K FT Q0 () TRANITOR Q0 * K(L) FT Q0 () TRANITOR Q0,0 (N,P) TRANITOR Q0 () TRANITOR Q0 K FT Q0 * RTN0U-T TRANITOR Q0,0 TK IITAL TRANITOR Q0 J FT Q0 K FT Q0 J FT Q0-0 K FT Q0,0 () TRANITOR Q0-0 K FT TH THRMITOR TH, THRMITOR TH THRMITOR

13 XPLO VIW TK-0 A The FF (Flexible Flat able) could be inserted to the connector at an angle. Make sure that the cable is inserted into the connector firmly to the end. Ax A M. x (O) L : N-0- : N-00- M. x (r-tap) : N-0- x 0 X (A/) x Q, x 0 x W X (/) VR0 J0 x X (/) 0 0 X (hassis) 0 Parts with the exploded numbers larger than 00 are not supplied.

14 TK-0 PAKIN Microphone (T-0-) Instruction manual (--0) 0 Warranty card Lead wire with connector (--0) 0 Holder (J--) cord (0--) 0 Pamphlet Protection sheet (H-0-0) Fuse (0A) (F-000-0) racket (J-0-0) Protection bag (H-0-0) crew set (N-0-0) Packing fixture (Front) (H-0-) Packing fixture (Rear) (H-0-) Inner packing case (H0-0-0) Item carton case (H-0-0) Parts with the exploded numbers larger than 00 are not supplied.

15 AJUTMNT TK-0 Key Functions in Panel Test Mode and Panel Tune Mode Knob/Key Test mode Tune mode Test mode/tune mode changeover Monitor ON/OFF N N ON/OFF Tuning value back up MON Frequency H down Tuning item down A Frequency H up Tuning item up ignalling H down Tuning value down ignalling H up Tuning value up Function panel Volume control L Power A key switch MI MON key connector W key MON A N UP key key TX/UY L key N key Panel Test Mode The transceiver's transmission output, receive sensitivity, and other items are measured and QT, QT, -tone and TMF signaling is decoded in this mode. Test frequency channel (MHz) : efault setting K H TX RX TX RX (enter) (Low) (High) Test signalling channel : efault setting H No. ncode tone ecode tone K None None 00Hz square wave None QT.0Hz QT.0Hz QT.Hz QT.Hz QT 0.Hz QT 0.Hz QT 0N QT 0N ingle tone Hz -tone./.hz TMF [] TMF [] MK None Panel Tune Mode The transceiver is adjusted in this mode. To enter the panel tune mode Press the [ ] key in the panel test mode. The adjustment items, the frequency and signalling, other than the maximum deviation and sensitivity, return to the values that were effective for the test frequency channel and test signalling channel before entering the panel tune mode. To enter the panel test mode Hold down [MON] and turn the power switch on to enter this mode. The test frequency channel and test signalling channel will be displayed. N on Test signalling H Test frequency H Note : When a key other than RP down is pressed, the optional signalling is reset.

16 TK-0 AJUTMNT Adjustment Points isassembly for Repair (peaker) To install the speaker and to style wiring from the speaker, follow the instructions given in the diagram below. ANT L0 N0 L0 L0 L0 N0 T0 T0 VR0 N0 N0 L L TP TP L L L Measurement Adjustment Item ondition Testequipment Unit Terminal Unit Parts Method pecifications/remarks. PLL lock ) H-I : - VM TX-RX TP heck.0~.v : K voltage Power meter (A/).~.V : K check Main VO ) H-I : -.~.V : K.0~.V : K ub RX-center ) H-I : - TP.~.V. Transmit ) H-I : - Power meter Rear ANT Front key H frequency ±00Hz frequency elect FRQ_XXX f. counter panel panel key in tune mode PTT : ON

17 AJUTMNT TK-0 Item ondition Measurement Testequipment Unit Terminal Adjustment Unit Parts Method pecifications/remarks. PF ) H-I : - pectru TX-RX N0 TX-RX L0 Adjust the coils in Adjust it so it is almost elect L analyzer (A/) (A/) L0 the following order symmetrical, and so the gain N : K L0 : L0, L0, L0, is maximum. N 0 : K Tracking Rear ANT L0 L0 in tune mode generator panel pectrum analyzer pan : 0MHz K K cale : 0d/div Tracking generator Output : 0dm H log MA 0d / RF 0d :.0d H log MA 0d / RF 0d :.d Marker :.MHz Marker : MHz TART 0.000,000MHz TOP 0.000,000MHz TART 0.000,000MHz TOP 0.000,000MHz. MF ) H-I : - pectrum TX-RX N0 TX-RX L Adjust it so it is almost symmetrical, and so the pectrum analyzer analyzer (A/) (A/) L gain is maximum. pan : khz L Adjust the coils in the following order : L, L, cale : 0d/div Tracking N0 L L, L. enter frequency :.MHz generator Tracking generator Output : 0dm H log MA 0d / RF 0d :.0d Marker :.0MHz enter frequency.0,000mhz PAN 0.00,000MHz. elay line ) H-I : - pectrum TX-RX N0 TX-RX T0 Adjust it so it is almost symmetrical, and so the N pectrum analyzer analyzer (A/) (A/) T0 gain is maximum. pan : 0MHz H log MA 0d / RF 0d :.d cale : 0d/div Tracking N0 enter frequency :.MHz generator Tracking generator Output : 0dm Marker :.MHz enter frequency.0,000mhz PAN 0.000,000MHz. istortion ) H-I : - Rear ANT TX-RX L Adjust it, and so istortion is minimum. output : dm/0µv panel (A/) the distortion is AF output : V/ istortion XT.P minimum. meter AF VTVM Oscilloscope dummy load

18 TK-0 AJUTMNT Item ondition Measurement Adjustment Testequipment Unit Terminal Unit Parts Method. RF power ) RF power Power meter Rear ANT Front key 0W 0w ±.0W _POW_XXX Ammeter panel panel key A or less A or less Adjust the RF power. All values in Low, enter and High frequencies changes one time. ) elect L _POW_XXX in tune mode PTT : ON ) elect _POW_XXX in tune mode PTT : ON ) elect H _POW_XXX in tune mode PTT : ON. Maximum ) H-I : - Power meter Rear ANT Front key ±.0kHz ±0.kHz deviation elect MXV_XXX eviation panel panel key in tune mode meter PTT : ON eviation meter filter AF VTVM Front MI HPF : OFF, LPF : khz A panel e-emphasis : OFF Oscilloscope A : khz/0mv. MI ) H-I : - TX-RX VR0 heck.~.khz sensitivity PTT : ON (A/) eviation meter filter HPF : OFF LPF : khz e-emphasis : OFF A : khz/mv 0. QT ) H-I : - Front key ±0.kHz ±0.0kHz deviation elect QTV_XXX panel key in tune mode PTT : ON eviation meter filter HPF : OFF LPF : khz e-emphasis : OFF. QT ) H-I : - ±0.kHz ±0.0kHz deviation elect QV_XXX in tune mode PTT : ON eviation meter filter HPF : OFF, LPF : khz e-emphasis : OFF. TMF ) H-I : - ±.0kHz ±0.kHz deviation elect TV_XXX in tune mode PTT : ON eviation meter filter HPF : OFF, LPF : khz e-emphasis : OFF. MK ) H-I : - ±.0kHz ±0.kHz deviation elect MV_XXX in tune mode PTT : ON eviation meter filter HPF : OFF, LPF : khz e-emphasis : OFF pecifications/remarks

19 AJUTMNT TK-0 Item. ensitivity Measurement Adjustment ondition Testequipment Unit Terminal Unit Parts Method ) ensitivity Rear ANT Front key N_XXX panel panel key Adjust the sensitivity. All values in Low, enter and High AF VTVM XT.P TX-RX L frequencies changes one time. istortion (A/) ) elect L meter Low check N : K Oscilloscope N 0 : K dummy in tune mode load output : dm/0.µv AF output : 0.µV/ ) elect ) elect N_0 in tune mode H N_0 in tune mode. quelch ) quelch tight point tight point Q_T_XXX Adjust the squelch tight point. All values in Low, enter and High frequencies changes one time. ) elect L Q_T_XXX in tune mode output : Value when d is added from the sensitivity value of d INA. N : ON ) elect Q_T_XXX in tune mode ) elect H Q_T_XXX in tune mode. quelch ) quelch open point open point Q_O_XXX Adjust the squelch open point. All values in Low, enter and High frequencies changes one time. ) elect L Q_O_XXX in tune mode output : Value when d is subtracted from the sensitivity value of d INA. N : ON ) output : OFF. N ) elect Front panel key key enter check High check Adjust to point of opening squelch heck Front key Adjust to point of Q_O_XXX in tune mode panel key opening squelch ) output : OFF ) elect heck H Front key Adjust to point of Q_O_XXX in tune mode panel key opening squelch ) output : OFF ) H-I : - Rear ANT output : 0dm/0.µV Pulse panel Pulse generator generator Output : 0.Vp-p/0 ycle : 00µsec istortion XT.P Pulse width : 0ns meter N : ON Oscilloscope AF VTVM Pulse generator heck heck oupler Radio Oscilloscope pecifications/remarks INA d or more quelch must be closed. quelch must be closed. quelch must be closed. INA d or more load AF VTVM istortion meter

20 0 J I H F A 0 TK-0 P OAR TX-RX UNIT : TX-RX TION omponent side Foil side Layer Layer Layer Layer Layer Layer omponent side view (J-0-0) (X-00-XX)(A/, /) R00 R0 R0 R0 R0 R0 R0 R0 R0 R0 R R0 R R R R 0 00 TH0 R R R R R R R R R R R R R R R R 00 0 R 0 R 0 R 0 R 0 R R 0 0 F I0 L0 L0 L0 L0 L0 L0 TH R0 R0 R0 R0 R R R R R R0 R R R R R R R0 R0 R0 R R R0 R R L R R R R R R 0 R0 R R R 0 R R R R R 0 R0 0 R R R R R R R R R X0 R R R R R R R R R R0 R R R R R R R R R R 0 R R R R R0 R R R R R R R R R R R0 R R R R R R R0 R R R R R R R R R0 R R R R 0 R R R R R0 R R R R L0 R R R R 0 0 L N L L N 0 L I 0 W W W R 0 L0 0 Q0 Q0 Q0 Q Q 0 0 Q0 I0 O I I0 0 0 N IN N IP IP P P R0 N 0 N O HK HR MI FW AUX PTT Q T P Q Q Q I Q Q Q Q Q Q A F H J K L M N P R T W X Y Z T 0 Q0 Q0 I0 I I0 I0 I PTT/TX MI N N VOL L N M HK/RX M N M VR0 LK AT I Q0 Q0 Q0 Q0 N N K AT N N TXL L PW K K LK L M RXL R Q Q R F0 F Q0 I0 QL Q0 I Q0 Q0 I0 I0 I0 N0 Q0 J-0-0 A/

21 J K L M N O P Q R 0 P OAR TK-0 omponent side view (J-0-0) TX-RX UNIT : TX-RX TION (X-00-XX)(A/, /) Ref. No. I I0 I0 I0 0L I0 J I0 I I0 H I0 0F I0 I I0 I0 I0 0 I I I I I 0 Q J Q J Q F Q Q F Q0 Q0 Q0 Q0 Q Q Q F Q Q Q F Q F Q Q0 O Address Q0 M Q0 K Q0 K Q0 J Q0 0I Q0 F Q0 F Q0 Q0 Q0 Q0 Q0 F Q0 0H Q0 H N N 0 F 0 H O 0 O 0 N 0 M 0 0I 0 0 I 0 F H Ref. No. Address N H R XF0 R R R R N0 R R R R R R R 0 R0 R R R R R R R R R 00 0 R0 0 R 0 0 R R 0 0 R 0 0 R T0 T0 0 R R R 0 0 R I0 0 K L L L L L L R R R0 R R R R L0 L0 L0 L0 L0 L0 L0 L0 L0 L L L L L L L L L L0 L L L L L L L L L0 L L 0 R0 R0 R0 R0 R0 R0 R0 R W Q Q 0 R0 R R N0 R F0 Q0 ANT N TV 0 0 Q0 0 I0 N0 Q0 VR0 R0 J0 J-0-0 / L N M HK P PTT MI M TP TP Q0 Q0 L L

22 J I H F A 0 TK-0 P OAR TX-RX UNIT : TX-RX TION Foil side view (J-0-0) (X-00-XX)(A/, /) I0 P I0 P I0 0P I0 I0 K I0 I0 O I0 N I0 N I0 0O I0 O I0 N I0 M I0 M I0 L I0 N Q Q M Q N Q N Q N Q M Q0 Q N Q0 Q Q0 P Q0 P Q0 P Q0 P Q0 P Q 0P Q 0P Q0 Q0 Q0 Q0 Q0 Q0 0F Q0 Q0 J Q0 0H Q0 0K Q0 I Q0 H Q0 0L Q0 0L 0 P 00 0 J 0 J 0 I 0 I 0 P 0 Q 0 P 0 N 0 Q 0 N 0 P 0 N 0 N Ref. No. Address Ref. No. Address F M K K 0 I00 F Q00 0 H N0 R00 R0 R0 R0 R0 R0 R0 R0 R0 R0 R0 R R R R R R R R R R0 R R R R R R R R R R0 R R R R R R R R R0 0 R 0 R Q Q0 Q0 L0 I00 L I0 L L L L L L0 L L L L L L L L L L L L L0 L L R R0 R R R R R 00 R0 0 R 0 R R 0 0 R 0 R 0 R R R R R R R R R R R R R0 R R R R R R0 R R R R R 0 Q00 Q0 Q0 Q0 Q0 Q0 Q0 0 R L0 L L L L L R Q0 0 0 Q0 0 Q0 0 L N M HK P PTT MI M L N M HK/RX M N M PTT/TX MI N N VOL J-0-0 / J-0-0 A/

23 J K L M N O P Q R 0 P OAR TK-0 Foil side view (J-0-0) omponent side Foil side Layer Layer Layer Layer TX-RX UNIT : TX-RX TION (X-00-XX)(A/, /) Layer Layer 0 R00 R0 R0 R0 R0 0 R0 R0 R0 R0 R0 R0 R R R R R R R R R R0 R R R R R R R R R R R R R0 R R R R R R Q Q0 Q0 Q0 R Q0 R F L0 L0 L0 L0 L0 L0 L0 L0 L0 L0 L L L L I0 L TH I0 TH L L L L0 L P0 P0 R0 L P0 R0 L P0 R0 P0 R0 P0 P0 R0 P0 L P0 P P R P R P R P R P R0 R0 R0 R0 R0 P0 L P L P P R00 L P R0 L P R0 L P R R0 L P R0 L R0 R L R R0 R R R R R R R R R R R R R R R R0 R R R R R R R R R R 0 R0 R R R 0 R R R0 0 R L R L R R L 0 R L L R L R R0 R R R R R R R R R 0 R R X0 0 0 R R R0 0 R R R Q R0 Q R R 0 R R R 0 R R R R R 0 R R R R R0 R R R R R 0 R R 0 R I0 R R R I0 L0 L0 P0 R P P P 0 Q0 0 Q Q Q Q I0 I0 I0 I I0 0 0 I Q0 Q0 I0 I0 I0 I Q Q I0 Q0 Q0 Q0 Q0 0

24 A TK-0 F H I P OAR TX-RX UNIT : IPLAY TION (X-00-XX)(/) omponent side view (J-0-0) J 0 0 I0 Layer Layer Layer Layer Layer Layer omponent side Foil side 0 R R R R R 0 0 R TX-RX UNIT : IPLAY TION (X-00-XX)(/) Foil side view (J-0-0) R R R R0 R R R R 0 0 PWR MON A J-0-0 / 0 R0 R0 R R0 R0 R0 R R0 R Q0 I0 Q0 Layer Layer Layer Layer Layer Layer omponent side Foil side N0 N N N K PW K AT N N K LK TXL L L M RXL 0 R L0 M J-0-0 /

25 J K L M N O P Q R P OAR TK-0 TX-RX UNIT : IPLAY TION (X-00-XX)(/) omponent side view (J-0-0) H UP N N Ref. No. I Address F M J J J F I K K 0 N TX-RX UNIT : IPLAY TION (X-00-XX)(/) Foil side view (J-0-0) Q0 0 R0 Q0 Q0 R0 R 0 Q0 Q0 R0 R0 Ref. No. I0 Q0 Q0 Q0 Q0 Q0 Address 0F 0K K 0J 0J 0J 0F

26 A TK-0 HMATI IARAM TX-RX UNIT TX-RX TION X-00-XX A/ X-00-XX TX-RX UNIT(IPLAY)/ TK0ML- R00 K 0A MU RTN0U-T 00K 0 - X-00-XX T0F(N)-F 0 RTPU-T RTPU-T RTPU-T - RTPU-T RTPU-T RTPU-T RTPU-T UZW. R 0 0 L L L L L L0 L L0 L0 L0 L0 L0 L L L L L0 L R R R R R R R R R R0 R NO 0n u L-- L--0 L--0 L--0 NO n L--0 L--0 L--0 L--0 0n n 0n 0n NO 0n k 0 0 k 0 NO 0 NO 0k 0 HMA- 0n 0n L--0 L--0 L--0 L--0 n NO L-0-0 L-0-0 L-0-0 L-0-0 0n n NO NO 0n NO k NO 0 NO k NO 0 0 0k 0 X-0 (A/) /

27 F H I J TX-RX UNIT(X-00-XX) HMATI IARAM TK-0 AT0N-H -F MPF0J TU -F 0 00P R R R0 R R R R R R0 R R R R R R NO 0k k k 0 NO NO NO NO NO p NO 00p p 00p NO p 0p 0p p p 0p NO NO p p p p p p p p p 0p p p p p p p p 0p p --0 NO 0 0k k NO p 0p p p 0.0u 0p p 00p 00p p p 0p p p p p p p p p p p p 00p p p p p p p p 00p p u N X-0 (A/) /

28 TK-0 HMATI IARAM KTA-P(Y) RTN0U-T R R R R R k L0 u L0 u u K L M N O TX-RX UNIT(X-00-XX) MAJ 0 0 KIA0API L0 - KV0- KV0- KV0- KV0- TK0ML KTA-P(Y) KTA-P(Y) R u 0.u R0 R0 0k R0 00k 0 0.u R0 00k R0 0 0 p R0 k 0 0.0u R0 R Q00 K-FP 0 0.0u R0 0 R u 0 0p R R k 0k IN() V V IN(-) out R 0k R.k 0 0.0u R 00 I00 TA0F-F R 0k R I0 LMH0MM V V VIN I- R VoUT N V- R 0 0k 0.0u 0.0u R.k R0.k 0.0u R 0k Q0 R 00k R k Q0 (R)F 000p A(R)F R.k R k R R 0k k 0.0u.u R 000p R0 0k R 00k R R 0k 0 000p Q0 (R)F p p --0 NO p NO NO NO p p p p p 000p p p p p 000p 0p 0p 0p 0p --0 0p p 0.0u NO p p p p p p p 0p 00p p p 0p 0p NO NO NO NO NO X-0 (A/) /

29 RTN0U-T R R TX-RX UNIT(X-00-XX) P Q R T - 0.0u L--0 R 0 R 0 RFM0UX RFM0UX L-- HMATI IARAM TK-0 R R R R R R R R A A 0P 0P WITH 0P P L WITH R Q K 000P 000P F R L--0 L--0 L--0.P --0 L--0 KIFU-P -F 0.P 0P n L--0 TAFN -0.P.P.P.k.P.P u 0.u 0 00p R A(R)F Q0 R)F 0.0u.u R0 0k R 00k R 0k 0 000p Q0 (R)F R.k p 0p R R k R k 0k R 00 Q0 (R)F 0.0u 0.0u 00 R0 k R 0k 0.0u R k Q0 (R)F 00 H Q0 K 0 0p MAJ K F -F 000p R k Note : The components marked with a dot ( ) are of layer. X-0 (A/) /

30 A TK-0 HMATI IARAM TX-RX UNIT IPLAY TION X-00-XX / X-00-XX TX-RX UNIT MI & VOL TION X-00-XX / X-00-XX MINIM00F, UR PROTTOR AVRM00MAA 0 X-0 (/) /

31 F H I J HMATI IARAM TK-0 TX-RX UNIT(X-00-XX) -F Note : The components marked with a dot ( ) are of layer. X-0 (/) /

32 TK-0

33 J K L M N O P Q R I H F A 0 0 P OAR TK-0 TK-0 P OAR omponent side view (J-0-0) TX-RX UNIT : TX-RX TION omponent side Foil side Layer Layer Layer Layer TX-RX UNIT : TX-RX TION (X-00-XX)(A/, /) Layer Layer omponent side view (J-0-0) (X-00-XX)(A/, /) Ref. No. I I0 I0 I0 0L I0 J I0 I I0 H I0 0F I0 I I0 I0 I0 0 I I I I I 0 Q J Q J Q F Q Q F Q0 Q0 Q0 Q0 Q Q Q F Q Q Q F Q F Q Q0 O Address Q0 M Q0 K Q0 K Q0 J Q0 0I Q0 F Q0 F Q0 Q0 Q0 Q0 Q0 F Q0 0H Q0 H N N 0 F 0 H O 0 O 0 N 0 M 0 0I 0 0 I 0 F H Ref. No. Address N H R XF0 R R R R N0 R R R00 R0 R R0 R R0 R R0 R R0 R R0 R0 R0 0 R0 R0 R R R R0 R R R R R R R R R R R0 0 TH0 R 0 0 R R R 0 R 0 R R 0 0 R R R R R T0 R R T0 R R R 0 R 0 R 0 R 0 R 0 R 0 R 0 R 0 R 0 0 R F I0 0 L0 L0 L0 L0 L0 L0 TH R0 R0 R0 R0 R K R R R R R0 R R R R R R R0 R0 R0 R R R0 R R L L L L L L R R R R L0 R R R0 R R R 0 R R R R R 0 R0 0 R R R R R R R R R X0 R R R R R R R R R R R0 R R R R R R0 R R R R R R R R R R 0 R R R R R0 R R R R R R R R R R R0 R R R R R R R0 R R R R R R R R R0 R R R R 0 R R R R R0 R R L0 R L0 R L0 R L0 L0 R L0 R L0 R L0 0 L0 L L L L L L L L L 0 L0 L L L L N L L L N L L 0 L0 L L L I 0 R0 R0 R0 R0 R0 R0 R0 0 W W W R 0 L0 0 Q0 Q0 Q0 Q Q 0 0 Q0 I0 O I I0 0 0 N IN N IP IP P P R0 N 0 N O HK HR MI FW AUX PTT Q T P Q Q Q I Q Q Q Q Q Q A F H J K L M N P R T W X Y Z T 0 Q0 Q0 I0 I I0 I0 I PTT/TX MI N N VOL L N M HK/RX M N M VR0 LK AT I Q0 Q0 Q0 Q0 N N K AT N N TXL L PW K K LK L M RXL R W Q Q 0 R0 R R N0 R F0 F Q0 I0 QL Q0 I Q0 Q0 I0 I0 I0 N0 Q0 ANT N TV 0 0 Q0 0 I0 N0 Q0 VR0 R0 J0 J-0-0 / L N M HK P PTT MI M J-0-0 A/ TP TP Q0 Q0 L L

34 J K L M N O P Q R I H F A 0 0 P OAR TK-0 TK-0 P OAR Foil side view (J-0-0) TX-RX UNIT : TX-RX TION omponent side Foil side Layer Layer Layer Layer TX-RX UNIT : TX-RX TION (X-00-XX)(A/, /) Layer Layer Foil side view (J-0-0) (X-00-XX)(A/, /) I0 P I0 P I0 0P I0 I0 K I0 I0 O I0 N I0 N I0 0O I0 O I0 N I0 M I0 M I0 L I0 N Q Q M Q N Q N Q N Q M Q0 Q N Q0 Q Q0 P Q0 P Q0 P Q0 P Q0 P Q 0P Q 0P Q0 Q0 Q0 Q0 Q0 Q0 0F Q0 Q0 J Q0 0H Q0 0K Q0 I Q0 H Q0 0L Q0 0L 0 P 00 0 J 0 J 0 I 0 I 0 P 0 Q 0 P 0 N 0 Q 0 N 0 P 0 N 0 N Ref. No. Address Ref. No. Address F M K K 0 I00 F Q00 0 H N0 0 R00 R0 R0 R0 R0 R0 R0 R0 R0 R0 R00 R0 R0 R0 R0 0 R0 R0 R R0 R R0 R R0 R R0 R R R R R R0 R R R R R0 R R R R R R R R R R R R R R R0 R R R R R R R R0 R R R R R R R R R R R R R R0 00 R 0 R 0 0 R R0 R 0 R 0 R 0 R R 0 0 Q Q Q0 Q Q0 Q0 R Q0 R Q0 F L0 L0 L0 L0 L0 L0 L0 L0 I00 L0 I0 L0 L L L L I0 L L L L TH L I0 TH L0 L L L L L L L L L L0 L L L L P0 L P0 L R0 L P0 R0 L P0 R0 P0 R0 P0 P0 R0 P0 L0 L P0 P P R P R P R P R P R0 R0 R0 R0 R0 P0 L P L P L P R00 L P R0 L P R0 L P R R0 L P R0 L R0 R L R R0 R R R R R R R R R R R R R R R R0 R R R R R R R R R R 0 R R R0 R R R 0 R R R0 0 R 00 R0 0 L R 0 R L R R L R R L R 0 L R 0 R L R R R R R 0 R R0 R R R R R R R R R R R R R 0 R R X0 0 0 R0 R R R0 0 R R R R R R R R Q R0 Q R R R 0 R R R R 0 R R R R R 0 R R R R R0 R R R R R 0 R R 0 Q00 Q0 R Q0 Q0 Q0 Q0 Q0 0 I0 R R R R I0 L0 L0 0 L0 L0 0 0 L L L L R P0 R P P P Q0 0 0 Q0 0 Q0 0 Q Q Q Q I0 I0 I0 I I0 0 0 I Q0 Q0 I0 I0 I0 I Q Q I0 Q0 Q0 Q0 Q0 0 L N M HK P PTT MI M L N M HK/RX M N M PTT/TX MI N N VOL J-0-0 / J-0-0 A/

35 A TK-0 P OAR F H I J K L M N O P Q R P OAR TK-0 TX-RX UNIT : IPLAY TION (X-00-XX)(/) omponent side view (J-0-0) TX-RX UNIT : IPLAY TION (X-00-XX)(/) omponent side view (J-0-0) Layer Layer Layer Layer Layer Layer omponent side Foil side R I0 R R R R 0 0 R PWR MON A N H UP N N 0 Ref. No. I Address F M J J J F I K K 0 0 J-0-0 / TX-RX UNIT : IPLAY TION (X-00-XX)(/) Foil side view (J-0-0) TX-RX UNIT : IPLAY TION (X-00-XX)(/) Foil side view (J-0-0) Q0 0 omponent side Layer Layer Layer Layer Layer Layer Foil side N0 R0 N N N K PW K R0 AT N N K LK R TXL L L M RXL R R R R0 R R I0 R R R0 R0 R0 0 R R R0 R Q0 Q0 0 R0 R 0 Q0 Q0 R0 R0 R0 Ref. No. I0 Q0 Q0 Q0 Q0 Q0 Address 0F 0K K 0J 0J 0J 0F L0 M J-0-0 /

36 A F I H K J M L O N Q P R T TK-0 HMATI IARAM TX-RX UNIT TX-RX TION X-00-XX A/ R R R R 0 R RFM0UX R - WITH R R TK0ML- MPF0J A R 0.0u L-0- A L-- AT0N-H -F P 0P RTN0U-T R L--0 X-00-XX TX-RX UNIT(IPLAY)/ R 0 0 0P R RFM0UX 0P R R KTA-P(Y) TU R00 K - 0A MU -F WITH Q K 000P MAJ F 0 R 000P R 0 00P 0 L L0 KIA0API RTN0U-T - L--0 L--0 L--0 00K KV P 0 KIFU-P KV0- KV0- n 0.P 0 L L L0 L L0 L L L L0 NO 0n u L-- L--0 L--0 L--0 NO n L--0 HMA- 0n 0n L--0 L--0 L--0 L--0 n NO L-0-0 L0 L--0 L-0-0 L0 L L L L L0 L R R R L0 L--0 L--0 0n n 0n 0n NO 0n k 0 NO 0n NO k NO 0 NO L-0-0 L-0-0 0n n R R R R R R 0 k 0 0 NO NO NO k NO 0 0 R0 R R R 0 0k 0 00k k 0k R k 0 R R0 R R R R R R NO NO NO NO NO p NO 00p p 0p p NO p 00p NO p 0.0u 0p 0 p p 0 0 NO p p p p p 0p 0p p p 0p NO 00p 00p p p 0p p p p p p p p p p p 000p 0p 0p 0p 0p p p p p 0p p p p p p p p 0p p --0 NO NO p NO p NO p p p 000p p p NO NO NO p NO p 0p 0p NO p p p p 00p p p p p p p p 00p p u NO p p p p p p 0p 00p p 0k F 0 0p K 0.0u MAJ H Q0 K 00 0.u 00p 0 0.P k R0 0.0u 0.0u R 0k R 0p R k Q0 (R)F 00 0k R 00 Q0 (R)F k R k.k R0 0k R 00k.u 000p Q0 (R)F R R u R k R 000p 0.u -F R k Q0 (R)F.k p 0 R R k 0.0u 00k A(R)F 000p k R R R 00 k R 0.0u Q0 A(R)F Q0 R 0k R 0k.k 0k R 0.0u.k R I00 TA0F-F 0 R0 0.0u R R 0k I0 LMH0MM V V VIN I R VoUT N V- R R 0k R R 00.k IN() V V IN(-) out R 0k k R 0.0u L0 u L0 u 00k p 0 0.0u 0 R0 0 0p R0 0 k 0 R0 R0 0.0u R0 R u R0 0k 00k UZW. RTPU-T 0 0 R0 Q00 K-FP 0 0.0u 0 KTA-P(Y) KTA-P(Y) 00 0 R0 0 RTPU-T R00 R RTPU-T 0.0u 0 RTPU-T.k RTPU-T 0.u R0 RTPU-T.P.P RTPU-T.P.P 0 X-00-XX T0F(N)-F --0 TAFN L--0 TK0ML- - 0P -F KV0-

37 A F H I J TK-0 HMATI IARAM TX-RX UNIT IPLAY TION X-00-XX / Note : omponents marked with a dot ( ) are of patterun. X-00-XX -F TX-RX UNIT MI & VOL TION X-00-XX / X-00-XX MINIM00F, UR PROTTOR AVRM00MAA