0 Parts Manual JNSZ00SV READ THIS MANUAL CAREFULLY IT CONTAINS IMPORTANT SAFETY INFORMATION. MINIMUM RECOMMENDED OPERATOR AGE: FOR OFF-ROAD USE ONLY This vehicle is designed and manufactured for off-road use only. USA only: It does not confirm to federal motor vehicle safety standards, and operation on Public streets, roads, or highways is illegal
CONTENTS PARTS MANUAL.... ENGINE....TRANSSMISSION.... CHASSIS... Wearing parts.... Body....Engine... 9.Transmission... 90..Standard part... 9 PREPARATION ATTACH INSTRUCTION... 9. Remove packing... 9.Install the front suspension arm... 9.Attach front shock absorber... 9.Attach the rod end and front wheel... 9.Attach tie rod and front wheel... 9.Attach the rear suspension arm... 97. Attach driver shaft... 9 7. Attach driver shaft... 99.Attach rear shock absorber... 00 9. Attach rear wheel... 0 0.Attach rear bumper bar... 0.Attach of spotlight and aluminum roof rack... 0.Check vehicle... 0
PARTS MANUAL. ENGINE. COOLING SYSTEM 7 9 9 0 0 7 No Part number Name Quantity Q00 BOLT,HEXAGON HEAD 7-070 WATER PUMP PULLEY Q00 BOLT,HEXAGON FLANGE Q0 BOLT(MX) Q0 BOLT,HEXAGON FLANGE 7-0700 PUMP SET,WATER 7 7-070 RING, O 7-070 WATER PUMP WASHER 9 7-070 SEAL STRIP 0 Q0 BOLT 7-0709 SEAL STRIP 7-070 SEAL STRIP GB0- RING,'O' RUBBER 7-00 SEAT - THERMOSTAT OUTER 7-000 THERMOSTAT ASSY 7-000 THERMOSTAT ASSY 7 Q00 BOLT,HEXAGON FLANGE 7-00 INNER SEAT-THERMOSTAT ASSY 9 7-00 OUTER SEAT-THERMOSTAT ASSY 0 7-007 PIPE
9.CYLINDER BLOCK 9 7 0 No Part number Name Quantity 7-0000 CYLINDER BLOCK ASSY 7-0007 POSITION PIN 7-000 CRANKCASE VENTILATION PIPE 7-000 CYLINDER HEAD SEAL PLUG Q00 BOLT,HEXAGON FLANGE 7-0000 KNOCK SENSOR 7 7-000 POSITION PIN S-000 SWITCH,OIL PRESSURE 9 G0GB0 BALL 0 7-000 PLUG 7 7-000 BOLT 0 7-000 COVER-OIL CONTROL 7-00 TIE-IN-OIL FILTER 7-0007 VENT PIPE
0.CRANKSHAFT 7 9 7 9 0 0 No Part number Name Quantity 7-000 PULLEY BOLT 7-0000 TORSION SHOCK ABSORBER ASSY 7-000 CRANKSHAFT TIMING GEAR 7-0007 TOOTHED BELT BAFFLE 7-000 CRANKSHAFT FRONT OIL SEAL 7-000 BEARING,NEEDLE 7 7-000 WOODRUFF KEY 7-0000 CRANKSHAFT ASSY 9 7-000 STOPPER PLATE 0 S-00 BOLT,COVER SET 7-000 PIN - DOWEL 7-0000 REAR OIL SEAL 7-000 REAR OIL SEAL BRACKET Q00 BOLT,HEXAGON FLANGE 7-0000 FLYWHEEL ASSY 7 7-000 BOLT,LOCK-FLY WHEEL S-007 SENSOR,CRANKSHAFT POSITION 0 9 S-000CA COVER-CLUTCH 0 S-000CA DRIVEN DISK ASSY
. EXHAUST MANIFOLD (for Europe) 7 9 (for Europe) No Part number Name Quantity 7-000 GASKET-EXHAUST MANIFOLD 7-000 EXHAUST MANIFOLD Q00F STUD Q00 NUT,HEXAGON 7-000 HEAT INSULATOR Q0 BOLT,HEXAGON HEAD 7 S-00JA OXYGEN SENSOR Q00F STUD 9 S-7 BRACKET,OXYGEN SENSOR
.INTAKE SYSTEM 7 9 0 9 7 0 0 7 9 No Part number Name Quantity Q0 BOLT,HEXAGON HEAD S-900JA THROTTLE S-90JA GASKET-THROTTLE Q00 BOLT,HEXAGON FLANGE 7-000 ACCELERATOR PULLING WIRE BRACKET S-09 INTAKE TEMPERATUREAND PRESSURE SENSOR 7 Q00 BOLT,HEXAGON HEAD 7-000 UPPER INTAKE MANIFOLD 9 Q0 BOLT,HEXAGON HEAD 0 S-0JA OIL GUIDE S-00JA INJECTOR Q00F STUD Q00F STUD 7-000 GASKET-INTAKE MANIFOLD Q00F STUD 7-000 INTAKE MANIFOLD FRONT BRACKET
.INTAKE SYSTEM 7 9 0 9 7 0 0 7 9 No Part number Name Quantity 7 7-000 INTAKE MANIFOLD REAR BRACKET 7-00 BRACKET 9 Q00 BOLT,HEXAGON HEAD 0 7-0 CRANKCASE VENTILATION PIPE () H-000 OIL AND AIR SEPARATOR 7-0 CRANKCASE VENTILATION PIPE () Q0 BOLT,HEXAGON FLANGE 7-00 CRANKCASE VENTILATION PIPE () Q00 BOLT,HEXAGON FLANGE S-00DA CABLE-ACCL. 7 7-000 GASKET-INTAKE MANIFOLD 7-000 INTAKE MANIFOLD LOWER 9 7-0007 TIE-IN 0 7-0 PIPE S-09BA TUBE
.LUBRICATING DEVICE 7 9 0 No Part number Name Quantity 7-000 OIL FILTER ASSY 7-0090 OIL DIP STICK ASSY 7-0090 OIL DIP STICK PIPE ASSY 7-00 SEAL STRIP 7-00 OIL PUMP WASHER 7-000 OIL PUMP ASSY 7 Q0 BOLT Q0 BOLT(MX) 9 Q0 BOLT,HEXAGON HEAD 7 0 7-0007 OIL STRAINER WASHER Q00 STUD Q00 NUT,HEXAGON 7-0000 OIL STRAINER ASSY Q00 BOLT,HEXAGON FLANGE Q00 BOLT,HEXAGON FLANGE
7.CYLINDER HEAD 9 7 0 7 0 9 0 No Part number Name Quantity 7-0007 SPARK PLUG SLEEVE Q00 BOLT,HEXAGON HEAD 7-000 BOLT,CYLINDER HEAD 0 7-000 CYLINDER HEAD BOLT WASHER 0 S-00 SENSOR,WATER TEMP. S-0009 SENSOR,CAMSHAFT POSITION 7 Q00 BOLT,HEXAGON HEAD 7-000 GUIDE - VALVE 9 7-000 EXHAUST VALVE SEAT INSERT 0 7-000 INTAKE VALVE SEAT INSERT 7-0000AB GASKET-CYLINDER HEAD 7-000RA HANGER - FRONT ENGINE Q0 BOLT,HEXAGON FLANGE 7-0007 BLOCK COVER 7-000 CAMSHAFT OIL SEAL 7-0000 CYLINDER HEAD
7.CYLINDER HEAD 9 7 0 7 0 9 0 No Part number Name Quantity 7 7-000 CAMSHAFT BEARING CAP POSITION COVER 0 S-000 SENSOR SET,WATER TEMP. 9 7-000BA REAR HINGER 0 7-000 PLUG 7-000 PLUG 7-000 PLUG 7-000 STUD 7-0007 SLEEVE 7-000 PLUG
7. COVER-VALVE CHAMBER No Part number Name Quantity 7-00090 OILING PORT COVER ASSY Q0 SCREW 7-0007 COVER 7-0000 VALVE CHAMBER 7-000 GASKET-VALVE CHAMBER Q0 BOLT,HEXAGON HEAD
9.OIL PAN No Part number Name Quantity 7-00900 OIL PAN ASSY Q0 BOLT,HEXAGON HEAD 7 7-00907 SEAL WASHER-OIL DRAIN THREADED PLUG 7-0090 PLUG,MAGNET
9 0.VALVE MECHANISM 7 9 0 7 9 0 0 7 9 No Part number Name Quantity 7-00700 TENSIONING PULLEY ASSY Q00 BOLT,HEXAGON HEAD Q00 BOLT,HEXAGON HEAD 7-00700 TIMING GEAR COVER ASSY Q0 BOLT,HEXAGON HEAD 9 Q00 BOLT,HEXAGON HEAD 7 Q0 RING,SHIELD-SHAFT SPRING 7-000 SADDLE FLIP WASHER 9 7-000 DRIVE RING 0 7-0000 GEAR (DERIVEN) - INTAKE CAMSHAFT 7-0000 GEAR (MAIN ) - INTAKE CAMSHAFT 7-0000 GEAR (MAIN ) - INTAKE CAMSHAFT 7-0007 BOLT,HEXAGON FLANGE 7-000 SPROCKET,TIMING BELT 7-000 NUT,LOCK-CLUTCH HUB Q00 BOLT,INNER HEXGON HEAD
0 0.VALVE MECHANISM 7 9 0 7 9 0 0 7 9 No Part number Name Quantity 7 7-000 COUPLING FLANGE 7-000 EXHAUST CAMSHAFT GEAR 9 7-0000 EXHAUST CAMSHAFT GEAR 0 7-00707 ADJUSTMENT WASHER 7-0070 VALVE LIFTER 7-00709 VALVE LOCK BLOCK 7-0070 EDDY SLEEVE 7-0070BA UPPER SEAT,VALVE SPRING 7-0070 SPRING - VALVE 7-00700 SEAL,VALVE 7 7-0070 LOWER VALVE SPRING SEAT 7-0070 VALVE,EXHAUST 9 7-0070 TOOTHED TIMING BELT 0 7-0070 VALVE,INLET 7-000 PIN 7-0007 PIN
0.VALVE MECHANISM 7 9 0 7 9 0 0 7 9 No Part number Name Quantity 7-0070 UPPER SEAT,VALVE SPRING Q7B CLAMP 7-0070 LOWER COVER-TIMING GEAR 0-00 BOLT
.IGNITION DEVICE 0 7 9 No Part number Name Quantity S-700JA IGNITION COIL Q0 SCREW AND WASHER UNIT S-7000CA BRACKET-IGNITION COIL S-70700 SPARK PLUG ASSY Q00 BOLT,HEXAGON HEAD S-70700BA CORD NO.,HI.TENSION 7 S-70700BA CORD NO.,HI.TENSION S-70700BA CORD NO.,HI.TENSION 9 S-70700BA CORD NO.,HI.TENSION 0 S-7 CLIP
.PISTON AND CONNECTING ROD DEVICE No Part number Name Quantity 7-000 PISTON PIN 7-000AC PISTON 7-000 CONNECTING ROD ASSY 7-00 BEARING-CONNECTING ROD
. OTHER ACCESSORY 9 0 7 7 No Part number Name Quantity S-70CS Engine Harness S-000JA 7 ECU S-70 Shift Bracket S-00JA PCV,carbon can S-700GA Starter assembly S-7000 lower Steel cushion 7 S-000BA Single Exhaust Gasket GB/T70-000-M*.7 Hex nut M*.7 9 GB/T 9-97- Spring Washerφ 0 GB/T97. standard- Washerφ GB/T70.-000- M*.7*7* Hex socket head bolt M*.7*7* QB Bolt * Q0 Bolt *0 7-0000 Upper steel cushion S-70 locating dowel Q0 Bolt * 7 Q00 Bolt *0 S-000 Electric odometer sensor assy
. OTHER ACCESSORY No Part number Name Quantity S-700BB Alternator S-70BA Alternator bracket S-00BA Rear bracket S-70 V-ribbed belt
.TRANSSMISSION.CASE&ACCESSORY No Part number Name Quantity QR-700 CASE.CLUTCH QR-70 CASE.TRANSMISSION T07-7000 SIDE COVER T07-7000 DECLUTCH BEARING T07-7000A DECLUTCH FORK T07-7000 SLEEVE.CLUTCH FORK 7 T07-7000 SEAL.CLUTCH FORK T07-7000 SLEEVE.CLUTCH FORK 9 QR-700 DOUBLE-SCREW ROD 0 GB/T79-9 BOLT AM 0 T07-7000 LOCATING PIN T07-7000 PLUG SCREW.OIL
7.CASE&ACCESSORY No Part number Name Quantity T07-7000 WASHER.PLUG SCREW.OIL T07-7900 SWITCH.BACK-UP LIGHT T07-700A DOUBLE-SCREW ROD T07-70009 STOP PLATE.BEARING 7 T07-7000 OIL-STOP PLATE GB/T79-9 AM /BOLT AMX 9 GB/T7-97 /WASHER 0 T07-7000 OIL GROOVE ASSY T07-7000A ROCKER.CLUTCH GB/T79-9 AM /BOLT AMX GB/T77-000 NUT M T07-700 BOLT.SIDE COVER QR-0 RELEASE SPRING.DECLUTCH
.COUNTERSHAFT No Part number Name Quantity T0A-700 COUNTERSHAFT QR-700 DRIVEN GEAR ASSY.FIRST GEAR QR-700 DRIVEN GEAR ASSY.SECOND GEAR QR-70 DRIVEN GEAR.THIRD GEAR QR-70 DRIVEN GEAR.FOURTH GEAR T07-700 BEARING.OUTPUT SHAFT.FRONT 7 T07-700 NEEDLE BEARING.ST GEAR&ND GEAR QR-709 OUTER RING.SYNCHRONIZER.ST GEAR&ND GEAR 9 QR-700 MID RING.SYNCHRONIZER.ST GEAR&ND GEAR 0 QR-70 INNER RING.SYNCHRONIZER.ST GEAR&ND GEAR QR-700 SYNCHRONIZER.ST GEAR&ND GEAR
9.COUNTERSHAFT No Part number Name Quantity QR-70 SPRING.SYNCHRONIZER.ST GEAR&ND GEAR QR-70 GEAR-HUB.SYNCHRONIZER.ST GEAR&ND GEAR QR-70 GEAR-SLEEVE.SYNCHRONIZER.ST GEAR&ND GEAR QR-70 GUIDE BLOCK.SYNCHRONIZER.ST GEAR&ND GEAR T07-700 RETAINER.SYNCHRONIZER.ST GEAR&ND GEAR 7 T07-700 SPACER.RD GEAR&TH GEAR T07-700 REAR BEARING.OUTPUT SHAFT 9 QR-707 ADJUSTING WASHER. REAR BEARING.OUTPUT SHAFT Demand 0 T0A-700 SLEEVE.COUNTERSHAFT MQC-709 NUT.COUNTERSHAFT T0A-7000 COUNTERSHAFT ASSY
0.INPUT SHAFT ASSY No Part number Name Quantity QR-700 INPUT SHAFT T07-7000 SEAL.INPUT SHAFT T0-700 BEARING 0/YA/P QR-700 DRIVE GEAR ASSY.RD GEAR T07-700 NEEDLE BEARING.RD GEAR&TH GEAR QR-707 RING.SYNCHRONIZER.RD GEAR&TH GEAR&TH GEAR 7 QR-700 SYNCHRONIZER ASSY.RD GEAR&TH GEAR QR-70 GEAR-HUB.SYNCHRONIZER. RD GEAR&TH GEAR 9 QR-70 GEAR-SLEEVE.SYNCHRONIZER. RD GEAR&TH GEAR 0 QR-70 SPRING.SYNCHRONIZER.RD GEAR&TH GEAR&TH GEAR QR-70 GUIDE BLOCK.SYNCHRONIZER. RD GEAR&TH GEAR T07-700 RETAINER.SYNCHRONIZER. RD GEAR&TH GEAR
.INPUT SHAFT ASSY No Part number Name Quantity QR-70 WAVEFORM WASHER RING.SYNCHRONIZER QR-700 DRIVING GEAR ASSY.TH GEAR T07-700 BACK BEARING/INPUT SHAFT QR-707 ADJUSTING WASHER. BACK BEARING/INPUT SHAFT Demand 7 T0A-700 SLEEVE.INPUT SHAFT QR-7000 INPUT SHAFT ASSY 9 QR-709 NUT.SYNCHRONIZER.TH GEAR 0 QR-7070 IDLE GEAR ASSY T07-700 RETAINER.REVERSING IDLE GEAR T07-700A SHAFT.REVERSING IDLE GEAR T07-7007A BOLT.REVERSING IDLE GEAR T07-700 WAHSHER. REVERSE-GREAR SHAFT
.SHIFT FORK& SHIFT- FORK SHAFT No Part number Name Quantity QR-70 SHIFT FORK.ST GEAR&ND GEAR T07-700A SHIFT FORK.RD GEAR&TH GEAR GB/T0-00 STELL BALL 7.97 T07-700A SHIFT FORK.TH GEAR T07-700A SHIFT FORK.RD GEAR&TH GEAR T0A-700 A STOP BLOCK 7 QR-70 PIN.X0 QR-70 SHIFT-FORK SHAFT.ST GEAR&ND GEAR 9 T07-7007 SPRING.SHIFT SHAFT
.SHIFT FORK& SHIFT- FORK SHAFT No Part number Name Quantity 0 QR-70 SHIFT SHAFT.RD GEAR&TH GEAR QR-70 SHAFT. SHIFT FORK.TH GEAR QR-70 SHAFT. SHIFT FORK.REVERSE GEAR T07-70 SCREW PLUG.SHIFT-FORK SHAFT T07-70 WASHER. SCREW PLUG.SHIFT-FORK SHAFT QR-70 SHIFT-FORK PIN.REVERSE GEAR T07-700 SPRING.SHIFT BLOCK 7 T07-7000A SHIFT ARM ASSY GB/T9-97 WASHER 9 T07-70A BOLT.SHIFT ARM
.SHIFT CONTROL MACHANISM No Part number Name Quantity T07-7000A SHIFT-SELECT SHAFT ASSY T07-700A SHIFT-SELECTING SHAFT QR-70 SNAP RING.STOP PLATE.SHIFT INTERLOCK T07-700 RELEASE-SPRING SEAT.ST GEAR&ND GEAR T07-700 RELEASE-SPRING.ST GEAR&ND GEAR T07-700 SPRING-STOP PLATE 7 T07-7007A STOP PLATE.SHIFT INTERLOCK T07-700A SHIFT-SELECT ARM. 9 QR-70 SPRING PIN.X 0 T07-700 PIN.SHIFT-SELECT ARM. T07-70A RELEASE-SPRING.TH GEAR&REVERSE GEAR T07-70 RELEASE-SPRING SEAT.TH GEAR&REVERSE GEAR GB/T79.-000 PIN X T07-700A SPRING SEAT.REVERSE GEAR
.SHIFT CONTROL MACHANISM No Part number Name Quantity T07-7009A LIMITING SPRING.REVERSE GEAR QR-70A LIMITING CAM.REVERSE GEAR 7 GB/T79.-000 PIN X QR-70070 GUIDE CASE ASSY. SHIFT-SELECT SHAFT 9 QR-7007 GUIDE CASE. SHIFT-SELECT SHAFT 0 T07-7007 STOP PLATE.RELEASE SPRING.TH@REVERSE GB/T79-9 BOLT AMX QR-707 OIL SEAL.SHIFT-SELECT SHAFT T07-700 ANTI-DUST COVER. SHIFT-SELECT SHAFT T07-7007 LIMITING BOLT.REVERSE GEAR QR-709 WASHER.LIMITING BOLT.REVERSE GEAR GB/T9-000 PIN B X 7 GB/T79-9 BOLT AM X T07-700A LIMITING BOLT.SHIFT
.SHIFT CONTROL MACHANISM No Part number Name Quantity 9 QR-709 WASHER.STOP SCREW.REVERSE GEAR 0 T07-700 SUPPORT ASSY.SHIFT ARM GB/T79-9 BOLT AM X0 T07-7007 ANTI-DUST WASHER.SHIFT ARM T07-700 SHIFT ARM.COMP T07-700 SMALL WASHER.SHIFT ARM T07-700 BIG WASHER.SHIFT ARM GB/T70-000 NUT M 7 T07-700 ANTI-DUST COVER.SHIFT-SELECT SHAFT T07-700 PUSHING BLOCK.SHIFT 9 T07-700 SHIFT ARM COMP 0 GB/T79.-000 PIN X QR-70 LIFTING HOOK
7.DRIVEN GEAR ASSY.SPEED REDUCER No Part number Name Quantity T0A-7000 DRIVEN GEAR ASSY.SPEED REDUCER T07-700 FRONT BEARING.DIFFERENTIAL QR-700 DRIVING GEAR.ODOMETER T0A-700 FRONT BEARING.OUTPUT SHAFT T0A-700 OUTPUT SHAFT T0A-700 CONNECTING DISC 7 T0A-700 DRIVEN GEAR.SPEED REDUCER T0A-700 REAR BEARING.OUTPUT SHAFT 9 T07-700 REAR BEARING.DIFFERENTIAL 0 T07-7009 FLANGE BOLT MQC-00 RETAINER RING T07-70090 RIGHT SEAL ASSY.DIFFERENTIAL T07-7000 LEFT SEAL ASSY.DIFFERENTIAL QR-700 ADJUSTING WASHER. RIGHT SEAL ASSY.DIFFERENTIAL Demand
. CHASSIS Frame No. Code name Description SV00.0.00.00.00 Frame component Q'ty
9 Engine mount assy 7 0 9 No. P/N ENGLISH Q'ty SV00.0.0.0.00 front engine mount 9-WΦ0 washer? 0( *0*) 9-SWΦ0 spring washer? 0 77-M0*.*0 bolt-washer M0*.*0 0 D0.0.0.00.0 engine rubber bumper 7 77.-M0X. nut-washer M0x. 7 7 SV00.0.0.0.00 engine(7) SV00.0.0.0.00 left engine mount 9 SV00.0.0.0.00 rear engine mount 0 9-WΦ washer? 9-SWΦ spring washer? 77-M*0 bolt-washer M*0 77-M0*.*0 bolt-washer M0*.*0 SV00.0.0.0.00 Clutch action arm D0.0.0.00.0A small engine rubber bumper
0 Gear-shift mechanism 0 7 9 0 9 9 0 No. Code name Description 77-M* SV00.0.0.00.0A M* bolt plastic cover S0.0.0.0.00 shifter control assembly S0.0.0.0.0 rubber shifter indication S0.0.0.0.0 rubber shifter cover S0.0.0.0.0 control framework 7 SV00.0.0.0.0 orientation metal sheet 70-M M nut(m=.) 9 -WΦ washer? (?.*? *.) 0 9-PΦ* cotter pin? * SV00.0.0.0.00 SV00.0.0.0.00 shifter soft shaft shifter soft shaft 77-MX Mx bolt Q'ty
9 0 Steering assy 9 0 7 7 0 7 7 9 0 9 7 9 0 0 No. 7 9 0 7 Code name Description Q'ty 70-M* bolt M* DI0.0.0.00.0 plastic cover DI0.0.0.00.0 rubber cover DI0.0.00.00.0 rubber block -M*0 M*0 screw DI0.0.0.00.0 steering wheel 77.-M M self-locking nut DI0.0.0.00.00 steering wheel subassembly 9.-M*0 bolt M*0 7.-Φ? spring shim N0.0.00..00 integrated ignition switch D00.0.0.0.0 steering wheel shaft 9.-CΦ circlip?, internal 7-B90 90 bearing D00.0.0.0.0 steering column housing 7-B0 0 bearing 9.-CΦ circlip?, internal
9 0 Steering assy 9 0 7 7 0 7 7 9 0 9 7 9 0 0 No. 9 0 7 9 0 Code name Description Q'ty 9.-CΦ?, external circlip D00.0.0.0.00 steering column assy 77.-M0*. M0*. nut 77-M0*.* M0*.* bolt 9-WΦ? washer(.**) 9-Φ? spring shim 7-M* M* bolt D00.0.0.0.00 steering universal rod D00.0.0.0.0 steering gear shaft 77-M*0 M*0 bolt D00.0.0.0.0 bearing cover D00.0.0.0.0 gear rack D00.0.0.00.0 rod end bearingposalh 7.-M*.7 jam nut M*.7LH D00.0.0.0.0 capping plate 7-M* socket head screw M* 9 7.-M*.7 jam nut M*.7
9 0 Steering assy 9 0 7 7 0 7 7 9 0 9 7 9 0 0 No. 7 9 0 7 9 0 Code name D00.0.0.00.0 D00.0.0.00.0 D00.0.0.00.0 7-M*.*0 D00.0.0.0.00 77-M*.*0 77.-MX. D00.0.0.0.07 77.-M0*. D00.0.0.0.0 D00.0.0.0.0 77-M0*.*0 77-M0*.*7 D00.0.0.0.0 D00.0.0.0.0 D00.0.0.0.09 D00.0.0.0.00 Description Q'ty spacer sleeve rod end bearingposa baffle plate M*.*0 bolt steering cross rod M*.*0 bolt Mx. nut dust guard plate M0*. nut bracket socket bolt M0*.*0 bolt M0*.*7 adding oil screw oiliness bearing c7** ball bearing 0** steering gear box
Throttle and park assy 9 0 7 7 7 7 9 9 0 7 0 9 7 0 9 7 No. 7 9 0 Code name Description Q'ty SV00.07.0.0.0 disc brake with floating caliper,front SV00.07.0.0.0 disc brake with floating caliper,rear D0.07.0.0.0 hydraulic threeway valve SV00.07.0.0.0 hydraulic brake hose D0.07.0.0.0 hydraulic master cylinder SV00.07.0.0.0 hydraulic brake pads SV00.07.0.0.00 four caliper hydraulic brake assy D0.07.0.00.0 pushing bar 7.-M M nut D0.07.0.00.0 push rod holder 9-P.*0 cotter pin.*0 9-WΦ0? 0 washer(? 0.*? *?.) SV00.07.0.0.00 clutch pedal D0.07.0.00.0 pedal rubber cover SV00.07.0.0.00 cable, clutch
Throttle and park assy 9 0 7 7 7 7 9 9 0 7 0 9 7 0 9 7 No. 7 9 0 7 9 0 Code name Description Q'ty 70.-M* M* socket head bolt 70-M M nut(m=.) D0.0.00 spring D0.07.0.00.0? 0*0 pin roll 9-PΦ* cotter pin? * 9-WΦ? washer D00.07.0.0.00 brake bar D0.07.0.00.0? *0 pin roll D0.07.0.00.0? 0*0 pin roll D00.07.0.0.00 throttle pedal SV00.07.0.0.00 throttle cable 77.-M M nut 77-M*0 M*0 bolt D0.07.0.0.00 park assy -WΦ? washer
Throttle and park assy 7 7 9 0 9 0 7 7 9 7 0 9 7 0 9 7 No. 7 9 0 Code name Description 9-P.*0 cotter pin.*0 D0.07.0.0.0 axle * D0.07.0.00.0 parking brake connection 9-P.*0 cotter pin.*0 D0.07.0.0.00 M self-locking nut D0.07.0.00.0 bolt-washer M*0 D0.07.0.0.0 single hydraulic pump D0.07.0.0.0 single hydraulic oil cup D0.07.0.0.0 MV00.07.0.0.00 MV00.07.0.0.00 single hydraulic caliper single hydraulic park brake assy park brake cable steel bush D00.07.0.00.0 SV00.07.0.0.0 copper braking hose 77-MX flange bolt mx Q'ty
7 7 9 No. 7 0 9 0 Code name 0 0 Front susp assy Description S0.0.0.00.0 M*. wheel nut JD0000 rubber dirt-proof boot D0.0.0.0.00H(F9) left wheel(*-) 9-P cotter pin 97-MX. castle nutmx. D00.0.0.00.0 washer 7 D0.0.0.00.0 spacer sleeve D00.0.0.00.07 axle bush 9 D00.0.0.00.0 0** grease seal 0 D00.0.0.00.0 ball bearing XX D00.0.0.00.0 spacer sleeve D00.0.0.00.0A D0.0.0.00.0A front hub D0.0.0.00.0 D0.0.0.00.0 9 0 7 0 7 9 0 7 0 9 7 9 0 Q'ty knurled screw M*. brake disk M bolt 0 7 0 9
7 9 No. 7 0 9 0 Code name 0 0 9 0 Front susp assy 7 0 7 Description SV00.07.0.0.0 brake calliper 7 D00.0.0.00.0 0** ball bearing D00.0.0.00.09 0xx7 grease seal 9 7-M** M** bolt 0 D00.0.0.00.0 bushing D00.0.0.0.00 upper suspension arm,left D00.0.0.00.0 radial bearing 9.-C circlip D00.0.0.00.0 bushing.-m* M* nut 77-M*0 M*0 bolt 7 D00.0.0.00.0A front axle left wheel D00.0.0.0.00 lower suspension arm,left 9 7-M*.*90 M*.*90 bolt 0 D00.0.0.00.0 front spacer shock sleeve 9 0 7 0 9 7 0 9 0 7 0 Q'ty 9
9 7 9 No. 7 0 9 0 Code name 0 0 9 0 Front susp assy 7 Description SV00.0.0.0.00 front shock absorber.-m*. M*. nut 7-M** M** bolt D00.0.0.00.0 control arm spacer sleeve D00.0.0.00.0 control arm rod end bearing 7.-M* jam nut M* 7 7-M*.*0 M*.*0 bolt 7-M**9 bolt M**9 9 D0.0.0.0.00H(F9) right wheel(*-) 0 D00.0.0.0.00 upper suspension arm,right D00.0.0.00.0A front axle right wheel D00.0.0.0.00 lower suspension arm,right S0.0.0.0.0 front rim * D0.0.0.0.0H front tire *-,R D0.0.0.0.0H front tire *-,L 0 7 9 0 7 0 9 7 0 9 0 7 0 Q'ty 9
70 Fuel tank and gasoline pump 9 0 0 9 7 0 9 7 7 9 0 7 No. Code name Description Q'ty D0.0.0.00.0 fuel filter clip D00.0.0.0.00 fuel pump D00.0.0.00.0 hoop (-) SV00.0.0.00.0 D0.0.0.00.0 fuel pipe( φxφx7) fuel filter D0.0.0.00.0 hoop (0-) 0 7 SV00.0.0.00.0 fuel pipe( φxφx0) D00.0.0.00.0 connector (7.9),fuel pipe 9 -M* M* cross groove head screw 0 -M*0 M*0 cross groove head screw 9-WΦ washer Ф 9-SWΦ spring washer Ф -M hex nut M SV00.0.0.0.00 fuel level meter SV00.0.0.00.0 fuel pipe(φxφx0)
7 Fuel tank and gasoline pump 9 0 0 9 7 0 9 7 7 9 0 7 No. Code name Description D00.0.0.0.00 fuel press adjuster 7 SV00.0.0.00.09 fuel pipe (φxφx0) SV00.0.0.00.0 fuel pipe (φxφx0) 9 SV00.0.0.00.0 fuel press adjuster bracket 0 7-MX0 bolt MX0 9-SWΦ spring washer Ф 9-WΦ washer Ф SV00.0.0.0.00 fuel tank assy D00.0.0.0.0 rubber washer D00.0.0.0.0 fuel tank cap with key SV00.0.0.0.0 bare fuel tank 7 D0.0.0.0.00A carbon can SV00.0.0.00. fuel pipe (φxφx0) 9 S-00JA Pressure Control Valve (PCV) 0 SV00.0.0.00. fuel pipe (φxφx0) SV00.0.0.00.07 fuel pipe (? X? ) Q'ty
7 Fuel tank and gasoline pump 9 0 0 9 7 0 9 7 7 9 0 7 No. Code name Description Q'ty 77.-M washer nut M D0.0.0.00.0 carbon can bracket 77-M* bolt-washer M* D0.0.0.00.0 carbon can plate MV00.0.0.00.0 oil pressure sensor 7 SV00.0.07.00.0 connecting pipe N0.0.0.0.00 air cleaner jacket 9 D00.0.0.0.00 air cleaner 0 N0.0.0.00.0 hoop(-) SV00.0.0.00.0 air cleaner rubber sleeve 70.-M*0 M*0 socket head screw 97.-WΦ washer φ( φ*φ*.) D00.0.0.0.00 rear bumper bar D00.0.0.0.00 fuel tank strap 77.-M0*. nut-washer M0*.
7 Spot lights and radiator assy 7 7 9 0 7 the frame in out 9 connect to radiator "out" connect to radiator cap 7 connect to engine connect to air outlet connect to thermostat outlet connect to radiator "in" 9 0 0 connect to inlet of engine connect to thermostat outlet No. Code name Description Q'ty 77-M*0 bolt-washer M*0 77.-M self-locking nut M D00.0.0.00.0 aluminium radiator bracket D00.0.0.0.00 aluminium radiator D00.0.0.0.00 temperature detect switch(tds) D00.0.0.0.00 radiator fan 7 77-M*0 bolt-washer M*0 D0.0.0.00.0 hoop(-),water tube 9 D0.0.0.00.0 water outlet hose, engine 0 D0.0.0.00.0 water inlet hose, engine D00.0.0.00.0 underlying board D00.0.0.0.00 reserve tank D00.0.0.00.0 cap of reserve tank D00.0.0.00.0 airproof washer of reserve tank
7 Spot lights and radiator assy 7 7 9 0 7 the frame in out 9 connect to radiator "out" connect to radiator cap 7 connect to engine connect to air outlet connect to thermostat outlet connect to radiator "in" No. 7 9 0 7 9 0 0 connect to inlet of engine connect to thermostat outlet Code name Description Q'ty D0.0.0.00.0 hoop(0-) 7 D00900 radiator connecting tube D00.0.0.0.00 oil separator 77-M* bolt-washer M* D0.0.07.00.0 cover, oil separator D0.0.07.00.0 air filter, oil separator SV00.0.07.00.0 hoop(-) D00.0.0.00.00 spotlight SV00.99.99.0.00 mount of spotlight 77-M0*0 bolt-washer M0*0 77.-M0 self-locking nut M0 77-M* bolt-washer M* D00.0.0.00.07 spacer SV00.0.0.0.00 aluminium roof rack
7 Spot lights and radiator assy 7 7 9 0 7 the frame in out 9 connect to radiator "out" connect to radiator cap 7 connect to engine connect to air outlet connect to radiator thermostat connect to radiator "in" 0 0 connect to inlet of engine 9 connect to radiator thermostat No. 9 0 7 Code name Description Q'ty SV00.0.0.00.0 small cycle hose SV00.0.0.00.0 steel -way.small cycle D00900 hose φ*φ.overflow tank SV00.0.0.0.00 steel -way.air outlet SV00.0.0.00.0- water inlet hose, engine SV00.0.0.00.0- water outlet hose, engine SV00.0.07.00.0 hoop(-) D00.0.0.00.0 loop M0 D00.0.0.0.0 oil separator tank D00.0.0.00.0 reserve tank
7 Electrical appliance 7 9 7 0 0 9 No. Code name Description Q'ty D00.0..00.00 headlight D00.0..00.0 D0.0.00.0.00 headlight bulb front blinker D0.0.00..00 front blinker D0.0.00.09.00 horn D00.0.0.00.00 spot light 7 D00.0.0.00.0 spot light bulb(0w) JD0000 washer 9 DS0.0.00.00.0 horn button 0 D00.0.0.00.00 four switch assy MV00.0.0.00.00 speedometer D00.0.0.00.00 tachometer
77 Electrical appliance 7 9 7 0 0 9 No. Code name Description Q'ty MV00.0.0.00.00 coolant temperature indicator D00.0.09.00.00 voltmeter D00.0.0.00.00 fuel level gauge D00.0.07.00.00 oil pressure gauge 7 D00.0.0.00.00 battery (AH) D00.0.00.00. tail light assy 9 D0079A flasher apparatus 0 MV00.0.0.00.00 electrical wiring harness S-000JA- ECU MV00.0.0.00.0 fuse box MV00.0.0.00.0 relay box S-70CS engine wiring harness D0079 flasher coat D00.0.0.00.0 bracket
7 MUFFLER 7 0 9 7 9 9 0 No. Code name Description Q'ty 7-000 SV00.0.0.0.00 exhaust manifold gasket exhaust manifold S-00JA oxygen sensor SV00.0.0.0.00 seal washer 77- Mx nut-washer 7 9 SV00.0.0.0.00A S-00JA 77.-M D0.0.0.00.0 catalac convertor oxygen sensor self-locking nut M U clamp 0 D0.0.0.00.0- U clamp mount
79 MUFFLER 7 0 9 7 9 9 0 No. 7 9 0 Code name Description Q'ty D0.0.0.00.0- U clamp screw rod D0.0.0.0.00B long muffler 77-M*0 JD9000A JD9000 bolt-washer M*0 muffler rubber cover spacer 9-WΦ** washer? ** 77.-M M self-locking nut SV00.0.0.00.0 muffler bracket 77-M* 77.-M bolt-washer M* M self-locking nut 77.-M nut-washer M SV00.0.0.00.0 wire clamp
0 seat and safety belt J O Y N E J O Y N E R R J O Y N E R J O Y N E R No. Code name Description Q'ty SV00.0.0..00 SV00.0.0.0.00 D0.0.0.00. safty belt seat safty belt tube
Rear susp,left 7 9 0 9 7 7 9 7 9 0 7 0 No. Code name Description S0.0.0.00.0 wheel nut M*. D0.0.0.0.00H(F9) wheel(*-),bl 9-P*0 cotter pin *0 D0.0.0.00.0 slotted nut M*.,rear shaft D0.0.0.00.0A disk base D0.0.0.00.0A M*. bolt 7 D0.0.0.00.0 brake disk D0.0.0.00.0 M bolt,brake disk 9 9.-CΦ circlip,internal 0 D0.0.0.00.07 bearing(? 0*? 0*) 77-M*.*00* M*.*00* bolt D00.0.0.00.0 bush ring D0.0.0.00.0 bearing block 77.-M*. M*. nut 77-M*0 M*0 bolt SV00.07.0.0.00 brake caliper 7 N0.0.0.0.0 outer boot seal 00 steel cable baffle ring 9 N0.0.0.0.0 BIG band Q'ty
Rear susp,left 7 9 0 9 7 7 9 7 9 0 0 7 No. 0 7 9 0 7 9 Code name Description Q'ty N0.0.0.0.0 inner boot seal N0.0.0.0.0 SMALL band N0.0.0.0.0 end motion type inboard joint SV00.0.0.0.0 solid bar,left N0.0.0.0.07 fixed enter type outboard joint SV00.0.0.0.00 left drive shaft 7-M*.*0*0 M*.*0*0bolt D00.0.0.00.0 spacer sleeve D00.0.0.00.0 rear shock absorber.-m*. M*. nut 77-M** M** bolt D00.0.0.00.0 grease seal,? D00.0.0.00.0 powdered spacer sleeve D00.0.0.00.0 spacer sleeve 77.-M* M* nut D00.0.0.0.00A rear suspension arm,left D00.07.0.0.00 single hydraulic park brake assy 7-M*.** M*.**bolt S0.0.0.0.0 rear rim * D0.0.0.0.0H rear tire X-,L
Rear susp,right 7 9 0 0 7 0 9 7 7 7 9 9 No. 7 9 0 7 9 Code name Description Q'ty S0.0.0.00.0 wheel nut M*. D0.0.0.0.00H wheel(*-),br (F9) 9-P*0 cotter pin *0 D0.0.0.00.0 slotted nut M*.,rear shaft D0.0.0.00.0A disk base D0.0.0.00.0A M*. bolt D0.0.0.00.0 brake disk D0.0.0.00.0 M bolt,brake disk 9.-C circlip,internal D0.0.0.00.07 bearing(? 0*? 0*) 77-M*.*00* M*.*00* bolt D00.0.0.00.0 bush ring D0.0.0.00.0 bearing block 77.-M-. M-. nut 77-M*0 M*0 bolt SV00.07.0.0.00 brake caliper N0.0.0.0.0 inner boot seal N0.0.0.0.0 small band N0.0.0.0.0 outer boot seal
Rear susp,right 7 9 0 0 7 0 9 7 7 7 9 9 No. 0 7 9 0 7 Code name Description Q'ty N0.0.0.0.0 big band N0.0.0.0.07 fixed enter type outboard joint SV00.0.0.0.0 solid bar,right N0.0.0.0.0 end motion type inboard joint 00 steel cable baffle ring SV00.0.0.0.00 right drive shaft 7-M*.*0 D00.0.0.00.0 M*.*0 bolt spacer sleeve D00.0.0.00.0 rear shock absorber.-m*. M*. nut 77-M** M** bolt D00.0.0.00.0 grease seal,? D00.0.0.00.0 powdered spacer sleeve D00.0.0.00.0 spacer sleeve 77.-M* M* nut SV00.0.0.0.00A rear suspension arm,right 7-M*.** M*.**bolt S0.0.0.0.0 rear rim * D0.0.0.0.0H rear tire X-,R
Other parts 7 0 9 7 0 7 J O Y N E R J O Y N E R No. 7 0 Code name Description Q'ty SV00.0.0.00.0 canvas roof D0.0.0.00.0 plastic zip tie 0 JN00000EU side view mirror,left JN00000EU side view mirror,right SV00.0.0.00.0 front cover plate SV00.0.0.0.0 rear fin side D00.0.0.00.0 rear panel D00.0.0.0.0 TOP panel D00.0.0.00.0 cloth cover for entire kart
Other parts 7 0 9 7 0 7 J O Y N E R J O Y N E R No. Code name Description Q'ty SV00.99.99.0.00 left nerf bar SV00.99.99.0.00 right nerf bar D00.0.0.0.00 battery bracket D00.0.0.0.00 ECU plastic shield SV00.0.0.00.0 D00.0.0.00.0 ECU bracket battery cover 7 SV00.0.0.00.0 tube clip 0 SV00.0.0.00.0 engine bottom plate 9 SV00.0.0.0.00 envelopment
7 Other parts 7 0 9 7 0 7 J O Y N E R J O Y N E R No. Code name Description Q'ty 0 SV00.0.0.07.00 foam cover fender bracket.left.front fender bracket.right.front fender bracket.left.rear fender bracket.right.rear D00.0.0.00.0- shock absorber coat.front 7 D00.0.0.00.0- shock absorber coat.rear SV00.0.0.0.0 rear fin side.left
Wearing parts. Body Num English name 件号 数量 rubber washer Φ JD090000 0 radial bearing D00.0.0.00.0 bushing D00.0.0.00.0 rod end bearing,control arm D00.0.0.00.0 spacer sleeve,control arm D00.0.0.00.0 interner circlip φ (model B) GB/T9.-9-7 shocker spacer sleeve D00.0.0.00.0 hub screw M0*. D0.0.0.00.0 0 9 wheel nut M0*. D0.0.0.00.0 0 0 ball bearing ** D00.0.0.00.0 ball bearing 0** D00.0.0.00.0 oil seal 0** D00.0.0.00.0 oil seal 0xx7 D00.0.0.00.09 bearing(0*0*) D0.0.0.00.07 slotted nut M*.,rear shaft D0.0.0.00.0 internal circlip Φ (model B) GB/T9.-9-7 engine rubber bumper D0.0.0.00.0 9 rod end bearingposalh D00.0.0.00.0 0 rod end bearingposa D00.0.0.00.0 spacer sleeve D00.0.0.00.0 electric cable MV00.0.0.00.00 spotlight bulb D00.0.0.00.0 spotlight bulb D00.0.0.00.0 headlight bulb D00.0..00.0 headlight bulb D00.0..00.0 7 turning light bulb D0.0.00.0.0 tail light bulb D0.0.00.0.0 9 stoplight bulb D0.0.00.0.0 0 flasher apparatus D0.0.00.0.00 ignition switch assembly N0.0.00..00 cable SV00.07.0.0.00 brake caliper SV00.07.0.0.0 clutch cable SV00.07.0.0.00 air cleaner D00.0.0.0.00 brake pad SV00.07.0.0.0 7 brake Disc D0.0.0.00.0 fuel pump assy D00.0.0.00.0 9 inner boot seal N0.0.0.0.0 0 SMALL band N0.0.0.0.0 outer boot seal N0.0.0.0.0 big band N0.0.0.0.0
drive shaft, right SV00.0.0.0.00 drive shaft, left SV00.0.0.0.00 four switch assy D00.0.0.00.00 FUSE E0.0.00.0.0 7 FUSE E0.0.00.0.07 FUSE E0.0.00.0.0 9 FUSE E0.0.00.0.09 0 FUSE E0.0.00.0.0 FUSE7 E0.0.00.0. FUSE E0.0.00.0. FUSE9 E0.0.00.0. FUSE0 E0.0.00.0..Engine Bolt main 7-000 0 Plug 7-000 valve-inlet 7-0070 valve-exhaust 7-0070 adjustment washer 7-00707 valve lifter 7-0070 7 seal valve 7-00700 bolt,cylinder head 7-000 0 9 cylinder head bolt washer 7-000 0 0 cylinder head cover gasket 7-000 camshaft oil seal 7-000 block cover 7-0007 the first Piston ring 7-000 the second Piston ring 7-000 oil control steel-ring scraper 7-000 oil control steel-ring cushion 7-000 7 bearing-connecting rod 7-00 upper bearing-cranksaft 7-000 9 lower bearing-cranksaft 7-000 0 cranksaft front oil seal 7-000 stopper plate 7-000 rear oil seal 7-0000 pulley bolt 7-000 toothed timing belt 7-0070 intake camshaft assy 7-0000 exhaust camshaft assy 7-0000 7 valve seal 7-00700 intake manifold gasket 7-000 9 Nut Q00 0 oil piug washer 7-0007 oil pump gasket 7-00 9
90 oil pump 7-000 water pump set 7-0700 water pump washer 7-070 ring "o" 7-070 seal strip 7-070 7 seal strip 7-070 seal strip 7-0709 9 cord NO., Hi.tension S-70700CA 0 cord NO., Hi.tension S-70700CA cord NO., Hi.tension S-70700CA cord NO., Hi.tension S-70700CA spark plug S-70700 ignition coil S-700JA injector S-00JA oil filter 7-000 7 alternator S-700B alternator adjustment arm S-70BA 9 dextral hex bolt Q090 0 V-ribbed belt S-70 Starter assembly S-700GA Electric odometer sensor S-000 Crankcase ventilation pipe() 7-00 Crankcase ventilation pipe 7-0 Crankcase ventilation pipe 7-0 Crankcase ventilation pipe 7-0.Transmission DOUBLE-SCREW ROD T07-700A shift turning rod T07-70090A SHIFT-SELECT SHAFT T07-7000A SHIFT-SELECTING SHAFT T07-700A SNAP RING.STOP PLATE.SHIFT INTERLOCK QR-70 RELEASE-SPRING SEAT.ST GEAR&ND GEAR T07-700 7 RELEASE-SPRING.ST GEAR&ND GEAR T07-700 SPRING-STOP PLATE T07-700 9 SHIFT INTERLOCK STOP PLATE T07-7007A 0 SHIFT-SELECT ARM T07-700A SHIFT-SELECT ARM PIN T07-700 SPRING PIN.X QR-70 RELEASE-SPRING.TH GEAR&REVERSE GEAR T07-70A RELEASE-SPRINGSEAT.TH GEAR&REVERSE GEAR T07-70 SPRING SEAT.REVERSE GEAR T07-700A
LIMITING SPRING.REVERSE GEAR T07-7009A 7 LIMITING CAM.REVERSE GEAR QR-70A FRONT BEARING.OUTPUT SHAFT T07-700 9 REAR BEARING.OUTPUT SHAFT T07-700 0 FRONT BEARING.DIFFERENTIAL T07-700 ODOMETER DRIVING GEAR QR-700 REAR BEARING.DIFFERENTIAL T07-700 LOCATING PIN T07-7000 INPUT SHAFT SEAL T07-7000 RIGHT SEAL.DIFFERENTIAL T07-70090 SEAL.CLUTCH FORK T07-7000 7 LEFT SEAL.DIFFERENTIAL T07-7000 BEARING 0/YA/P T0-700 9 DECLUTCH BEARING T07-7000 0 BACK-UP LIGHT SWITCH T07-7900..Standard part self-locking nut M GB/T77.-000 0 self-locking nut M GB/T77.-000 0 nut M0*. GB/T-000 0 nut M0*. GB/T-000 cotter pin.*0 GB/T9-000 cotter pin *0 GB/T9-000 7 Bolt M*.*90 GB/T7-000 Bolt M*.*0 GB/T7-000 9 Bolt M*.*0 GB/T7-000 0 Bolt M*.* GB/T7-000 Nut M*. GB/T.-000 Bolt M** GB/T7-000 Bolt M**9 GB/T7-000 Bolt M** GB/T7-000 Nut M* GB/T.-000 bolt-washer M0*.*0 GB/T77-9 0 9 spring washer 0 GB/T9-97 0 9
PREPARATION ATTACH INSTRUCTION. Remove packing 9
9.Install the front suspension arm D00.0.0.0.00 FL lower suspension arm D00.0.0.0.00 FL upper suspension arm D00.0.0.0.00 FR lower suspension arm D00.0.0.0.00 FR upper suspension arm No. Description Q'ty
9.Attach front shock absorber D00.0.0.0.00 front shocker absorber 7-000 M*.*90 M*.*90 bolt D00.0.0.00.0 shocker spacer sleeve.-000 M*. M*. nut No. Description Q'ty
9.Attach the rod end and front wheel Attach tie rod end and front wheel forward steering cross rod left wheel axle,front S0.0.0.00.0 wheel nut M*. D0.0.0.0.00H,FL wheel(*-) D00.0.0.00.0 rod end bearing,posalh D0.0.0.0.00H wheel(*-),fr No. Description Q'ty. Install the shaft of outer tie rod end- to left wheel axle,front.. Install bolt,spacer sleeve,then tighen nut. Note: don't adjust outer tie rod end as wheel alignment is done before packing.. Attach the wheel(*-),fl- on the hub, tighten the nuts.. Attach the wheel(*-),fr- as described above.
.Attach tie rod and front wheel 9
97.Attach the rear suspension arm 7 77.-000 M* M* nut D00.0.0.00.0 spacer sleeve D00.0.0.00.0 powdered spacer sleeve D00.0.0.00.0 77- M** grease seal,? M** bolt D00.0.0.0.00A left rear suspension arm SV00.0.0.0.00A right rear suspension arm No. Description Q'ty
9. Attach driver shaft Attach drive shaft forward 00 steel cable baffle ring SV00.0.0.0.00 right drive shaft SV00.0.0.0.00 left drive shaft No. Description Q'ty.Check the steel cable baffle ring- in the groove of the output shaft of transmission.. Insert right drive shaft- onto the output shaft of transmission.. Attach the left side as figure.
7. Attach driver shaft 99
00.Attach rear shock absorber D00.0.0.0.00 rear shock absorber.-000 M*. M*. nut D00.0.0.00.0 shocker spacer sleeve 7-000 M*.*0 M*.*0 bolt No. Description Q'ty
9. Attach rear wheel 0
0.Attach rear bumper bar 0
0.Attach of spotlight and aluminum roof rack SV00.0.0.0.00 aluminium roof rack 7 77-9 M0*.*0 bolt-washer M0*.*0 77.-000 M0*. self-locking nut M0*. D00.0.0.00.07 spacer D00.0.0.00.0 steel ring 77.-000 M0*. self-locking nut M0*. 77- M0*.*0 bolt-washer M0*.*0 SV00.99.99.0.00 mount of spotlight No. Description Q'ty
.Check vehicle 0