VHF MOBILE TRANSCEIVERS

Transcript

1 VHF MOBILE TRANSCEIVERS S-44XZ-C Feb. 009

2 INTRODUCTION This service manual describes the latest technical information for the IC-F0 IC-F0 IC-F0/H IC-F06/H IC-F08H VHF MOBILE TRANSCEIVERS at the time of publication. MODEL VERSION CHANNEL SPACING TX POWER FREQUENCY RANGE F0 [USA-0]./.0 0 W F0 [EUR-0]./0.0/.0 W 6 74 MHz F0 [EXP-0] F0H [EXP-0] 0 W F06 [RUS-0]./.0 W MHz F06H [RUS-0] 0 W F08H [CHN-0] 6 74 MHz CAUTION NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than specified. This will ruin the transceiver. DO NOT expose the transceiver to rain, snow or any liquids. DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 0 dm (00 mw) to the antenna connector. This could damage the transceiver s front-end. To upgrade quality, any electrical or mechanical parts and internal circuits are subject to change without notice or obligation. UNIT ABBREVIATIONS: F=FRONT UNIT M=MAIN UNIT Be sure to include the following four points when ordering replacement parts:. 0-digit Icom parts numbers. Component name. Equipment model name and unit name 4. Quantity required <ORDER EXAMPLE> ORDERING PARTS S.IC TA6FNG IC-F0 MAIN UNIT pieces Screw 48 screw IC-F0H Top cover 0 pieces Addresses are provided on the inside back cover for your convenience. REPAIR NOTES. Make sure that the problem is internal before disassembling the transceiver.. DO NOT open the transceiver until the transceiver is disconnected from its power source.. DO NOT force any of the variable components. Turn them slowly and smoothly. 4. DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be used for all adjustments.. DO NOT keep power ON for a long time when the transceiver is defective. 6. DO NOT transmit power into a Standard Signal Generator or a Sweep Generator. 7. ALWAYS connect a 0 db to 60 db attenuator between the transceiver and a Deviation Meter or Spectrum Analyzer when using such test equipment. 8. READ the instructions of test equipment throughly before connecting a test equipment to the transceiver. Icom, Icom Inc. and ICOM logo are registered trademarks of Icom Incorporated (Japan) in the United States, the United Kingdom, Germany, France, Spain, Russia and/or other countries.

3 TABLE OF CONTENTS SECTION SPECIFICATIONS SECTION INSIDE VIEWS SECTION DISASSEMBLY INSTRUCTION SECTION 4 OPTIONAL UNIT INSTALLATION SECTION CIRCUIT DESCRIPITON - RECEIVER CIRCUITS TRANSMITTER CIRCUITS FREQUENCY SYNTHESIZER CIRCUITS VOLTAGE DIAGRAM PORT ALLOCATIONS SECTION 6 ADJUSTMENT PROCEDURE 6- PREPARATION FREQUENCY ADJUSTMENT TRANSMIT ADJUSTMENT RECEIVE ADJUSTMENT SECTION 7 PARTS LIST SECTION 8 MECHANICAL PARTS SECTION 9 BOARD LAYOUTS SECTION SECTION SECTION 0 GENERAL WIRING BLOCK DIAGRAM VOLTAGE DIAGRAM

4 SECTION. SPECIFICATIONS GENERAL TRANSMITTER [USA], [RUS], [CHN], [EXP] [EUR] Frequency coverage 6 74 MHz [USA], [CHN], [EXP] MHz [RUS] 6 74 MHz Type of emission Wide 6K0FE (.0 khz) Middle 4K0FE (0.0 khz) Narrow K0FE (. khz) 8K0FE (. khz) Number of programable channels 8 channels (8 zones) Antenna impedance 0 Ω (nominal) Operating temperature range 0 C to +60 C ( F to +40 F) C to + C Power supply requirement (nominal).6 V DC (Negative ground). V DC (Negative ground) Current drain Stand-by 00 ma RX (approx.) Max.audio 00 ma TX at W 7.0 A at 0 W 4.0 A Dimensions [ W ver.] 0 (W) 40 (H) 7. (D) mm; ( 9 / (W) 9 /6 (H) 4 /8 (D) in) (projections not included) 0 (W) 40 (H) 67. (D) mm; [0 W ver.] ( 9 / (W) 9 /6 (H) 6 9 / (D) in) Weight [ W ver.] 0.8 kg ( /4 Ib) 0.8 kg [0 W ver.]. kg ( 7 /6 Ib) Transmit output power [ W ver.] W (High), 0 W (Low),. W (Low) [0 W ver.] 0 W (High), W (Low),.0 W (Low) Modulation Variable reactance frequency modulation Max. permissible deviation Wide ±.0 khz Middle ±4.0 khz Narrow ±. khz Frequency error ±. ppm ±. khz Spurious emission 70 db typ. 0. μw ( GHz),.0 μw (> GHz) Adjacent channel power Wide 70 db min. Middle 70 db min. Narrow 60 db min. Audio frequency response + db to db of 6 db/octave (from Hz) Audio harmonic distortion % typ. (with khz AF 40% deviation) FM hum and noise Wide More than 40 db (46 db typ.) (without CCITT filter) Narrow More than 4 db (40 db typ.) Residual modulation Wide More than 4 db ( db typ.) (with CCITT filter) Middle More than 4 db ( db typ.) Narrow More than 40 db (0 db typ.) Limiting charact of modulation 70 00% of max. deviation Microphone impedance 600 Ω -

5 RECEIVER Receive system Intermediate frequencies [USA], [RUS], [CHN], [EXP] Double-conversion superheterodyne st IF; 46. MHz, nd IF; 40 khz Sensitivity 0. μv typ. at db SINAD 4 dbμv (EMF) typ. at 0 db SINAD [EUR] Squelch sensitivity (at threshold) 0. μv typ. 4 dbμv (EMF) typ. Adjacent channel selectivity Wide More than 70 db (7 db typ.) Other than [RUS] 8 db typ. [RUS] Middle More than 70 db (7 db typ.) Narrow More than 60 db (6 db typ.) Spurious response 70 db min. Intermodulation More than 70 db (7 db typ.) More than 6 db (67 db typ.) FM hum and noise Wide More than 40 db (4 db typ.) (without CCITT filter) Narrow More than 4 db (40 db typ.) Residual modulation Wide More than 4 db ( db typ.) (with CCITT filter) Middle More than 4 db ( db typ.) Narrow More than 40 db (0 db typ.) Audio output power 4.0 W typ. at % distortion with a 4 Ω load Audio output impedance 4 Ω -

6 SECTION. INSIDE VIEWS FRONT UNIT (TOP VIEW) RESET IC (IC) EEPROM (IC) CLOCK FREQUENCY SHIFT DIODE (D6) CPU (IC) LCD DRIVER (IC6) BACKLIGHT DRIVER (Q) DIMMER CONTROLLER (Q) TONE FILTER ITCH (Q) BACKLIGHT CONTROLLER (Q) TONE (IC) -

7 MAIN-A UNIT (TOP VIEW) +8 REGULATOR (IC9) POWER ITCH (Q) POWER ITCH (Q4) R8 REGULATOR (Q0) CPU LINE REGULATOR (IC0) RIPPLE FILTER (Q7) VCO ITCH (Q) LOCK VOLATGE BUFFER (Q8) PLL IC (IC4) ST IF FILTER (FI) APC AMP (IC) WIDE/NARROW ND IF FILTER ITCH (Q40) IF IC (IC) WIDE/NARROW PHASE SHIFTER ITCH (Q) (Q9) -

8 MAIN-A UNIT (BOTTOM VIEW) + REGULATOR (Q7,Q8) T8 REGULATOR (Q) AF POWER AMP (IC8) AF MUTE ITCH (Q, Q6) Ext. MODULATION LINE ITCH (Q) VCO REFERENCE OSCILLATOR MODULATION AMP (IC9) REFERENCE FREQUENCY OSCILLATOR (X) D/A CONVERTER (IC0) DRIVE AMP (Q9) ST MIXER (Q) EXPANDER (IC7) D/A CONVERTER (IC8) ANALOG ITCH (IC4) ND IF FILTER (FI) ND IF FILTER (FI6) RF AMP (Q9) AF PRE-AMP (IC) AF/TONE FILTER (IC6) -

9 SECTION. DISASSEMBLY INSTRUCTION ) Unscrew 4 screws from the top cover, and remove the top cover. ) Disconnect the fl at cable and speaker cable. ) Unscrew screws from the both sides, and remove the front panel in the direction of the arrow. TOP COVER 6) Unsolder total of 9 points; points at the antenna connector, 6 points at the PA module. UNSOLDER Solder remover FLAT CABLE MAIN UNIT FRONT PANEL SPEAKER CABLE 7) Take off the MAIN UNIT from the CHASSIS. MAIN UNIT ) Unscrew 9 screws from the MAIN UNIT. MAIN UNIT -

10 SECTION 4 OPTIONAL PRODUCTS INSTALLATION Install optional UT-08 as follows; ) Turn the transceiver OFF, then disconnect the DC cable. ) Unscrew 4 screws, then remove the bottom cover. ) Install the unit as shown below. 4) Recover the bottom cover, screws and DC power cable. Install optional OPC-99 as follows; ) Turn the transceiver OFF, then disconnect the DC power cable. ) Unscrew 4 screws, then remove the bottom cover. ) Install the cable as shown below. OPC-99 Cut off the bushing as in the illustration, when you install the optional OPC-99. 4) Cut or short the patterns as below. (For AF output) Install optional UT-09R or UT-0R as follows; ) Turn the transceiver OFF, then disconnect the DC power cable. ) Unscrew 4 screws, then remove the bottom cover. ) Cut the pattern on the PCB at "MIC" and "" as showon below. 4) Install the unit as shown below. ) Recover the bottom cover, screws and DC power cable. I K ) Short the pattern as below. (For modulation input) MIC D 6) Recover the bottom cover, screws and DC power cable. NOTE: Be sure to recover the patterns when you remove the optional product. Otherwise no TX modulation or AF output is available. Solder remover 4 -

11 SECTION. CIRCUIT DESCRIPTION - RECEIVER CIRCUITS RF CIRCUITS RF signals from the antenna are passed through the (as the harmonic filter for transmitting) and antenna, then applied to the RX BPF circuit. The applied RX signals are passed through the -staged tuned BPF (D4, D8) to remove unwanted out-of-band signals, and amplified by the low-noise RF AMP (Q), then applied to the st mixer (Q) via another -staged tuned BPF (D9, 0). Total of 4 stage BPF are tuned to the RX frequency by the tuning voltage T and T from the D/A converter (IC0), to obtain required IMD characteristic. RF CIRCUITS D,,,6,48 D,D 6-74 MHz ND IF AND DEMODULATOR CIRCUITS The amplified st IF signal is mixed with the nd LO signal at the internal nd IF mixer of the IF IC (IC), to obtain the 40 khz nd IF signal. The. MHz signal generated by the reference oscillator (X) is passed through the filter AMP (Q4, L,, C0 08) to extract the 4.9 MHz rd harmonic component. The 4.9 MHz signal is then applied to pin of IF IC (IC) as the nd LO signal. The converted nd IF signal is output from pin of IF IC (IC), and filtered by the ceramic filters (FI and FI6 for Narrow mode; FI only for Wide mode) to remove unwanted out-of-band signals, then applied to the internal frequencydemodulator of IF IC (IC) from pin. The demodulator is a quadrature type which uses X as the phase shifter. From the TX AMP ANT LP F PWR DET The frequency-demodulated AF signals are output from pin 9 to AF circuits. To st IF circuits D0 BPF D9 BPF Q AGC Q RF AMP D4 BPF D8 BPF ND IF AND DEMODULATORCIRCUITS REF X.MHz Tuning voltage T Tuning voltage T X Q4 IC:TA6FN BPF 4.9MHz IF IC From st IF circuits ST IF CIRCUITS The RX signals from the BPF are mixed with the st LO signals to be converted into the 46. MHz st IF signal. D/A IC8 AK0 SQIN Q W/N NWC X D7 W/N FI6 40kHz FI CERAMIC BPF The st LO signals are generated by the RX VCO (Q4, D, D4, L6, L9, etc.), and passed through the LO (D) and attenuator, then applied to the st mixer (Q) To the AF circuits NWC CERAMIC BPF W/N Q40 D6 The converted st IF signal is filtered by the crystal filter (FI) and amplified by the st IF AMP (Q4), then applied to the IF IC (IC). ST IF CIRCUITS st LO signals (8. MHz-0. MHz) D TX/RX To IF IC Q4 IF AMP FI XTAL BPF Q 46. MHz From RF circuits st mixer -

12 AF CIRCUITS The demodulated AF signals from the IF IC (IC) are amplified and filtered by the HPF (IC6), and passed through the AF line (IC4) and (IC6). The filtered AF signals are adjusted its level (=loudness) by the D/A converter (IC8), and applied to the AF AMP (IC) via the AF line (IC4). The amplified AF signals are applied to the AF power AMP (IC8) and power-amplified to obtain AF output level. SIGNALING (DECODING) Demodulated signals from pin 9 of the IF IC (IC) are passed through the to extract tone signals contained in the demodulated signals. / tone signals are extracted by the (IC6). CTCSS/ DTCS signals are extracted by the (Q9). These extracted tone signals are applied to the CPU (FRONT UNIT: IC) for decoding. The power-amplified AF signals are applied to the internal speaker on the FRONT UNIT or output from the external speaker jack on the rear panel. RX AF CIRCUITS From the IF IC IC6 HPF RXAF D/A IC8 AK0 VRAF IC4 CD4066 ANALOG TMONI IC6 IC AF AMP AF ON AF MUTE AF POWER AMP IC8 LA44A J4 Ext. speaker jack IC6 SDEC Q,6,D9 FRONT UNIT (/ TONE signals) Q9 To CPU (FRONT UNIT: IC) Int. speaker CDEC (TCSS/DTCS signals) -

13 - TRANSMITTER CIRCUITS MIC AMPLIFIER (FRONT UNIT) Audio signals from the connected microphone are applied to the MIC AMP (IC) via the microphone connector (J). The amplifi ed MIC signals are applied to the MAIN UNIT. TX AF CIRCUITS The MIC signals from the FRONT UNIT are passed through the D/A converter (as a MIC gain controller; IC8) for level adjustment, and applied to the limiter AMP which is also rolled to the pre-emphasis circuit (IC6). CTCSS/DTCS SIGNALS ENCODING (FRONT UNIT) The CTCSS/DTCS encoding signals from the CPU (IC) CENC0 CENC are passed through the (IC) for waveform conversion, and applied to the MAIN UNIT as tone modulation signals. / TONE, DTMF ENCODING (FRONT UNIT) Encoding signal from the CPU (IC) named SENC is passed through the (IC), and applied to the MAIN UNIT as tone modulation signals. TX AF CIRCUITS To the Reference frequency oscillator BAL MCOT D/A IC8 A K0 MCGO HPF VRAF MODI IC6 Limiter Pre-empha. MIC line IC4 CD4066 SPIN MOD IC6 TX VCO Splat. MIC TONE CDTS J IC MIC MICROPHONE AMP CONNECTOR FRONT UNIT TX AMPLIFIERS The frequency-modulated signal from the TX VCO is bufferamplifi ed by two buffers (Q and Q0), and applied to the drive AMP (Q9) as the TX signal via the LO (D4). The amplifi ed TX signal is applied to the FET HPA module (IC) via the, and power-amplifi ed to obtain TX output power level. The power-amplified TX signal is passed through the antenna (D) and as a harmonic filter, then fed to the antenna. MIC MUTE ITCH The pre-emphasized MIC signals are passed through the MIC mute (IC4). While receiving, the MIC mute (IC4) cuts the MIC line off, and is controlled by MMUT signal from the expander (IC7). APC CIRCUIT A portion of TX signal rectifi ed by D, D and D on the TX line to detect TX power level. The rectified voltage is applied to the APC AMP (IC), and the APC AMP controls the gain of HPA module (IC) automatically by comparing the rectifi ed voltage and the power setting voltage "T." TX AMPLIFIERS APC CIRCUIT SPLATTER FILTER The MIC signals from the MIC mute (IC4) are applied to the splatter fi lter (IC6). The splatter filter (IC6) is also used as the AF Summing AMP for tone signals modulation (CTCSS, / TONE). From TX VCO Q8 DRIVE AMP LP F PWR AMP IC D ANT LP F IC APC AMP T D,D DET PWR D MHz MUTE TMUT MODULATION CIRCUIT MIC signals from the splatter filter (IC6) is level-adjusted (=deviation adjustment) by the D/A converter (IC8), and applied to the TX VCO (Q, D6, ) via modulation mute (IC4) as the modulation signals. RX circuits The MIC signals are also applied to the reference frequency oscillator (X) as the modulation signals via D/A converter (IC8) and REF AMP (IC9). MODULATION CIRCUITS IC9 BAL REF AMP X CR-794 REF OSC IC4 MBA0 PLL IC LOOP FIL LV Q BUFF Q0 BUFF D4,D TX/RX To TX AMPs. MHz Q,D6, D8 TX VCO FM MOD From the D/A converter From the MIC line -

14 - FREQUENCY SYNTHSIZER CIRCUITS VCOs The TX VCO which generates TX signal is composed by Q, D6, D, L, L8, etc., and the frequency modulation is carried out by applying modulation signals to D8. The RX VCO which generates st LO signals is composed by Q4, D, D4, L6, L9, etc. These two VCOs are switched by the VCO (Q, 6) using RXC signal. The output signals from each VCO are amplified by the buffer AMP (Q) and LO AMP (Q0), then applied to the TX or RX circuits. A portion of oscllated signals is applied to the PLL IC (IC4) via buffer AMP (Q). FREQUENCY SYNTHESIZER CIRCUITS PLL The applied VCO output is divided according to the serial data including divide ratio from the CPU, at the prescaler and programmable divider. In the same way, the reference frequency signal from the reference frequency signal oscillator is applied to the PLL IC and divide so that these are the same frequency. The frequency-matched signals are applied to the phase comparator and phase-compared. The resulted phase difference is detected as a phase-type signal, and leveladjusted at the charge pump then output. The output pulse type signal is passed through the loop filter to be converted into the DC voltage (=Lock Voltage). Applying the lock voltage to the variable capacitors (VD) which composes a part of the resonator of VCO, the capacitance of VDs changes corresponding to the applied lock voltage. This causes the change of resonation frequency that determines the VCO oscillating frequency to keep the VCO frequency constant. When the oscillation frequency drifts, its phase changes from that of the reference frequency, causing a lock voltage change to compensate for the drift in the VCO oscillating frequency. Q7 Q,6 RIPPLE FIL VCO RXC REF IC9 AMP X CR-794 REF.MHz Q4 IC4 MBA0 PLL IC Clock,Data,Strobe LOOP FIL T RLVA LV TLVA D D RLV AD J TLV AD J LV Q4,D,4 RX VCO Q,D6, TX VCO Q Q BUFF TXC Q0 BUFF D4,D TX/RX 6/46 MHz-740 MHz 8. MHz-0. MHz X BPF D8 X D4, FM MOD BPF 4.9MHz IF IC IC:TA6FN -4 VOLTAGE DIAGRAM Voltage from the power supply is routed to the whole of the transceiver via regulators and switches. IF IC (IC), PLL IC(IC4), etc. Q7 Q8 + REG CPU CPU Driver(Q9), APC AMP(IC), etc. T D Q Q9 T8 REG TMUT VCC IC9 +8 REG IC0 CPU REG RF AMP(Q), st IF AMP(Q4), st mixer(q), etc. R Q6 Q0 R8 REG RXC Q Q4 POWER HV Power supply cable External output(from J6) VCC W VCOs, FRONT UNIT PWON HPA module(ic) HV - 4

15 - PORT ALLOCATIONS -- CPU (FRONT UNIT; IC) Pin No. 4 8 Port Name KR KR KS0 KS4 Description Input ports for dealer-programmable keys. Output ports for dealer-programmable keys. 0 CCS Outputs chip-select signal to the attached optional unit. 9 CENC0 Output ports for CTCSS/DTCS signal. CENC Frequency response of tone filter (FRONT UNIT; DUSE IC) switching signal. Low =While transmitting. 4 IPTT PTT input from connected microphone. Low =PTT is pushed. HANG Microphone on/off hook detect. Low =The microphone is off hook. 0 PLST Outputs PLL strobe signal to the PLL IC (MAIN UNIT; IC4, pin ). 4 ULCK Input port for PLL unlock detect signal from the PLL IC (MAIN UNIT; IC4, pin 7). Low =While the PLL circuit is unlocked. 9 DSDA Outputs serial data to the D/A converter (MAIN UNIT; IC0, pin 6). 4 SENC Outputs DTMF signals to the (FRONT UNIT; IC, pin ). 44 BEEP Outputs beep sounds to the (FRONT UNIT; IC, pin 7). 4 SDEC Input port for DTMF signals. 46 CDEC Input port for CTCSS/DTCS signals. 48 BATV Input port for power supply voltage. 49 LVIN Input port for VCO lock voltage. 0 Input port for receive signal strength level signal from the IF IC (MAIN UNIT; IC, pin ). TEMP Voltage divided by thermal register (MAIN UNIT; R09) and R0. (temperature monitor) AFVI [VOL] dial (FRONT UNIT; R4) input. (divided voltage of line) 9 RES Input port for CPU reset signal from the reset IC (FRONT UNIT; IC8, pin ). Low =When the CPU is reset. 69 CSFT Outputs CPU clock shift signal to the clock frequency shift switch (FRONT UNIT; D6). 7 DAST Outputs strobe signal to the D/A converter (MAIN UNIT; IC8, pin 7). 7 IG/ DIM 7 NOIS Ignition control input. Or Dimmer control input. Input port for noise signal from the IF IC (MAIN UNIT; IC, pin ). 79 CLO Cloning data output. 80 CLI Cloning data input. 8 ESDA Outputs serial data to the EEPROM (FRONT UNIT; IC, pin ). 8 ESCL Outputs clock signal to the EEPROM (FRONT UNIT; IC, pin 6). 86 PWON Transceiver's power control. High =Power ON. 9 LSO Outputs serial data to the LCD driver (FRONT UNIT; IC6, pin 48). 9 L Outputs clock signal to the LCD driver (FRONT UNIT; IC6, pin 47). 9 LCS Outputs chip-enable signal to the LCD driver (FRONT UNIT; IC6, pin 46). 94 LINH Outputs display inhibit signal to the LCD driver (FRONT UNIT; IC6, pin 4). 9 LIGT Outputs LCD backlight control signal to the backlight LEDs (FRONT UNIT; DS 9) driver (FRONT UNIT; Q). High =While the backlight is ON. Pin No. Port Name Description 98 Outputs serial clock signal to the PLL IC (IC4, pin 9) and D/A converters (IC7, pin /IC8, pin 8/ IC0, pin 7). 99 SO Outputs serial data to the PLL IC (IC4, pin 9) and D/ A converters (IC7, pin /IC8, pin 8/IC0, pin 7). 00 KR0 Input ports for dealer-programmable keys. -- EXPANDER (MAIN UNIT; IC7) Pin No. Line Name Description EXST Strobe (load enable) input. SO Serial data input. Serial clock input. 4 RXC T, R lines and RX VCO ON/OFF control. AFON AF mute (Q) control. Low =Mute 6 NWC RX band width switching signal to the nd IF fi lter (D6, 7). Low =Narrow mode RX band width switching signal to the phase shifter (Q). Low =Wide mode 7 RMUT Outputs AF mute signal to the analog switch (IC, pins, ). Low =While the squelch is close or transmitting. External device control. HORNO Low =Pin 6 of OPC-99 (if connected) is Low. TMUT Outputs transmit mute signal to the transmit mute switch (Q46). High =Transmitting is muted. -- D/A CONVERTER (MAIN UNIT; IC8) Pin Description No., MIC signal level adjustment. 4, RX AF/MIC signal level adjustment. 6, 7 Tone signal level adjustment. Oscillation frequency control voltage to the reference 8, 9 frequency oscillator (X). 0, Modulation signal level adjustment., Beep sound loudness adjustment. 4, Squelch threshold level adjustment. --4 D/A CONVERTER (MAIN UNIT; IC0) Pin No. Line Description Name While receiving Tuning voltage to the tuned BPF (D4, 8). While transmitting TX power level setting signal to the APC AMP IC). T T Tuning voltage to the tuned BPF (D9, 0). TLVA Oscillation frequency correcting voltage to the TX VCO (Q, D6, 8,, ). 4 RLVA Oscillation frequency correcting voltage to the RX VCO (Q4, D, 4, ). -

16 SECTION 6. ADJUSTMENT PROCEDURE 6- PREPARATION M REQUIRED EQUIPMENTS EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE Cloning Software CS-F00 : Revision.0 or later JIG Cable DC Power Supply Modulation Analyzer Frequency Counter RF Power Meter Output voltage Current capacity Frequency range Measuring range Frequency range Frequency accuracy Sensitivity Measuring range Frequency range Impedance R :.6 V DC except [EUR]. V DC [EUR] : More than 0 A : DC 00 MHz : 0 to ±0 khz : 00 MHz : ± ppm or better : 00 mv or better : 0 W [ W ver.] 60 W [0 W ver.] : MHz : 0 Ω : Better than. : Attenuator External Speaker Standard Signal Generator (SSG) Oscilloscope Modifi ed OPC-U (see the illust below) Power attenuation Capacity Input impedance Capacity Frequency range Output level Frequency rang Measuring range : 40 or 0 db : 0 W [ W ver.] 60 W [0 W ver.] : 4 Ω : 0 W or more : 00 MHz : µv to mv ( 7 to 7 dbm) : DC 0 MHz : V M JIG CABLE OPC-U (USB type Cloning cable) EXT. SPEAKER ( W/4 Ω) SP + AUDIO GENERATOR ( Hz/ 00 mv) + SETTING; Frequency : khz Level : 40 mvrms Waveform : Sine wave AC MILLIVOLTMETER (0 mv to 0 V) + MIC PTT µf PTT ITCH Add a jumper wire here 6 -

17 M ADJUSTMENT FREQUENCIES Before starting adjustment, clone adjustment frequencies and settings into the transceiver as below. For except [F06] NOTE: FOR [F0], when adjust Deviation, Modulation Balance, RX SENSITIVITY and S-meter in the middle band, change the bandwidth to Middle as below. Select Middle For [F06] 6 -

18 M CONNECTION Standard signal generator 7 to 7 dbm ( V to mv) CAUTION: DO NOT transmit while SSG is connected to the antenna connector. PC Oscilloscope Modulation analyzer (DC measurable) Attenuator 40 db or 0 db RF power meter 0 W [ W ver.] 60 W [0 W ver.] DC power supply.6 V / 0 A except [EUR]. V / 0 A [EUR] Frequency counter to DC cable to the antenna connector to USB port JIG CABLE to the MIC connector AC millivoltmeter Audio generator M ADJUSTMENT UTILITY WINDOW (example) Click to open the I/O Check window ADJ. CHANNEL TX POWER MOD. BALANCE DEVIATION CTCSS\DTCS SQUELCH REF. FREQUENCY RX SENSITIVITY LOCK VOLTAGE (S and S level) 6 -

19 6- FREQUENCY ADJUSTMENT ) Select an adjustment item using cursor or [ ] / [ ] keys of the PC s keyboard. ) Set or modify the adjustment value as specified using [ ] / [ ] keys of the PC s keyboard, then push the [ENTER] key. ADJUSTMENT ADJUSTMENT CONDITION OPERatio VALUE PLL LOCK VOLTAGE -adjustment- [RX LVA] Channel Receiving [TX LVA] Channel Transmitting : - Select the item [RX LVA], then adjust the voltage (LVIN) using [ ] / [ ] keys of the PC s keyboard. : - Select the item [TX LVA], then adjust the voltage (LVIN) using [ ] / [ ] keys of the PC s keyboard.. V Other than [F06], [F06H].7 V [F06], [F06H].06 V Other than [F06], [F06H] PLL LOCK VOLTAGE -verification- REFERENCE FREQUENCY [REF] Channel Receiving Channel Transmitting Channel : - Connect an RF power meter to the antenna connector. Transmitting : - Click [Reload (F)] button, then check the LVIN item on the I/O Check window..4 V [F06], [F06H] V : -.. V Loosely couple a frequency counter to the antenna connector MHz I/O Check window Lock voltage (The values shown in the above screen are example only. Each transceiver has their own values.) 6-4

20 6- TRANSMIT ADJUSTMENT ) Select an adjustment item using cursor or [ ] / [ ] keys of the PC s keyboard. ) Set or modify the adjustment value as specified using [ ] / [ ] keys of the PC s keyboard, then push the [ENTER] key. ADJUSTMENT ADJUSTMENT CONDITION OPERatio VALUE OUTPUT POWER [Power (Hi)] Channel : -4 Transmitting [Power (L)] Channel : - Transmitting [Power (L)] Channel : -6 Transmitting MODULATION BALANCE [BAL] DEVIATION -PREPARA- TION- (NARROW) [MOD N] (WIDE) [MOD Ratio] (MIDDLE)* [MOD Ratio] CTCSS/DTCS DEVIATION [CTCSS/DTCS] *: [EUR] only Channel : -7 No audio signals applied to the JIG cable. Set a modulation analyzer as; HPF : OFF : 0 khz De-emphasis : OFF Detector : (P P)/ Transmitting. Connect an audio generator to the JIG cable and set as; Frequency :.0 khz Level : 40 mvrms Set the modulation analyzer to the same condition as MODULATION BAL- ANCE. Channel : -8 Transmitting Channel : -9 Transmitting 4 Channel : -0 Transmitting Channel : - No audio signals applied to the JIG cable. Set the Modulation Analyzer to the same condition as MODULATION BAL- ANCE. Transmitting Connect an RF power meter to the antenna connector. Connect the Modulation Analyzer with an oscilloscope to the antenna connector through an attenuator. Connect a Modulation Analyzer with an oscilloscope to the antenna connector through an attenuator. Connect a Modulation Analyzer with an oscilloscope to the antenna connector through an attenuator. W [W ver.] 0 W [0 W ver.] 0 W [W ver.] W [0 W ver.]. W [W ver.].0 W [0 W ver.] Set to square waveform ±.0 to ±. khz ±4.0 to ±4. khz ±. to ±. khz ±0.6 to ±0.7 khz 6 -

21 6-4 RECEIVE ADJUSTMENT ) Select an adjustment item using cursor or [ ] / [ ] keys of the PC s keyboard. ) Set or modify the adjustment value as specified using [ ] / [ ] keys of the PC s keyboard, then push the [ENTER] key. S-METER [] (S level) ADJUSTMENT ADJUSTMENT CONDITION LOCATION VALUE RECEIVE NOTE: When RECEIVE SENSITIVITY is re-adjusted, S-METER must be re-adjusted too. SENSITIVITY Channel : - (Automatic [BPF T] Receiving adjustment) [BPF T] Connect the SSG to the antenna connector and set as; Frequency : 6.00 MHz except [F06] : MHz [F06] : +0 dbµ ( 87 dbm) Level Modulation : khz Deviation : ±. khz except [EUR] ±.8 khz [EUR] ) Select the item [BPF T] then push the [ENTER] key. ) Select the item [BPF T] then push the [ENTER] key. NOTE: "RECEIVE SENSITIVITY" MUST be adjusted before "S-METER." When "RECEIVE SENSITIVITY" is readjusted, "S-METER" MUST be re-adjusted too. Channel : - Connect the SSG to the antenna connector and set as; Frequency : 6.00 MHz except [F06/H] : MHz [F06/H] Level : + dbµ ( 84 dbm) Modulation : khz Deviation : ±. khz except [EUR] ±.8 khz [EUR] Receiving (S level) Set the SSG as; Level : 7 dbµ ( 4 dbm) Receiving SQUELCH [SQL] Channel : -4 Connect the SSG to the antenna connector and set as; Frequency : 6.00 MHz except [F06/H] : MHz [F06/H] Level : dbµ ( 0 dbm) Modulation : khz Deviation : ±. khz except [EUR] ±.8 khz [EUR] Receiving Select the item [ S Level], then push the [ENTER] key to store the adjust value for S level. Select the item [ S Level], then push the [ENTER] key, to store the adjust value for S level. ) Once close the squelch by increasing [SQL] value, then decrease the value to open the squelch. ) Push [ENTER] key to store the value. ; The output level of the standard signal generator (SSG) is indicated as the SSG s open circuit. (Automatic adjustment) (Automatic adjustment) 6-6

22 SECTION 7. PARTS LIST [MAIN-A UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION IC S.IC TA6FNG(D,EL) T 7.8/4.7 IC 0007 S.IC TA7S0F(TE8R,F) T 60/4.9 IC 0007 IC RA0H7M- [EUR-0] 0007 IC RA0H7M- [EXP-0] IC RA60H7MA-0 [USA-0] IC RA60H7MA-0 [EXP-0] IC RA60H7MA-0 [CHN-0] IC S.IC MBA0PFV-G-BND-ERE T 77.8/9. IC IC LA44A-E IC S.REG NJM7808DLA-TE-#FZZB T./4.7 IC S.REG NJM8F0-TE-#ZZZB T.6/.4 IC S.IC CD4066BPWR B./6.4 IC 0007 S.IC TA7S0F(TE8R,F) B /6.7 IC S.IC NJM90V-TE-#ZZZB B 0.6/. IC S.IC CD4094BPWR B./9.9 IC S.IC AK0P-L B.9/.7 IC S.IC TA7S0F(TE8R,F) B 8.7/8. IC S.IC M64FP 600C B 7./6. Q S.FET SK89(TE8R,F) T.7/9.7 Q S.FET SK9(TE8L,F) B 4./8.7 Q S.FET SK4UG-TL-E B 7./8.4 Q S.TRA SC4-O(TE8R,F) T 64./. Q S.TRA DTC44EUA T06 T.6/. Q S.TRA SC7-T RF B 88./. Q S.TRA SC006-T B 9.8/.8 Q S.TRA SC006-T B 00.7/.8 Q S.TRA SC006-T B 97.4/ Q S.TRA SC46-T R B 0.4/.9 Q S.TRA SC46-T R B 00.6/.8 Q S.TRA XP4(TX) T 0./4. Q S.TRA DTC44EUA T06 T 0.6/6.6 Q S.TRA SC46-BL(TE8R,F) T 07.7/.4 Q S.FET SK880-Y(TRICOM,F) T 78/4. Q S.TRA DTC44EUA T06 T 99./.9 Q S.TRA SC46-BL(TE8R,F) [USA-0] T 60/ S.TRA SC46-BL(TE8R,F) [EXP-0] 0008 S.TRA SC46-BL(TE8R,F) [CHN-0] Q S.FET SJ06STR-E T./4.4 Q S.TRA DTC44EUA T06 T 0./44. Q S.TRA SD664 T00Q B./47.6 Q S.TRA SA77 T06 Q T 07.7/44. Q S.TRA SB T00 R B./. Q S.TRA XP60-(TX).AB B 8.7/. Q S.TRA DTC4TUA T06 B 6.4/4. Q S.TRA DTC44EUA T06 T 07.7/9.4 Q S.FET SJ44-GR (TE8R,F) B 4./. Q S.TRA DTC44EUA T06 T.6/6.6 Q S.TRA SC46-BL(TE8R,F) B 67.6/. Q S.TRA DTC6EK T46 B 8.9/7.8 Q S.TRA DTC44EUA T06 B 8.7/8. Q S.TRA DTC44EUA T06 T./ Q S.TRA XP460(TX) T./9. Q S.TRA DTA4EUA T06 T 46.6/ Q S.FET SK09 TL T./7.7 Q S.TRA DTC4EUA T06 T 6.4/. D S.DIO SS7-TL-E B.8/4. D DIO L407CDB D S.VAR HVC7BTRF-E B./8. D S.DIO L709CER (940) [USA-0] T 4.7/ S.DIO L709CER (940) [EXP-0] S.DIO L709CER (940) [CHN-0] D S.DIO SV07(TPH,F) B 4.8/46.8 D S.VAR HVC7BTRF-E B 0./8. D S.VAR HVC0BTRF-E B.8/9.9 D S.VAR HVC0BTRF-E B 6.6/9.9 D S.DIO SS7-TL-E B 8./49.9 D S.DIO SS7-TL-E B 4/8. D S.DIO MAS077G0L B 8.4/4.8 D S.DIO MAS077G0L B 8./9. D S.VAR HVC76BTRF-E B 07./. D S.VAR HVLCMKRF-E B 04./.8 D DIO DSAA D S.DIO DA TL B 4/4. D S.DIO MAS0GL B 6.7/ D S.DIO MAS780GL T 6.8/.8 D S.DIO MAS0GL B 9./0. D S.VAR HVC76BTRF-E B 0.6/. D S.VAR HVC76BTRF-E B 9.4/. D S.VAR HVC76BTRF-E B 9.9/. D S.DIO MAS0GL T 79.9/.4 D S.DIO DAP TL B 7./7. D S.DIO DAP TL B /7. D S.DIO MAS0GL B 48.9/.4 D S.DIO MAS0GL B./.4 D S.DIO SV07(TPH,F) [EUR-0] T.4/ S.DIO SV07(TPH,F) [EXP-0] D S.DIO SV07(TPH,F) [EUR-0] T.4/ S.DIO SV07(TPH,F) [EXP-0] D S.VAR HVC7BTRF-E B 99.7/. D S.VAR HVC7BTRF-E B 0/8. D S.DIO MAS077G0L B 90.6/.6 D S.DIO MAS077G0L B 9.8/.6 D S.DIO DANETL T./. D S.DIO DANETL T 48./0.4 [MAIN-A UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION D S.DIO DA TL B.7/0.8 D S.DIO DA TL T /7. D S.DIO DA TL B /8.4 D S.DIO DA TL T /9.4 D S.DIO DA TL T.7/7. D S.DIO MAS780GL T.8/9.7 FI S.MON DSF7SB 46.0 MHz(FL-) T 66.6/4.9 FI CER LTM40FW <JJE> FI S.LC NFEPTZE9L (NFM60R0T) B 97.7/8. FI S.LC NFEPTZE9L (NFM60R0T) B 97.7/6.6 FI S.LC NFEPTZE9L (NFM60R0T) [USA-0] B 97.7/ S.LC NFEPTZE9L (NFM60R0T) [EXP-0] S.LC NFEPTZE9L (NFM60R0T) [CHN-0] FI CER LTM40GW <JJE> X S.DIS JTBM40CX4 <JJE> B.4/4. X S.XTA CR-794 TTS4VSB-A6. MHz B 80.8/.8 L S.COI AS N B 9.4/6.7 L S.COI AS N B.7/6.4 L S.COI AS N B.4/8.6 L S.COI AS N T 0/. L S.COI FHW0HC R0JGT <JJE> T 9./7.9 L S.COI C0C-6NG-A B 6.7/49.7 L S.COI C0C-8NG-A B 8./9.9 L S.COI C0C-8NG-A B.6/8. L S.COI C0C-6NG-A B 49/9.8 L S.COI MLF608A R8K-T T 78.4/. L S.COI C0C-6NG-A B 8.9/40. L S.COI ELJND R8JF B 68./40.6 L S.COI AS N B 8.7/64. L S.COI ELJRF 8NJFB B 9.7/. L S.COI ELJRF 68NJFB B 99/4. L S.COI ELJRE 8NGFA B 8.9/9. L S.COI TL 6N <COMO> B 07/8.7 L S.COI C64A-88NG-A B 9.6/6. L S.COI NLVT-RJ B 04/0 L S.COI ELJNC R8K-F B 94./9.7 L S.COI C0C-6NG-A B 4.8/44.8 L S.COI ELJRF NJFB B 8.8/.8 L S.COI MLF608D R8K-T B 6.9/. L S.COI MLF608D RK-T B 6./. L S.COI ELJRE R0GFA B 7./8.4 L S.COI ELJFC 00K-F B 96.8/9.7 L S.COI TL 6N <COMO> B 07/0 L S.COI TL 7.N <COMO> B 9./9.7 L S.COI ELJRF 8NJFB B 9.8/ L S.COI ELJRE 47NGFA B 88.6/9. L S.COI ELJRF NJFB B 84./.8 L S.COI ELJRF 8NJFB B 8.4/. L S.COI NLVT-RJ T 97.4/9. L S.COI NLVT-4R7J T 0.8/4.4 L S.COI MLF608E 00K-T B 06.8/4.6 L S.COI ELJND R0J T 0/. R S.RES MCR0EZHJ 00 K (04) B 7.4/64.6 R S.RES ERJGEYJ 0 V (0K) B 8.8/4. R S.RES ERJGEJ X (K) [EUR-0] B 4./ S.RES ERJGEJ X (K) [EXP-0] S.RES ERJGEJ 68 X (68K) [USA-0] S.RES ERJGEJ 68 X (68K) [EXP-0] S.RES ERJGEJ 68 X (68K) [CHN-0] R S.RES ERJGEJ X (K) [EUR-0] B./ S.RES ERJGEJ X (K) [EXP-0] S.RES ERJGEJ 68 X (68K) [USA-0] S.RES ERJGEJ 68 X (68K) [EXP-0] S.RES ERJGEJ 68 X (68K) [CHN-0] R S.RES ERJGEYJ 0 V (0K) B 8./. R S.RES ERJYJ0U (00) B 4.7/.9 R S.RES ERJGEYJ 0 V (0K) B 8.6/8.6 R S.RES ERJGEJ X (K) [EUR-0] B 44.8/ S.RES ERJGEJ X (K) [EXP-0] S.RES ERJGEJ 68 X (68K) [USA-0] S.RES ERJGEJ 68 X (68K) [EXP-0] S.RES ERJGEJ 68 X (68K) [CHN-0] R S.RES ERJGEJ 47 X (4.7K) B.9/8.4 R S.RES ERJGEJ 0 X (00) B 9./9. R S.RES ERJGEJ 47 X (4.7K) B.9/9.7 R S.RES ERJGEJ 0 X (0K) B.9/. R S.RES ERJGEJ 74 X (70K) B 9./8.6 R S.RES ERJGEJ 7 X (70) B 9./40.7 R S.RES ERJGEJ 0 X (00) B./40. R S.RES ERJGEJ 04 X (00K) B 9./6.8 R S.RES ERJGEJ 90 X (9) B.7/8.7 R S.RES ERJGEJ 0 X (0K) B./40. R S.RES ERJGEJ 0 X (0K) B 6.7/6.7 R S.RES ERJGEJ 0 X (0K) B./4. R S.RES ERJGEJ 47 X (470) B 79/40.6 M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount 7 -

23 [MAIN-A UNIT] REF PARTS H/V DESCRIPTION M. NO. NO. LOCATION R S.RES ERJGEJ 47 X (470) B 77.9/40.6 R S.RES ERJGEJ 0 X () B 78./9. R S.RES ERJGEJ 80 X (8) B 7./40.6 R S.RES ERJGEJ 47 X (470) B 70./40.6 R S.RES ERJGEJ 0 X (00) B 6.8/40.6 R S.RES ERJGEJ-JPW T 68./40. R S.RES ERJGEJ 8 X (80) T 6./9. R S.RES ERJGEJ 04 X (00K) T 66./7.8 R S.RES ERJGEJ 0 X (00) T 67./7.8 R S.RES ERJGEJ 9 X (.9K) B 7./.7 R S.RES ERJGEJ 7 X (.7K) T 6.4/9 R S.RES ERJGEJ 04 X (00K) T 9./9. R S.RES ERJGEJ 470 X (47) B 8./. R S.RES ERJGEJ X (.K) B 60.4/4.8 R S.RES ERJGEJ-JPW T 60./7.8 R S.RES ERJGEJ X (K) T 0.4/6. R S.RES ERJGEJ 47 X (470) T./9.6 R S.RES ERJGEJ 4 X (0K) T.9/6. R S.RES ERJGEJ 4 X (0K) T./6. R S.RES ERJGEJ X (.K) T.9/4. R S.RES ERJGEJ 84 X (80K) [USA-0] T 6.8/ S.RES ERJGEJ 84 X (80K) [EXP-0] S.RES ERJGEJ 84 X (80K) [CHN-0] R S.POS PRF8BD47QBRB [USA-0] T 4/ S.POS PRF8BD47QBRB [EXP-0] S.POS PRF8BD47QBRB [CHN-0] R S.RES ERJGEJ 47 X (470) B 80.7/8 R S.RES ERJGEJ 64 X (60K) T 6./. R S.RES ERJGEJ X (K) T 8.7/. R S.RES ERJGEJ X (0) T 7.8/. R S.RES ERJGEJ 0 X (0K) B 8.8/.7 R S.RES ERJGEJ 47 X (4.7K) T 64./. R S.RES ERJGEJ 4 X (0K) T 6.8/4.9 R S.RES ERJGEJ 0 X (0K) B 8.8/4.8 R S.RES ERJGEJ 47 X (470) T 64.7/4.9 R S.RES ERJGEJ 8 X (8K) T 9.7/. R S.RES ERJGEJ 0 X (00) B 8./49. R S.RES ERJGEJ 0 X (0K) B 8.7/49. R S.RES ERJGEJ 47 X (4.7K) B 84/8 R S.RES ERJGEJ 0 X (00) B 94/6. R S.RES ERJGEJ 0 X (00) B 9.9/4.4 R S.RES ERJGEJ 0 X (00) B 97.7/. R S.RES ERJGEJ 4 X (0K) B 00.7/4. R S.RES ERJGEJ 4 X (0K) B 97.7/.6 R S.RES ERJGEJ 0 X (00) B 97.7/. R S.RES ERJGEJ X (.K) T 0.6/.6 R S.RES ERJGEJ 0 X (K) B 0./.9 R S.RES RR00P-8-D (.8K) B 98.8/. R S.RES RR00P-0-D (K) B 99.7/8. R S.RES RR00P-8-D (.8K) B 06./0.8 R S.RES RR00P-9-D (.9K) B 0/0. R S.RES RR00P-9-D (.9K) B 97.9/8. R S.RES ERJGEJ 4 X (0K) B 0./.9 R S.RES ERJGEJ 0 X (0K) T 80/. R S.RES ERJGEJ 47 X (47K) T 9.4/.9 R S.RES ERJGEJ X (K) T 9.8/ R S.RES ERJGEJ 04 X (00K) T 9.8/.9 R S.RES ERJGEJ 0 X (K) T 78.8/.4 R S.RES ERJGEJ 0 X (K) T 84./7.4 R S.RES ERJGEJ X (.K) T 8.6/7.4 R S.RES ERJGEJ X (0) T 8./8.7 R S.RES ERJGEJ X (.K) T 09./.8 R S.RES ERJGEJ 0 X (0K) T 78./. R S.RES ERJGEJ 0 X (K) T 79/. R S.RES ERJGEJ 4 X (0K) T 77.9/.4 R S.RES ERJGEJ 8 X (8K) B 8/. R S.RES ERJGEJ 84 X (80K) B 84.7/. R S.RES ERJGEJ 8 X (8K) B 8.7/0. R S.RES ERJGEJ 74 X (70K) B 8.7/. R S.RES ERJGEJ X (.K) T 0./9.6 R S.RES ERJGEJ 47 X (47K) T 9.6/9.6 R S.RES ERJGEJ X (.K) T.4/9.6 R S.RES ERJGEJ X (K) T 9./.6 R S.RES ERJGEJ 9 X (.9K) B.4/. R S.RES ERJGEJ X (K) B./.4 R S.RES ERJGEJ 84 X (80K) B 0.7/. R S.RES ERJGEJ X (K) T 9./0.7 R S.RES ERJGEJ 6 X (.6K) T 8.8/. R S.RES ERJGEJ 0 X (0K) B 6./.8 R S.RES ERJGEJ 47 X (47K) B./. R S.RES ERJGEJ 8 X (8.K) T 8./4. R S.RES ERJGEJ 04 X (00K) B 7.6/.9 R S.RES ERJGEJ 47 X (4.7K) B 8./8 R S.RES ERJGEJ 04 X (00K) B 7.6/. R S.RES ERJGEJ 47 X (470) B 7.6/9.6 R S.RES ERJGEJ 4 X (0K) B.8/9.6 R S.RES ERJGEJ 0 X (0K) B 6.7/8 R S.RES ERJGEJ 0 X (00) T 0.9/6. R S.RES ERJGEJ X (K) T 9/4. R S.RES ERJGEJ 04 X (00K) T 0.8/4. R S.RES ERJGEJ X (K) T 4.6/9.9 R S.RES ERJGEJ 74 X (70K) T 9.9/6 R S.RES ERJGEJ 68 X (68K) T.8/6. R S.RES ERJGEJ 04 X (00K) B./ R S.RES ERJGEJ 04 X (00K) B./. R S.ARR EXB0JX T 69.7/4.8 R S.RES ERJGEJ 0 X (K) T 64.8/6. R S.RES ERJGEJ 0 X (K) T 74./4. R S.RES ERJGEJ 0 X (K) T 7.9/. R S.RES ERJGEJ 0 X (K) T 7/6. R S.ARR EXB0JX T 6.8/6.7 R S.ARR EXB0JX T 6.7/6. R S.ARR EXB0JX T 6.8/6. R S.ARR EXB0JX T 7./6 [MAIN-A UNIT] REF PARTS H/V DESCRIPTION M. NO. NO. LOCATION R S.RES ERJGEJ 47 X (4.7K) B 6.6/.9 R S.RES ERJGEJ 0 X (0K) B 7/7.4 R S.RES ERJGEJ 84 X (80K) T 9.9/4. R S.RES ERJGEJ X (K) B./9.7 R S.RES ERJGEJ 4 X (0K) B./8.8 R S.RES ERJGEJ 04 X (00K) T 7./9.9 R S.RES ERJGEJ 0 X (0K) B 6.8/7.9 R S.RES ERJGEJ 6 X (60) B 6.8/7 R S.RES ERJGEJ 4 X (0K) B 8.8/7. R S.RES ERJGEJ 4 X (0K) B 9.8/7. R S.RES ERJGEJ 474 X (470K) B 4./9. R S.RES ERJGEJ X (.K) B 7.8/.7 R S.RES ERJGEJ 0 X (K) B.7/7.8 R S.RES ERJGEJ 0 X (0K) B./6 R S.RES ERJGEJ 0 X (0K) T 8.6/4. R S.RES ERJGEJ 0 X (0K) T./49. R S.RES ERJGEJ 47 X (47K) T 4.7/49 R S.RES ERJGEJ 47 X (4.7K) T 0./46.6 R S.RES MCR0EZHJ 6.8K (68) B 9.4/48.8 R S.RES MCR0EZHJ 6.8K (68) B 9.4/47 R S.RES ERJGEJ 47 X (4.7K) T 07.7/4.4 R S.RES ERJGEJ 0 X (0K) T 07.7/4. R S.THE ERTJOEP 47J T 77.4/. R S.RES RR00P-04-D (00K) T 7.4/. R S.RES ERJGEJ 470 X (47) T 8.6/0. R S.RES ERJGEJ 0 X (00) T 8./6. R S.RES ERJGEJ 0 X (0K) T 84./6. R S.RES ERJGEJ 47 X (470) B 7.4/0 R S.RES ERJGEJ X (K) T 60.9/9. R S.RES ERJGEJ 0 X (0K) B 79.4/9.4 R S.RES ERJGEJ-JPW B 84.7/. R S.RES ERJGEJ 47 X (47K) B 8/0. R S.RES ERJGEJ 0 X (K) B 6.7/0.8 R S.RES ERJGEJ 470 X (47) B 4./. R S.RES ERJGEJ-JPW B.6/. R S.RES ERJGEJ 04 X (00K) B 6.7/. R S.RES ERJGEJ 0 X (M) T./.9 R S.RES ERJGEJ 04 X (00K) B.4/. R S.RES ERJGEJ 0 X (M) B 6.7/4 R S.RES ERJGEJ 04 X (00K) T 9.4/ R S.RES ERJGEJ 0 X (K) B 7.9/. R S.RES ERJGEJ 474 X (470K) B.4/8.9 R S.RES ERJGEJ 0 X (0K) B 94/. R S.RES ERJGEJ 0 X (0K) B 8.6/8 R S.RES ERJGEJ X (.K) B 67./. R S.RES ERJGEJ 684X (680K) B 67./. R S.RES ERJGEJ 04 X (00K) T.7/8.4 R S.RES ERJGEJ 04 X (00K) B.8/.9 R S.RES ERJGEJ 04 X (00K) B 6.7/4.6 R S.RES ERJGEJ 9 X (9K) B.8/4.6 R S.RES ERJGEJ 8 X (8K) B 4.9/.9 R S.RES ERJGEJ 94 X (90K) B 4/4.6 R S.RES ERJGEJ 84 X (80K) B./4.6 R S.RES ERJGEJ X (K) T 9.7/7. R S.RES ERJGEJ X (K) T 9./9. R S.RES ERJGEJ X (K) T 7./9. R S.RES ERJGEJ 0 X (0K) T 6./.6 R S.RES ERJGEJ X (.K) T 4.9/.6 R S.RES ERJGEJ 04 X (00K) T./7.7 R S.RES ERJGEJ 47 X (47K) T.9/9. R S.RES ERJGEJ 6 X (60) T.9/0.4 R S.RES ERJGEJ 0 X (0K) T 7./0.4 R S.RES ERJGEJ 0 X (0K) T 9./0.4 R S.RES ERJGEJ 0 X (M) T.8/.4 R S.RES ERJGEJ 0 X (M) T 4.7/.4 R S.RES ERJGEJ 0 X (M) T.6/.4 R S.RES ERJGEJ 04 X (00K) B.7/8.4 R S.RES ERJGEJ 04 X (00K) B 6.8/8.4 R S.RES ERJGEJ 0 X (00) T 6.8/.8 R S.RES ERJGEJ 0 X (00) T 4.6/8. R S.RES ERJGEJ 0 X (0K) B 7./0. R S.RES ERJGEJ 68 X (680) T 66./6 R S.RES ERJGEJ 04 X (00K) T 9.8/.8 R S.RES ERAYKD 04V (00K) B 7./9.4 R S.RES RR00P-04-D (00K) B 7.9/0.4 R S.RES ERJGEJ 84 X (80K) B 74.6/8. R S.RES ERJGEJ 6 X (6K) B 76.8/40.6 R S.RES ERJGEJ 4 X (0K) B 66.7/40.6 R S.RES ERJGEJ 6 X (6K) B 66./8 R S.RES ERJGEJ 0 X (0K) B.9/9.8 R S.RES ERJGEJ 0 X (0K) B 9.4/.7 R S.RES ERJGEJ X (0) B 96./. R S.RES ERJGEJ 0 X (M) T /6.8 R S.RES ERJGEJ 04 X (00K) T.8/9. R S.RES ERJGEJ 04 X (00K) T.8/0. R S.RES ERJGEJ 0 X (K) T 0.6/6. R S.RES ERJGEJ 0 X (K) T 0.6/7.4 R S.RES ERJGEJ 0 X (0K) T 7./7.9 R S.RES ERJGEJ 474 X (470K) T./6. R S.RES ERJGEJ 04 X (00K) B 0./8.9 R S.RES ERJGEJ 0 X (0K) T 07./.6 R S.RES ERJGEJ 0 X (K) T 6.8/6. R S.RES ERJGEJ 0 X (K) B 6.7/. R S.RES ERJGEJ 0 X (K) T 4.6/8. R S.RES ERJGEJ-JPW B 04.9/0.8 R S.RES MCR0EZHJ 6.8K (68) B 9.4/4. R S.RES ERJGEJ 6 X (.6K) B.4/0.6 R S.RES ERJGEJ-JPW T 90./6.6 R S.RES ERJGEJ 80 X (8) T 89.4/6.7 R S.RES ERJGEJ 7 X (70) T 90.7/6. R S.RES ERJGEJ X (K) T 4.6/7. R S.RES ERJGEJ-JPW T 84./6.7 R S.RES ERJGEJ 7 X (70) T 90.7/64. R S.RES ERJGEJ-JPW B 98.4/6.7 M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount 7 -

24 [MAIN-A UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION R S.RES ERJGEJ 0 X (0K) B 76.9/.9 R S.RES ERJGEJ X (K) B 9.7/. R S.RES ERJGEJ X (K) B 9/. R S.RES ERJGEJ 47 X (470) B 76.9/. R S.RES ERJGEJ 474 X (470K) T 9.4/ R S.RES ERJGEJ 04 X (00K) T 0/8.7 R S.RES ERJGEJ 7 X (7K) T./ R S.RES ERJGEJ 7 X (7K) T 49.6/8.6 R S.RES ERJGEJ X (.K) T 49./.9 R S.RES ERJGEJ 8 X (8.K) T 49./ R S.RES ERJGEJ 8 X (8.K) T 46.6/0.4 R S.RES ERJGEJ-JPW T 4.9/4.8 R S.RES ERJGEJ 0 X (K) B./8.4 R S.RES ERJGEJ 0 X (K) T 4.9/7. R S.RES ERJGEJ 0 X (K) T./6.9 R S.RES ERJGEJ 04 X (00K) T /0.9 R S.RES ERJGEJ 04 X (00K) B 4.6/8.4 R S.RES ERJGEJ 04 X (00K) T./7. R S.RES ERJGEJ 04 X (00K) B.7/6. R S.RES ERJGEJ 0 X (0K) T 76./. R S.RES ERJGEJ-JPW B./.8 R S.RES ERJGEJ-JPW B.4/8.8 R S.RES ERJGEJ 9 X (9K) B 6.6/. R S.RES ERJGEJ 47 X (47K) T 7/.4 R S.RES ERJGEJ 47 X (47K) T 8./.4 R S.RES ERJGEJ 4 X (0K) T 0./.4 R S.RES ERJGEJ 4 X (0K) B 9.8/4. R S.RES ERJGEJ 4 X (0K) T 9.4/9 R S.RES ERJGEJ 04 X (00K) T.6/7.6 R S.RES ERJGEJ-JPW B 7.8/0. R S.RES ERJGEJ-JPW T.9/67.6 R S.RES ERJGEJ-JPW B.7/67.7 R S.RES ERJGEJ X (.M) B 6.7/9.6 R S.RES ERJGEJ 470 X (47) B 8./.8 R S.RES ERJGEJ X (K) B 8/.7 R S.RES ERJGEJ 47 X (4.7K) B 86.6/8. R S.RES ERJGEJ 0 X () B 8/. R S.RES ERJGEJ X (K) B 4.7/7.8 R S.RES ERJGEJ 74 X (70K) T.7/4. R S.RES ERJGEJ 8 X (8K) T.6/8. C S.CER GRMMCH80JV0L (GRM4-6 CH) B 8.4/66.6 C S.CER GRMMCH0JV0L (GRM4-6 CH) B 7.4/8.6 C S.CER C608 CH H 0RB-T B 8.8/. C S.CER C608 CH H 0RB-T B 7./8.6 C S.CER C608 CH H 0RB-T B 8./4. C S.CER GRMMCH0JV0L (GRM4-6 CH) B 7.4/6. C S.CER GRMMCH0JV0L (GRM4-6 CH) B 8/8.7 C S.CER GRMMCH0JV0L C9 (GRM4-6 CH) B 6.4/ S.CER GRMMCH80JV0L (GRM4-6 CH) T 9.4/ C S.CER ECJ0EBE0K B.8/ C S.CER ECJ0EBE0K B 0/49. C S.CER ECJ0EBE0K T 9.4/ C S.CER ECJ0ECH470J B 49./.4 C S.CER GRMBRJ0KY0L (GHM00 R) B /7 C S.CER ECJ0ECH00J B 4./. C S.CER ECJ0ECH080C B 4./48. C S.CER ECJ0ECH060C B./44.8 C S.CER ECJ0EBE0K B 7/46. C S.CER ECJ0ECH0J B 0./40. C S.CER ECJ0ECHRB B.9/7. C S.CER ECJ0ECH00B T 70/.4 C S.CER ECJ0ECH0J B./40. C S.CER ECJ0ECH0J B./40. C S.CER ECJ0EBE0K B.9/6. C S.CER ECJ0EBE0K B.6/. C S.CER ECJ0ECH00B B 7.7/8. C S.CER ECJ0ECH00C B 9./7.7 C S.CER ECJ0EBA04K T 7./6. C S.CER ECJ0EBE0K B 4./40.7 C S.CER ECJ0EBA04K B 8.6/40.7 C S.CER ECJ0EBE0K B 7.7/40.7 C S.CER ECJ0EB0J0K B 48./4.8 C S.CER ECJ0EBE0K B./4. C S.CER ECJ0EBE0K B 49./4.8 C S.CER ECJ0EBE0K B 9./.9 C S.CER ECJ0EBE0K B.8/4 C S.CER ECJ0ECH040B B./9. C S.CER ECJ0ECH80J B 66./9. C S.CER ECJ0EBE0K B 6.7/ C S.CER ECJ0EBE0K B.6/7.8 C S.CER ECJ0ECH0RB B 6./40. C S.CER ECJ0EBE0K B 6.6/4 C S.CER ECJ0ECH00B B 4/6.8 C S.CER ECJ0EBA04K B 7./40.6 C S.CER ECJ0ECH080C B 76./9. C S.CER ECJ0EBE0K B 7./40.6 C S.CER ECJ0EBE0K T 69./40. C S.CER ECJ0ECH00C B 69./40.6 C S.CER ECJ0EBA04K B 70./4. C S.CER ECJ0EBE0K B 69./4. C S.CER ECJ0ECH040B T 67./40. C S.CER ECJ0ECH0J T 70/6.4 C S.CER ECJ0EBE0K B 6.8/6.7 C S.CER ECJ0EBE0K T 6./7.8 C S.CER ECJ0EBE0K T 67./9. [MAIN-A UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION C S.CER ECJ0EBC0K T 67./6 C S.CER ECJ0ECH0J T 6.6/. C S.CER ECJ0ECH80J T 6.4/0. C S.CER ECJ0ECH470J T 60./6. C S.CER ECJ0EBE0K T 6.4/7.4 C S.CER ECJ0EB0J0K T 70.4/7. C S.CER ECJ0EBE0K T.6/6.8 C S.CER ECJ0EBE0K B 60.4/. C S.CER ECJ0ECH0J T./. C S.CER ECJ0ECHJ T.9/. C S.CER ECJ0ECHJ T.9/7 C S.CER ECJ0EBA04K T 6.9/9.4 C S.CER ECJ0EBE0K [USA-0] T 6.8/ S.CER ECJ0EBE0K [EXP-0] S.CER ECJ0EBE0K [CHN-0] C S.CER ECJ0EB0J0K T 6.8/49.8 C S.CER ECJ0EBE0K B 4.8/ C S.CER GRMBBC06KEL T 6.6/. C S.CER ECJ0EBC0K T 7.8/4.9 C S.CER ECJ0EBE0K T 7.8/0.7 C S.CER ECJ0EBE0K B 8.8/6.6 C S.CER C608 JB A 4K-T T 6.6/4.9 C S.CER ECJ0EBA04K T 60.6/. C S.CER ECJ0EBE0K T 66./4.9 C S.CER GRMMCH80JV0L (GRM4-6 CH) [EUR-0] T 7./ S.CER GRMMCH80JV0L (GRM4-6 CH) [EXP-0] C S.CER GRMMCH0JV0L (GRM4-6 CH) [EUR-0] T 9.9/ S.CER GRMMCH0JV0L (GRM4-6 CH) [EXP-0] C S.CER ECJ0ECH470J T /6.6 C S.CER ECJ0EBE0K T 6/6.6 C S.CER ECJ0ECH470J T 8./6.7 C S.CER ECJ0EBE0K T 79.8/68.8 C S.CER ECJ0EBE0K T 64.7/49.8 C S.CER ECJ0EBE0K B 87./0. C S.CER ECJ0EBE0K B 87./.9 C S.CER ECJ0ECH80J B 84.9/49. C S.CER ECJ0ECH470J B 78.8/. C S.CER ECJ0EBE0K B 8.7/48. C S.CER ECJ0ECH00C B 9./.4 C S.CER ECJ0ECHRB T 64./9. C S.CER ECJ0ECH00C B 97.7/4.4 C S.CER ECJ0ECH00C B 99/.7 C S.CER ECJ0EBE0K B 00.7/. C S.CER ECJ0EBE0K B 97.4/9. C S.CER ECJ0ECH470J B 90./49. C S.CER ECJ0EBE0K T 8./8. C S.CER ECJ0EBC0K B 8/49. C S.CER ECJ0EBE0K B 96./.7 C S.CER ECJ0EBE0K B 00.7/.7 C S.CER ECJ0ECH470J T 0.8/6.6 C S.CER ECJ0ECHR7B B 00.6/8. C S.CER ECJ0ECH0J B 98.8/8. C S.CER ECJ0ECH0J B 0./. C S.CER ECJ0EBC0K B 00.6/. C S.CER ECJ0EBE0K B 99.7/. C S.CER ECJ0ECH0RB B 0./ C S.CER ECJ0EBE0K B 07.7/.8 C S.CER ECJ0EBA04K B 07.7/.9 C S.CER ECJ0ECH470J B 04/0.8 C S.CER ECJ0ECH470J B 07.7/.8 C S.CER ECJ0ECH470J B 0/9. C S.CER ECJ0ECHJ B 06/6. C S.CER ECJ0ECH0J B 97.9/. C S.CER ECJ0ECH0J B 9.9/. C S.CER ECJ0ECH00B B 0/7.6 C S.CER ECJ0EBA04K T 9.8/. C S.CER ECJ0ECH0J B 04./7.6 C S.CER ECJ0ECH80J B 97.9/. C S.CER ECJ0EBE0K T 79./0 C S.CER ECJ0ECH00B B 98.8/. C S.CER ECJ0EBE0K T 97./.9 C S.CER ECJ0ECH470J B 0.6/8.7 C S.CER ECJ0EBA04K B 06./.7 C S.CER ECJ0EBA04K T 8./8.7 C S.CER ECJ0EBE0K T 77./. C S.CER ECJ0EBE0K T 78.4/. C S.CER ECJ0EBE0K T 80/. C S.CER ECJ0ECH470J B 98.8/8.7 C S.CER ECJ0EBE0K B 0.8/. C S.TAN TEESVA V 4M8R T 8.8/.4 C S.TAN TEESVA C M8R T 8.6/.4 C S.CER GRMBBC06KEL T 09.7/0. C S.TAN TEESVA V 4M8R T 8.7/.4 C S.CER ECJ0EBE0K T 99./. C S.CER ECJ0EBA04K T 77/.4 C S.CER ECJ0ECH470J T 74./.4 C S.CER ECJ0ECH470J T 7./.4 C S.CER ECJ0ECH470J T 76./.4 C S.CER ECJ0EBE7K T 8.6/.4 C S.CER ECJ0ECH060C B 9/0.4 C S.CER ECJ0ECH0J B 76.9/4.8 C S.CER ECJ0ECH00B B 86./. C S.CER ECJ0ECH060C B 94./. C S.CER ECJ0EBA04K B 8./6. C S.CER ECJ0ECH040B B 9.7/0.4 C S.CER ECJ0EBC0K B 84.7/.9 C S.CER ECJ0EBE0K T 9./4. C S.CER ECJ0EBC0K B 8/9.4 C S.CER ECJ0EBC0K B 80./6.4 C S.CER ECJ0ECH470J B 84.7/0. M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount 7 -

25 [MAIN-A UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION C S.CER ECJ0EBA68K B.4/. C S.CER ECJ0EBA47K B.4/.4 C S.CER ECJ0EBA47K B./. C S.CER ECJ0EBE0K T 9.7/. C S.CER ECJ0EBC0K T./ C S.CER ECJ0EBA04K T 4.6/9 C S.CER GRMBBC06KEL T 0./7.9 C S.CER ECJ0EBE0K T./9.6 C S.CER ECJ0ECH470J T 0.8/.7 C S.CER ECJ0EBC8K B.4/9.7 C S.CER ECJ0ECH0J B 6./9. C S.CER ECJ0EBA04K B 8.9/7.4 C S.TAN TEESVA0G476M8R T.9/0. C S.CER ECJ0EBA04K B 9.8/9. C S.CER ECJ0EBC0K B 8./9.6 C S.CER ECJ0EBA04K B 7.6/8 C S.CER ECJ0ECHJ B 4.9/9.6 C S.CER ECJ0EBA04K B 6.4/0 C S.CER ECJ0EBA04K B 6.9/.8 C S.CER ECJ0EBA04K B 7/7. C S.CER ECJ0EBA04K B./.9 C S.CER ECJ0EBE0K B 8.9/9. C S.CER ECJ0EBC0K B./0 C S.TAN TEESVA V 4M8R T 9.9/6.6 C S.CER ECJ0EBE0K T 97./7. C S.CER ECJ0EBE0K T 0.9/. C S.CER C608 JB A 0K-T T 0./ C S.CER ECJ0EBA04K T 76.4/. C S.CER ECJ0EBA04K T 77.4/8 C S.CER ECJ0EBA04K T 80./. C S.CER ECJ0EBA04K B 7.8/.4 C S.CER ECJ0ECH470J B 70.8/6.6 C S.CER ECJ0EBE0K B 7.9/. C S.CER ECJ0EBE0K B 7/4. C S.CER ECJ0EBE0K B 70/4. C S.CER ECJ0EBE0K B 69./4. C S.CER ECJ0ECH470J B 6./6.8 C S.CER ECJ0EBA04K T 6.9/9 C S.CER ECJ0EB0J474K B 6.9/9. C S.CER ECJ0EBC0K B 0./9.8 C S.CER ECJ0EBA04K B 6.6/8.6 C S.CER ECJ0EBA04K B 9./. C S.CER ECJ0EBHK B./9. C S.CER ECJ0EBA04K B 9.8/.7 C S.CER ECJ0EBC0K B./6.9 C S.CER ECJ0EBA04K B.7/6.9 C S.CER ECJ0EB0J0K B.6/6.6 C S.CER ECJ0EBE0K T./4 C S.ELE EEEFKE B /9. C S.ELE EEEFKC B 0./4.8 C S.ELE EEEFKE B 0./.7 C S.CER ECJ0EBE0K B.4/8.8 C S.CER ECJ0ECH470J B 0./9 C S.CER C0 JF H 04Z-T B 9.4/0.6 C S.CER ECJ0EBA04K T 7.8/4 C S.CER C0 JF H 04Z-T T 4./7. C S.CER ECJ0EBA04K T.7/4. C S.ELE EEEFKE B 7/4.7 C S.CER GRMBBC06KEL T 7.8/44 C S.CER ECJ0EBE0K T.7/8. C S.CER GRMBBC06KEL T 4./.7 C S.CER ECJ0EBE0K B./48. C S.CER ECJ0EBE0K T 07.7/46. C S.CER GRMBBC06KEL T 0./44.4 C S.CER GRMBBC06KEL B 9.4/4.4 C S.CER ECJ0EBE0K B 0.7/.8 C S.CER GRMBBC06KEL T 4./9.6 C S.CER ECJ0EBE0K T 07.7/7.4 C S.CER ECJ0EBE0K B 8.6/4 C S.CER ECJ0EBC0K B 7./8.9 C S.CER ECJ0EBA04K B 78./0. C S.CER GRMBBC06KEL B 76.9/9.8 C S.CER ECJ0ECH470J B 78.7/.7 C S.CER ECJ0EBE0K B 94./0.4 C S.CER ECJ0ECH00B B 94./9. C S.CER ECJ0EBEK B 9.8/.8 C S.CER ECJ0EBA04K T 4.9/6 C S.CER ECJ0EB0J0K T 4.9/. C S.CER ECJ0EBE0K T 4.9/6.9 C S.CER ECJ0EBE0K T 4.9/4. C S.CER ECJ0ECH470J B 6.6/0. C S.CER ECJ0EBE0K T 6.6/7. C S.CER ECJ0EBE0K T 4.9/.7 C S.CER ECJ0EB0J0K T./.7 C S.CER ECJ0ECH080C B 86./.8 C S.CER ECJ0ECH0J B 8.6/. C S.CER ECJ0ECH080C B 8/. C S.CER ECJ0ECH080C B 84./. C S.CER ECJ0EBE0K B 94/. C S.CER ECJ0ECH00C B 80.7/9. C S.CER ECJ0EBE0K B 8.6/6.4 C S.CER ECJ0ECH00C B 76.9/.7 C S.CER ECJ0ECH60J B 64./. C S.CER ECJ0ECH040B B 6.4/ C S.CER ECJ0ECH070C B 6.6/. C S.CER ECJ0ECH00B B 6.6/4.8 C S.CER ECJ0EBC0K B 67./.4 C S.CER ECJ0EBE0K B 9.4/.7 C S.CER ECJ0EBE0K T.8/.8 C S.CER ECJ0EBA04K T 49./. C S.CER ECJ0EBC0K T 0./.8 C S.CER ECJ0EBCK B 6.7/.9 C S.CER ECJ0EBE8K B 4.9/4.6 C S.CER ECJ0EBE8K B./4.6 [MAIN-A UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION C S.CER ECJ0EBA04K B./4.6 C S.CER ECJ0EBA9K T 9./8.6 C S.CER ECJ0EBA04K T 7./8.6 C S.CER ECJ0EBE68K T 7./7.7 C S.CER ECJ0EBCK T 7./. C S.TAN F9AMAABMA T 78.8/.9 C S.CER ECJ0ECH470J B 40.4/40.7 C S.CER ECJ0EBE0K B 9.4/. C S.CER ECJ0EBE0K T 8.6/.4 C S.CER ECJ0ECH070C B.7/40.4 C S.TAN F9V4MAABMA T 78./66 C S.CER ECJ0EBE0K B./9. C S.CER ECJ0EBE0K T./4. C S.CER ECJ0EBE0K T 9./0. C S.CER ECJ0EBA04K B /7.7 C S.CER ECJ0EBA68K T 9.4/.8 C S.CER ECJ0EBCK B.6/8.7 C S.CER ECJ0ECH00B B 98.8/0. C S.CER ECJ0ECH090C B 9./. C S.CER ECJ0ECHRB B 0./. C S.CER ECJ0ECH070C B 07.7/. C S.CER ECJ0EBA04K T 0.6/4. C S.CER ECJ0EB0J0K B 9.4/8 C S.CER ECJ0ECH00B B 07./6.7 C S.CER ECJ0EBA04K B 6.7/6. C S.CER ECJ0EBE0K T./6. C S.CER ECJ0EBCK T 6.4/7.9 C S.CER ECJ0ECH470J T 79.8/67.8 C S.CER ECJ0EBE0K B 69./6.6 C S.CER ECJ0ECH680J B 9./7. C S.CER ECJ0EBE0K B 9./68. C S.CER ECJ0ECH680J B 9.9/68. C S.CER ECJ0EBE0K B 06./9 C S.CER ECJ0EBE0K T 60./67. C S.CER ECJ0EBE0K B./64.9 C S.CER ECJ0ECH00B B 07./.8 C S.CER ECJ0ECH680J B 6.7/6.6 C S.CER ECJ0EBE0K B /4.9 C S.CER ECJ0EBC0K B 0./0.7 C S.CER ECJ0ECH0J B 90.7/9. C S.CER ECJ0ECH0J B 90/8. C S.CER ECJ0EBE0K B 7.8/9. C S.CER ECJ0EBA04K T 6.4/6. C S.CER ECJ0EBA04K T 9./9.4 C S.CER ECJ0EBA04K T./. C S.CER C608 JB E 04K-T T 0./48.7 C S.CER ECJ0ECH470J B 74.6/40.6 C S.CER ECJ0EBE0K B 7.7/40.6 C S.CER ECJ0ECH80J B 6./9. C S.CER ECJ0EBA04K T.8/. C S.CER ECJ0EBA04K T 4.7/0.4 C S.CER ECJ0EBA04K T.9/9. C S.CER ECJ0EBC0K B 9.6/. C S.CER ECJ0EBC0K T 47.4/8.6 C S.CER ECJ0EBC0K B 9.6/. C S.CER ECJ0ECH80J T 88./64. C S.CER GRMMCH0JV0L (GRM4-6 CH) [USA-0] B 6./ S.CER GRMMCH0JV0L (GRM4-6 CH) [EXP-0] S.CER GRMMCH0JV0L (GRM4-6 CH) [CHN-0] C S.CER GRMMCH80JV0L (GRM4-6 CH) [USA-0] B / S.CER GRMMCH80JV0L (GRM4-6 CH) [EXP-0] S.CER GRMMCH80JV0L C404 (GRM4-6 CH) [CHN-0] S.CER GRMMCH0JV0L (GRM4-6 CH) B 0.4/8.7 C S.CER ECJ0EBE0K B 4.9/7.9 C S.CER ECJ0EBE0K B 8/.6 C S.CER ECJ0EBE0K [USA-0] T 4./ S.CER ECJ0EBE0K [EXP-0] S.CER ECJ0EBE0K [CHN-0] C S.CER ECJ0ECHJ B.4/9.7 C S.CER ECJ0EBE0K T 4.9/8 C S.CER ECJ0EBE0K B 6.7/9.6 C S.CER ECJ0ECH0J B 7/44. C S.CER ECJ0ECH040B B 4.6/49.8 C S.CER ECJ0ECH470J T 40./ C S.CER GRMBBC06KEL T 67.9/.9 C S.CER ECJ0ECH00B B 88.6/60.4 C S.CER ECJ0EBE0K B 7./.7 C S.CER ECJ0EBE0K B 8/8. C S.CER ECJ0ECH470J B 8/7. C S.CER ECJ0ECH80J B 88./8. C S.CER ECJ0EBE0K B 8/6.4 C S.CER ECJ0EBE0K T 8./8. C S.CER ECJ0ECHJ T.9/7.9 C S.CER ECJ0EB0J0K T 8/6. C S.CER ECJ0ECH680J B.4/60.6 C S.CER ECJ0ECH470J B 4./6.8 C S.CER ECJ0EBE0K B 78.9/68.8 C S.CER ECJ0ECH680J B 4./68.9 C S.CER ECJ0EBE0K B 4./67. C S.CER ECJ0ECH680J B 80/68.8 C S.CER ECJ0ECHJ T 60./68. C S.CER ECJ0EBE0K T 8.8/48.7 C S.CER ECJ0ECH680J T 8./.9 C S.CER ECJ0EBE0K T 88/8.9 C S.CER ECJ0EBE0K T 84.7/49.8 C S.CER ECJ0EBE0K T 8./8.4 C S.CER ECJ0ECHJ T 84./40.8 M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount 7-4

26 [MAIN-A UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION C S.CER ECJ0EBE0K T 7./7.7 C S.CER ECJ0EBE0K T 7/40.4 C S.CER ECJ0EBE0K T 7.9/40.4 C S.CER ECJ0EBE0K T.8/9.8 C S.CER ECJ0EBE0K T 0.9/. C S.CER GRM88BE0KA7D T.8/49. J S.CON AXK4047YG T /8. J S.CON 40FLT-SM-TB(LF)(SN)(M) T 67./0.6 J CON HSJ J S.CON BB-ZR-SM4-TF(LF)(SN) T 0/7. J S.CON BB-ZR-SM4-TF(LF)(SN) T 0./7. S S.I MINISMDC00F- CN T 4./.8 W JUM ERDST0 W CAB OPC-9C <TJM>! EP S.BEA MMZ00Y0C-T B 06./4.8 EP BEA HF70BB4.XX.6 [USA-0] BEA HF70BB4.XX.6 [EXP-0] BEA HF70BB4.XX.6 [CHN-0] EP BEA HF70BB4.XX.6 [USA-0] BEA HF70BB4.XX.6 [EXP-0] BEA HF70BB4.XX.6 [CHN-0] EP BEA HF70BB9.X0.4X4.9 EP BEA HF70BB9.X0.4X4.9 EP S.BEA MMZ00Y0C-T B 84.7/4.8 EP S.BEA MMZ00Y0C-T T 84./8.7 EP S.BEA MMZ00Y0C-T T 0./.8 MP S.CAS 79 VCO CASE Y4 B 99./7. [FRONT UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION IC 4000 S.IC HD64F8BTFV (FX-79A) B 67.8/ IC S.IC S-8094CNMC-G9CTG B 89./9. IC 0040 S.IC S-4CS64A0I-T8TG B 90./.7 IC S.IC NJM90V-TE-#ZZZB B./. IC S.IC LC784W-TLM-E B 4/. Q 0008 S.TRA SC46-BL(TE8R,F) B.6/6. Q S.TRA DTC4TUA T06 B.7/9.8 Q S.TRA DTC44EUA T06 B /7 Q S.TRA DTC4TUA T06 B.7/. D S.ZEN MAZ806GML T.4/7. D S.ZEN MAZ806GML T./7. D S.ZEN MAZ806GML B 8./. D S.DIO MAS0GL B 6.6/.7 D S.DIO MAS077G0L B 78/.8 X S.XTA CR-774 SMD-49TB.88 MHz B 8./6. L S.COI MLF608E 00K-T B.6/7. L S.COI NLVT-R0J B 9./9.7 R S.RES ERJGEJ 8 X (80) B.7/6. R S.RES ERJGEJ 8 X (80) B 6.6/6. R S.RES ERJGEJ 47 X (470) B 7./6. R S.RES ERJGEJ 9 X B./8 R S.RES ERJGEJ 7 X (.7K) B 4.7/8 R VAR RK09D0AN R S.RES ERJGEJ 0 X (K) B 7./7. R S.RES ERJGEJ 0 X (K) B 6./. R S.RES ERJGEJ 04 X (00K) T 8./7. R S.RES ERJGEJ 04 X (00K) B 9.7/. R S.RES ERJGEJ 84 X (80K) B 6./9.9 R S.RES ERJGEJ 6 X (6K) B 6./0.8 R S.RES ERJGEJ X (K) B 6./.7 R S.RES ERJGEJ 47 X (47K) B 0.9/7.9 R S.RES ERJGEJ 47 X (47K) B 0.9/7 R S.RES ERJGEJ X (K) B.6/8.8 R S.RES ERJGEJ 47 X (47K) B 9./7 R S.RES ERJGEJ 47 X (47K) B 6.9/7.9 R S.RES ERJGEJ 47 X (4.7K) B 0.9/6. R S.RES ERJGEJ 8 X (8K) B.6/7.9 R S.RES ERJGEJ X (K) B 0.9/. R S.RES ERJGEJ X (K) B 0.9/4. R S.RES ERJGEJ X (K) B 0.9/.4 R S.RES ERJGEJ 68 X (68K) B 0.9/. R S.RES ERJGEJ 68 X (68K) B 0.9/0.6 R S.RES ERJGEJ 68 X (68K) B 9./. R S.RES ERJGEJ 68 X (68K) B 9./.4 R S.RES ERJGEJ 68 X (68K) B 9./. R S.RES ERJGEJ 47 X (47K) B /6. R S.RES ERJGEJ 7 X (7K) B /7.9 R S.RES ERJGEJ 47 X (47K) B.6/7.9 R S.RES ERJGEJ 9 X (9K) B./7.9 R S.RES ERJGEJ 4 X (0K) B.8/7 R S.RES ERJGEJ 0 X (M) B.6/8.8 R S.RES ERJGEJ 0 X (K) B.4/. R S.RES ERJGEJ 7 X (.7K) B.4/. R S.RES ERJGEJ-JPW B 8/8. R S.RES ERJGEJ 04 X (00K) B 9./.7 R S.RES ERJGEJ 0 X (0K) B 8.8/.6 R S.RES ERJGEJ 04 X (00K) B 84/8.6 R S.RES ERJGEJ 0 X (K) B 9.7/9.9 R S.RES ERJGEJ 04 X (00K) B 8.8/. R S.RES ERJGEJ 0 X (0K) B 4./4.6 R S.RES ERJGEJ 0 X (0K) B 47/4.6 R S.RES ERJGEJ 0 X (0K) B 44./4.6 R S.RES ERJGEJ 0 X (K) T 0.4/7. R S.RES ERJGEJ X (.K) B 7./9. R S.RES ERJGEJ 47 X (47K) B 4./4. R S.RES ERJGEJ 04 X (00K) B 9/4.6 R S.RES ERJGEJ 04 X (00K) B 40.8/4.6 R S.RES ERJGEJ 04 X (00K) B 9.9/4.6 R S.RES ERJGEJ 94 X (90K) B.8/4. R S.RES ERJGEJ X (K) B 77.4/4.9 R S.RES ERJGEJ X (K) B 77.4/.7 R S.RES ERJGEJ X (K) B 78.8/. R S.RES ERJGEJ 04 X (00K) B 7.7/4.9 R S.RES ERJGEJ 00 X (0) B 77.4/.8 R S.RES ERJGEJ 0 X (M) B 78.8/7. R S.RES ERJGEJ 0 X (0K) B 86.7/8. R S.RES ERJGEJ 0 X (K) B 74/9.4 R S.RES ERJGEJ 0 X (K) B 7.6/0.9 R S.RES ERJGEJ-JPW B 9.7/7.7 R S.RES ERJGEJ 0 X (K) B 7./. R S.RES ERJGEJ 0 X (K) B 7./. R S.RES ERJGEJ 04 X (00K) B 7.7/.8 R S.RES ERJGEJ 04 X (00K) B 78/.8 R S.ARR EXB0JX B 7./. R S.RES ERJGEJ 0 X (K) B 60.6/7. R S.RES ERJGEJ 0 X (K) B 7/.7 R S.RES ERJGEJ 0 X (K) B 7.9/4.6 R S.RES ERJGEJ 0 X (K) B 7./4.9 R S.RES ERJGEJ 0 X (K) B 7.7/0. R S.RES ERJGEJ 0 X (K) B 7.9/.8 R S.RES ERJGEJ 0 X (K) B 7./. R S.RES ERJGEJ 04 X (00K) B 8.9/7. R S.RES ERJGEJ 0 X (K) B 8.9/8. R S.RES ERJGEJ 0 X (K) B 8.9/9. M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount 7 -

27 [FRONT UNIT] REF PARTS H/V NO. NO. DESCRIPTION M. LOCATION R S.RES ERJGEJ 0 X (M) B 78/8. R S.RES ERJGEJ 0 X (0K) B 0.9/. C S.CER ECJ0EBH68K B 4./. C S.CER ECJ0ECH470J B 84/7.7 C S.CER ECJ0ECH470J B 8./6. C S.CER ECJ0ECH470J B 47./ C S.CER ECJ0ECH470J B 6.4/. C S.CER ECJ0ECH470J B 8/7.6 C S.CER ECJ0ECH470J B 6./.6 C S.CER ECJ0EBE0K B.7/7. C S.CER ECJ0EBE0K T./7. C S.CER ECJ0EBE0K T 0./. C S.CER ECJ0ECH470J T 7./7. C S.CER ECJ0EBE0K T 8./. C S.CER ECJ0EBE0K B 9./8.8 C S.CER ECJ0EBCK B 9./7.9 C S.CER ECJ0EBA04K B 9./6. C S.CER ECJ0EBE8K B 6.9/8.8 C S.CER ECJ0EBA04K B.6/7 C S.CER ECJ0EBE0K B 0.9/9.7 C S.CER ECJ0EBE0K B 9./0.6 C S.CER ECJ0EBH9K B 6./8. C S.CER ECJ0EBC0K B 9./4. C S.CER ECJ0ECH470J B 4.4/8. C S.CER ECJ0EBC0K B.8/8.8 C S.CER ECJ0EBA04K B /7 C S.CER ECJ0EBE7K B.8/7.9 C S.CER ECJ0EBA04K B./8. C S.TAN TEESVA 0J 06M8R B./6. C S.CER ECJ0EBA04K B.4/4. C S.CER ECJ0ECH470J B 6.4/4. C S.CER ECJ0EBA04K B 8.8/6.8 C S.CER ECJ0ECH470J B 8.6/ C S.CER ECJ0ECH470J B 78.8/9. C S.CER ECJ0EBE0K B /8.8 C S.CER ECJ0ECH470J B 6./9. C S.CER ECJ0ECH470J B 6/9. C S.CER ECJ0ECH470J B 67.4/.7 C S.CER ECJ0ECH470J B 6.7/.7 C S.CER ECJ0EBA04K B 46./4.6 C S.CER ECJ0EBA04K B./8.8 C S.CER ECJ0EBA47K B 7.6/0.9 C S.CER ECJ0EBE0K B 8.9/7. C S.CER ECJ0EBA04K B 47.9/4.6 C S.CER ECJ0EBA04K B 4.4/4.6 C S.CER ECJ0EBE0K T 9./7. C S.CER ECJ0ECH470J B./6. C S.CER ECJ0ECH470J B./8. C S.CER ECJ0ECH470J B.8/6. C S.CER ECJ0ECH470J B 9./9.7 C S.CER ECJ0EBA04K B 0.9/8 C S.CER ECJ0EBE0K B 6.9/9. C S.CER ECJ0EBA04K B 76./. C S.CER ECJ0EBA04K B 77.4/.8 C S.CER ECJ0EBA04K B 7./. C S.CER ECJ0ECH0J B 78.8/.4 C S.CER ECJ0ECH080C B 77.4/6.7 C S.CER ECJ0ECH0J B 77.4/7.6 C S.CER ECJ0EBA7K B 9./8. C S.CER ECJ0EBA04K B 86.7/ C S.TAN TEESVB 0J 476M8R B 6./6.8 C S.CER C608 JB 0J 47K-T B 78/8.9 C S.CER ECJ0ECH470J B 6.9/ C S.CER ECJ0EBA04K B 7.8/8.9 C S.CER ECJ0EBA04K B 78/0 C S.CER ECJ0EBA04K B 78/0.9 C S.CER ECJ0EBA04K B 78/4.9 C S.CER ECJ0EBA04K B 78/. C S.CER ECJ0EBA04K B 78/4 C S.CER ECJ0EBE0K B 76./9.4 C S.CER ECJ0EBA04K B 9.7/8.6 C S.CER ECJ0EBA04K B.8/ C S.CER ECJ0EBE0K B./4. C S.CER ECJ0EBA04K T 4.6/9. C S.CER ECJ0EBE0K T.7/9. C S.CER ECJ0EBE0K B 8.7/8.6 C S.CER ECJ0EB0J0K B.6/. J CON <KIN> J S.CON 40FLT-SM-TB(LF)(SN)(M) B 70.9/.7 J 6000 S.CON 4FLT-SM-TB(LF)(SN)(M) B.8/8. DS S.LED SML-YTT86 T 64.8/. DS S.LED SML-YTT86 T 8./. DS S.LED SML-YTT86 T.6/. DS S.LED SML-YTT86 T.8/. DS S.LED SML-YTT86 T 8.4/. DS S.LED SML-YTT86 T 4/. DS S.LED SML-YTT86 T 8./. DS S.LED SML-YTT86 T 6./ DS S.LED SML-YTT86 T 6./ DS LCD A0B0X 79 LCD W CAB OPC-046B-(P0.,N40,L) <TJM> EP LCD SRCN-6-SP-N-W (SHJ) M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side) S.=Surface mount 7-6

28 SECTION 8. MECHANICAL PARTS [CHASSIS PARTS] REF NO. ORDER NO. DESCRIPTION J MR-DSE-0 W** OPC-99 MP CHASSIS- [EUR-0] CHASSIS- [EXP-0] CHASSIS- [RUS-0] LONG CHASSIS- [USA-0] LONG CHASSIS- [EXP-0] LONG CHASSIS- [CHN-0] LONG CHASSIS- [RUS-0] MP COVER- MP SCREW BT B0 X8 NI-ZC (BT) 8 MP SCREW BT B0 X8 NI-ZC (BT) MP SCREW BT B0 X8 NI-ZC (BT) MP SCREW BT B0 X8 NI-ZC (BT) MP SCREW BT B0 X8 NI-ZK (BT) 4 MP SCREW BT B0 X8 NI-ZK (BT) [FRONT UNIT] REF NO. ORDER NO. DESCRIPTION R RK09D0AN J J* FLT-SM-TB (LF) (SN) (M) J* FLT-SM-TB (LF) (SN) (M) DS A0B0X SP 000 C0SB00-4 W** OPC-046B- QTY. QTY. [ACCESSORIES] REF NO. ORDER NO. DESCRIPTION MC (Optional) HM- W (Optional) OPC-94A [EUR-0] (Optional) OPC-94A [EXP-0] (Optional) OPC-94A [RUS-0] (Optional) OPC-A [USA-0] (Optional) OPC-A [EXP-0] (Optional) OPC-A [CHN-0] (Optional) OPC-A [RUS-0] W OPC-049A MP MOBIL BRACKET- (Incl. MP) MP FELT MP FLANGE BOLT M4X8 NI 4 MP SCREW PH (+-) MX ZC 4 MP SCREW BT A0 X0 ZC 4 MP FLAT WASHER M BS NI 4 MP SPRING WASHER M ZC 4 MP NUT M ZC 4 MP MIC HANGER MP LCD LABEL MP SCREW BT A0 X6 SUS MC W MP9 MP0* MP MP W QTY. EP SRCN-6-SP-N-W MP FRONT PANEL ASSY (Incl. SP, MP, ) MP WINDOW PLATE MP SHIELD PLATE (Incl. MP4) MP EARTH SPRING MP KEYBOARD MP KNOB N-86 (Incl. MP7) MP KNOB SPRING NO.660 MP LCD PLATE MP REFLECTOR MP LCD FILTER MP SP NET MP VOL RUBBER MP SCREW BT B0 X8 NI-ZC (BT) MP6 MP7 MP8 MP MP MP4 (M ) MP (M 0) [MAIN-A UNIT] REF NO. ORDER NO. DESCRIPTION J* AXK4047YG J* FLT-SM-TB (LF) (SN) (M) J HSJ J6* BB-ZR-SM4-TF (LF) (SN) J7* BB-ZR-SM4-TF (LF) (SN) QTY. * Used for labelling the programmable function keys according to their assinged functions. S* MINISMDC00F W* ERDST0 W OPC-9C EP* HF70BB4.XX.6 [USA-0] HF70BB4.XX.6 [EXP-0] HF70BB4.XX.6 [CHN-0] EP* HF70BB4.XX.6 [USA-0] HF70BB4.XX.6 [EXP-0] HF70BB4.XX.6 [CHN-0] EP4* HF70BB9.X0.4X4.9 EP* HF70BB9.X0.4X4.9 MP VCO CASE MP VCO COVER MP M-PLATE MP4* EARTH SPRING- *: Refer to BOARD LAYOUTS for the location. **: Refer to GENERAL WIRING for the connection Screw abbreviations A, B0, BT: Self-tapping PH: Pan head ZK: Black NI-ZU: Nickel-Zinc SUS: Stainless 8 -

29 MP8 (C) x MP4 (C) x J (C) W (MA) MP (C) J4 (MA) MAIN UNIT IC (MA) IC8 (MA) MP (MA) MP6 (C) MP (C) x R4 (F) MP (F) MP (MA) MP (MA) MP (F) MP (F) x MP (C) MP0 (F) MP9 (F) EP (F) J (F) MP (C) MP (C) x8 DS (F) W (F) MP8 (F) MP (F) FRONT UNIT MP (F) MP6 (F) SP (F) MP7 (C) x4 MP (F) Unit abbreviations (F): FRONT UNIT (MA): MAIN-A UNIT (C): CHASSIS PARTS MP (F) 8 -

30 9 - SECTION 9. BOARD LAYOUTS MAIN-A UNIT (TOP VIEW) FRONT UNIT (TOP VIEW) SP+ SP SP (FRONT UNIT) ANT CONNECTOR MP4 J (CHASSIS) AF OUT AF The combination of top side and bottom side of this page shows the actual configuration of P.C. board. UNLK DIM TONE SDEC NOIS SI CCS MIC AFO SO TEMP EXOE OPV CDEC PLST TENC BATV CPU EXST LVIN DSDA PGIO OPT PTTO EPTT PWON CIRQ DAST PGIO PGIO4 OPT OPT BEEP PTTI BEPO RMUT SO AFONO AFOUT NC NC NC NC NC NC NC CCS MMUTE SI REM NC NC NC BUSY SIGO OPT OPT MCIN CIRQ OPT DAST OPV MCOT PTTO PTTI EXST (OPV) (OPV) IN VCC HV EP4 EP Ext.I/O 4(EPTT) Ext.I/O 7 (AFO) Ext.I/O (HORN) Ext.I/O6 (DIM/IG) Ext.I/O 0(SERIAL) Ext.I/O 4 (SERIAL) EP EP C9 C C C C C C6 C8 C9 C60 C6 C6 C6 C64 C6 C66 C68 C69 C70 C7 C7 C7 C7 C76 C77 C79 C80 C8 C8 C8 C84 C8 C86 C87 C88 C0 C07 C C C C7 C40 C4 C4 C4 C46 C47 C48 C49 C0 C C C C4 C C6 C70 C7 C7 C74 C7 C76 C80 C9 C96 C97 C98 C00 C0 C0 C4 C4 C6 C6 C64 C66 C67 C68 C70 C7 C74 C7 C88 C89 C90 C9 C9 C94 C9 C C C4 C0 C C C C0 C7 C4 C47 C48 C0 C7 C6 C6 C64 C7 C8 C84 C8 C88 C94 C9 C96 C98 C40 C4 C46 C44 C4 C46 C46 C464 C47 C47 C47 C474 C47 C476 C477 C478 C479 C480 C48 C48 C48 C484 CP CP8 D D D D8 D7 D47 D48 D6 D6 D7 D9 D6 D6 D6 D6 EP8 EP9 FI FI IC IC IC IC IC4 IC4 IC9 IC9 IC0 IC0 J J J6 J7 L4 L4 L L L0 L46 L47 L4 Q Q Q4 Q4 Q Q Q Q Q6 Q6 Q7 Q7 Q8 Q8 Q9 Q9 Q0 Q0 Q Q Q4 Q4 Q6 Q6 Q0 Q0 Q Q Q7 Q7 Q9 Q9 Q40 Q40 Q4 Q44 Q44 R R R4 R R7 R8 R4 R4 R4 R44 R4 R46 R48 R49 R R R R R6 R8 R9 R77 R89 R90 R9 R9 R9 R9 R96 R97 R98 R00 R0 R0 R R R R4 R8 R9 R R9 R0 R R4 R R7 R4 R4 R44 R4 R46 R47 R48 R49 R0 R8 R86 R98 R99 R00 R0 R04 R0 R09 R0 R R R R8 R7 R0 R8 R47 R48 R49 R0 R R R R6 R R4 R6 R6 R6 R7 R8 R90 R9 R R4 R R6 R7 R9 R0 R R R7 R R R4 R6 R7 R8 R48 R49 R0 R R R R4 R R7 R8 R9 R6 R6 R7 R7 R74 R77 R78 R8 R9 R9 S BLK 4 7 PTT W E 6 8 LV IC8 RED J J J7 J6 - -R -T MIC D -NWC TXC- J F I K G A C B REM BUSY- CUT B709B A.B W W CPU VCC LCD TYPE VHF PLL UT-09R UT-0R -EPTT -DIM -PWON -AFON -SDEC BAL- MOD- -VREF -SO - -TMUT -T -SQIN T -UNLK CDEC- -RMUTC - -HORNO RXC- -MCIN -SPAF -MCGO VRAF TONE- -TLVA RLVA -TENC MCIN- -BEEP H0 H H0 H H0 H H0 H H40 H4 H0 H H60 H6 H70 H7 H80 H8 H90 H9 H00 H0 H0 H H0 H H0 V0 V V0 V V0 V V0 V V40 V4 V0 V V60 V6 V70 C9 C0 C C C8 C8 C9 D D DS DS DS DS4 DS DS6 DS7 DS8 DS9 J R4 R4 R8 R76 H0 H H0 H H0 H H0 H H40 H4 H0 H H60 H6 H70 H7 H80 H8 H90 H9 V0 V V0 V V0 V V0

31 9 - MAIN-A UNIT (BOTTOM VIEW) FRONT UNIT (BOTTOM VIEW) The combination of top side and bottom side of this page shows the actual configuration of P.C. board. AFO CPU PGIO4 MIC BATV CCS EXST UNLK PLST SI SO TENC OPV BEEP LVIN TONE DAST CDEC TEMP SDEC PGIO M D I PWON OPT CIRQ NOIS EPTT EXOE OPT OPT PTTO PTTI DSDA PGIO C C C C4 C C6 C7 C8 C4 C C6 C7 C9 C0 C C C C4 C C6 C7 C8 C9 C C4 C6 C7 C8 C4 C0 C4 C69 C74 C7 C76 C77 C78 C79 C80 C8 C8 C84 C8 C87 C9 C0 C0 C0 C04 C0 C06 C07 C C C C4 C C6 C7 C8 C9 C0 C C4 C C6 C0 C D D D6 IC IC IC IC IC6 J J L L Q Q Q Q R7 R8 R9 R R R R6 R9 R0 R R R R4 R R6 R7 R8 R9 R R R4 R R6 R7 R8 R9 R40 R4 R4 R4 R44 R4 R46 R47 R48 R R8 R60 R6 R68 R7 R74 R7 R77 R78 R8 R8 R84 R90 R0 R0 R0 R04 R0 R06 R07 R08 R09 R0 R R R R4 R R6 R7 R8 R9 R0 R R R R4 R R7 R8 X B709C AFO -CLI MICI CLO AFVI COM 4 AFVI DUSE- IPTT- -KR0 -KR KS4- -TONE -BEEP KR -SO CPU- KS0 PO SENC- -CLO CLI- -AFO IPTT -CPU NOIS LSO KR CDEC SDEC BATV LVIN RES MD OPT OPT PWON -L OPT RES IC IC IC6 MIC- V0H0 H H0 H H0 H H0 H H40 H4 H0 H H60 H6 H70 H7 H80 H8 H90 H9 V V0 V V0 V V0 C C C C4 C C6 C7 C8 C0 C C C4 C C7 C8 C9 C0 C C C6 C7 C8 C9 C0 C C C4 C C6 C7 C8 C9 C40 C4 C4 C4 C44 C4 C46 C48 C49 C0 C C C4 C7 C67 C74 C78 C90 C9 C9 C94 C99 C00 C0 C0 C04 C0 C08 C06 C09 C0 C C4 C C6 C7 C8 C9 C0 C C C C4 C6 C7 C9 C C4 C6 C8 C9 C44 C4 C6 C7 C8 C9 C60 C6 C6 C64 C6 C66 C67 C68 C69 C77 C78 C79 C8 C8 C8 C84 C8 C86 C87 C88 C89 C90 C0 C04 C07 C08 C09 C0 C6 C44 C4 C46 C47 C49 C0 C C C C C C6 C6 C8 C8 C9 C60 C6 C6 C6 C69 C7 C7 C76 C80 C8 C8 C84 C8 C86 C87 C9 C97 C98 C99 C00 C0 C0 C0 C04 C0 C06 C07 C08 C09 C0 C C6 C7 C8 C C C9 C4 C49 C C C4 C C6 C9 C60 C6 C66 C67 C68 C69 C7 C7 C76 C77 C78 C79 C80 C8 C8 C90 C9 C9 C97 C99 C40 C40 C404 C408 C409 C4 C47 C440 C44 C46 C47 C48 C49 C460 C46 C46 C466 C467 C468 C469 C470 D D D4 D6 D8 D9 D0 D D D D D4 D D6 D8 D D D6 D9 D D D4 D4 D4 D4 D4 D44 D4 D D D4 D D8 D60 EP EP7 FI FI FI4 FI FI6 IC4 IC4 IC IC IC6 IC6 IC7 IC7 IC8 IC8 IC9 IC9 IC0 IC0 J4 L L L L L L L6 L6 L7 L7 L8 L8 L9 L9 L L L L6 L6 L L L L L6 L7 L8 L L L L L6 L7 L8 L9 L4 L4 L44 L4 L MP Q Q Q Q Q9 Q9 Q0 Q Q Q Q4 Q Q Q7 Q7 Q8 Q8 Q9 Q9 Q Q4 Q4 Q Q Q6 Q6 R R4 R R6 R7 R8 R8 R9 R0 R R R R4 R R6 R7 R9 R0 R R R R6 R7 R8 R9 R0 R R6 R9 R40 R0 R4 R7 R67 R68 R69 R70 R7 R7 R74 R7 R76 R78 R79 R80 R8 R84 R8 R86 R04 R0 R06 R0 R R6 R7 R0 R R R4 R R6 R7 R8 R8 R9 R6 R9 R84 R8 R87 R88 R9 R9 R9 R94 R9 R97 R0 R0 R R0 R R R R4 R R6 R8 R9 R R R4 R R6 R7 R40 R4 R4 R4 R44 R4 R69 R70 R87 R97 R98 R99 R00 R0 R0 R04 R0 R R R6 R8 R9 R0 R9 R40 R4 R4 R4 R6 R60 R6 R68 R70 R7 R7 R8 R8 R84 R8 R86 R87 R88 R90 X X X X -MCIN -AFOUT LVIN NARROW W/N B709B,t=.6,() -T -MOD - BAL- TXC- - NWC- -TONE -T -T TENC- -VREF -CPU -HORNO DIM- BEEP- -AFON CDEC SDEC- -RLVA TLVA RXC TXC -AFO EPTT- -OPV -MCOT -REF -R V0H0 H H0 H H0 H H0 H H40 H4 H0 H H60 H6 H70 H7 H80 H8 H90 H9 H00 H0 H0 H H0 H H0 V V0 V V0 V V0 V V40 V4 V0 V V60 V6 V70

32 SECTION 0 GENERAL WIRING FRONT UNIT MAIN-A UNIT CHASSIS UNIT J ANTENNA CONNECTOR J4 MICROPHONE CONNECTOR J CLO AFO PTT MICE MIC CLI TONE TENC NOIS EXOE EXST UNLK PLST CDEC SDEC OPV LVIN TEMP BATV DSDA PGIO CPU AFO J DIM DAST OPT OPT OPT PTTO PTTI PGIO SI SO CIRQ CCS MIC EPTT PGIO4 PWON BEEP FRONT UNIT W OPC-046B TONE TENC NOIS EXOE EXST UNLK PLST CDEC SDEC OPV LVIN TEMP BATV DSDA PGIO CPU AFO J DIM DAST OPT OPT OPT PTTO PTTI PGIO SI SO CIRQ CCS MIC EPTT PGIO4 PWON BEEP J OPV EXST(OPV) 0 DAST(OPV) 9 SI 8 SO OPT7 4 OPT 6 CIRQ OPT 6 CCS SIGO4 7 REM BUSY 8 9 AFOUT 0 0 RMUT 9 BEPO MCIN 8 AFONO 7 4 MMUTE MCOT 6 PTTO 6 PTTI (OPTIONAL UNIT SLOT) EXT. SPEAKER JACK OPTIONAL CABLE OPC-99 PIN ASSIGNMENT t q!!!0 y q (COMMON) w Det. AF OUT (40 mvrms ± db at khz 60 % Dev., kω) e (INPUT) r Ext. I/O 4 (H: V, L: 0V) or RXD (RS-C) t N/C y Ext. I 6 (H: 0 V, L: 0V) or Ignition (Active: Power ON, Inactive: Power OFF) u Ext. I/O 7 (H: V, L: 0V) or AF OUT (00 mvrms ± db at khz 60 % Dev.) i (Det. AF) o N/C!0 Ext. I/O 0 (H: V, L: 0V) or TXD (RS-C)! Ext.O HORN OUT (00 ma max.; Open corrector)! (AF OUT)! Mod. IN (40 mvrms ± db at khz 60 % Dev.)!4 Ext. I/O 4 (H: V, L: 0V) or Ext. PTT (H: PTT OFF, L: PTT ON)! VCC OUTPUT (0. A max.) J VCC Ext.I/O 6 (DIM/IG) Ext.I/O (HORN) Ext.I/O 7 (AFO) IN Ext.I/O 4(EPTT) Ext.I/O 4 (SERIAL) EXt.I/O 0(SERIAL) For OPC-99 (OPTIONAL PRODUCT) HV W SPEAKER SP CHASSIS UNIT W OPC J7 DC POWER CABLE 0 -